4
N a tio n a l F o a m
MATERIAL SAFETY DATA SHEET #NMS300
Aer-O-Lite 3%
AQUEOUS FILM FORMING FOAM (AFFF) Liquid Concentrate
Section 1. CHEMICAL PRODUCT/COMPANY IDENTIFICATION
Material Identification
Product: Aer-O-Lite 3%, Fire Fighting Foam Concentrate
Synonyms: Aqueous Film Forming Foam (AFFF)
CAS No: Mixture - No single CAS # applicable
Company Identification
Manufacturer:
National Foam, Inc.
180 Sheree Boulevard, Suite 3900
P.O. Box 695
Exton, PA 19341-0695
Emergency Phone Number (Red Alert): (610) 363-1400 (U.S.A.)
Fax (610) 524-9073
www.Kidde-Fire.com
Section 2. COMPOSITION / INFORMATION ON INGREDIENTS
Components CAS Number % Weight
Water 7732-18-5 61-88%
1, 2 Propanediol 57-55-6 5-15%
Synthetic Detergents No single CAS # applicable 4-10%
(2-Methoxymethylethoxy) Propanol 34590-94-8 3-10%
Fluoroalkyl Surfactant Confidential 0.5-2.0%
NMS#300 Page 1 of 8 10/01/07
Section 3. HAZARDS IDENTIFICATION
Potential Health Effects
Inhalation
Vapors are minimal at room temperature. If product is heated or sprayed as an aerosol, airborne
material may cause respiratory irritation.
Skin Contact
Contact with liquid may cause moderate irritation or dermatitis due to removal of oils from the
skin.
Eye Contact
Product is an eye irritant.
Ingestion
Not a hazard in normal industrial use. Small amounts swallowed during normal handling
operations are not likely to cause injury; swallowing large amounts may cause injury or
irritation.
Additional Health Effects
Existing eye or skin sensitivity may be aggravated by exposure.
Carcinogenicity Information
No data available.
Section 4. FIRST AID MEASURES
Inhalation
No specific treatment is necessary since this material is not likely to be hazardous by inhalation.
If exposed to excessive levels of airborne aerosol mists, remove to fresh air. Seek medical
attention if effects occur.
Skin Contact
In case of skin contact, wash off in flowing water or shower. Launder clothing before reuse.
Eye Contact
In case of eye contact, flush eyes promptly with water for 15 minutes. Retract eyelids often to
ensure thorough rinsing. Consult a physician if irritation persists.
Ingestion
Swallowing less than an ounce is not expected to cause significant harm. For larger amounts, do
not induce vomiting. Give milk or water. Never give anything by mouth to an unconscious
person. Seek medical attention.
NMS#300 Page 2 of 8 10/01/07
Section 5. FIRE FIGHTING MEASURES
Flammable Properties
Flash Point: >200癋
Fire and Explosion Hazards
Avoid contact with water reactive materials, burning metals and electrically energized
equipment.
Extinguishing Media
Product is an extinguishing media. Use media appropriate for surrounding materials.
Special Fire Fighting Instructions
This product will produce foam when mixed with water.
Section 6. ACCIDENTAL RELEASE MEASURES
Safeguards (Personnel)
NOTE: Review FIRE FIGHTING MEASURES and HANDLING (Personnel) sections before
proceeding with clean-up. Use appropriate Personal Protective Equipment during clean-up.
Accidental Release Measures
Concentrate
Stop flow if possible. Use appropriate protective equipment during clean up. For small volume
releases, collect spilled concentrate with absorbent material; place in approved container. For
large volume releases, contain and collect for use where possible. Flush area with water until it
no longer foams. Exercise caution, surfaces may be slippery. Prevent discharge of concentrate to
waterways. Disposal should be made in accordance with federal, state and local regulations.
Foam/Foam Solution
See above. Flush with water. Prevent discharge of foam/foam solution to waterways. Do not
discharge into biological sewer treatment systems without prior approval. Disposal should be
made in accordance with federal, state and local regulations.
Section 7. HANDLING AND STORAGE
Handling (Personnel)
Avoid contact with eyes, skin or clothing. Avoid ingestion or inhalation. Rinse skin and eyes
thoroughly in case of contact. Review HAZARDS and FIRST AID sections.
Storage
Recommended storage environment is between 20癋 (-7癈) and 120癋 (49癈). Store product in
original shipping container or tanks designed for product storage.
NMS#300 Page 3 of 8 10/01/07
Section 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Controls
Special ventilation is not required.
Personal Protective Equipment
Respiratory
Recommended exposure limits (OSHA-PEL and ACGIH-TLV) have not been determined for
this material. The need for respiratory protection should be evaluated by a qualified health
specialist.
Protective Clothing
Rubber or PVC gloves recommended.
Eye Protection
Safety glasses, face shield or chemical splash goggles must be worn when possibility exists for
eye contact. Contact lenses should not be worn. Eye wash facilities are recommended.
Other Hygienic Practices
Use good personal hygiene practices. Wash hands before eating, drinking, smoking, or using
toilet facilities. Promptly remove soiled clothing and wash thoroughly before re-use.
Exposure Guidelines
Exposure Limits
(2-Methoxymethylethoxy) Propanol (34590-94-8)
PEL(OSHA)
100 ppm, 8 hr. TWA Skin
150 ppm, 15 min. STEL Skin
TLV (ACGIH)
100 ppm, 8 hr. TWA Skin
150 ppm, 15 min. STEL Skin
Section 9. PHYSICAL AND CHEMICAL PROPERTIES
Physical Data
Boiling Point: Not applicable
Vapor Pressure: Not applicable
Vapor Density: Not applicable
Melting Point: Not applicable
Evaporation Rate: <1 (Butyl Acetate = 1.0)
Solubility in Water: 100%
NMS#300 Page 4 of 8 10/01/07
pH: 8.0
Specific Gravity: 1.03 @ 25癈
Freezing Point: 12癋 (-11癈)
Odor: Mild, pleasant
Form: Liquid
Color: Straw yellow
Section 10. STABILITY AND REACTIVITY
Chemical Stability
Stable.
Incompatibility, Materials to Avoid
Avoid use of product on burning metals, electrically-energized equipment and contact with water
reactive materials.
Polymerization
Will not occur.
Section 11. TOXICOLOGICAL INFORMATION
Mammalian Toxicity
Ingestion
This material was not toxic when administered to Wistar Albino rats at an acute oral dose of
5g/kg body weight.
Eye
Animal testing indicates this material is a primary eye irritant when tested undiluted on New
Zealand Albino Rabbits.
Skin
Animal testing indicates this material is not a primary skin irritant when tested undiluted on New
Zealand Albino Rabbits.
Inhalation
No data available at this time.
Carcinogenic, Developmental, Reproductive, Mutagenic Effects
No data available on this material.
NMS#300 Page 5 of 8 10/01/07
Section 12. ECOLOGICAL INFORMATION
Ecotoxicological Information Aquatic Toxicity
96 hr. Flow Through LC50 for Fathead Minnows (pimephales promelas) is reported to be greater
than 1000 ppm.
Environmental Fate
BOD5 Concentrate 239,000 mg/kg
BOD5 3% solution 8,750 mg/kg
COD Concentrate 400,000 mg/kg
Section 13. DISPOSAL CONSIDERATIONS
Aer-O-Lite 3%, as sold, is not a RCRA-listed waste or hazardous waste as characterized by 40
CFR 261. However, State and local requirements for waste disposal may be more restrictive or
otherwise different from Federal regulations. Therefore, applicable local and state regulatory
agencies should be contacted regarding disposal of waste foam concentrate or foam/foam
solution.
Concentrate
Do not discharge into biological sewer treatment systems without prior approval. Specific
concerns are high BOD load and foaming tendency. Low dosage flow rate or antifoaming agents
acceptable to the treatment plant may be helpful. Do not flush to waterways. Disposal should be
made in accordance with federal, state and local regulations.
Foam/Foam Solution
Aer-O-Lite 3% foam solution can be treated by waste water treatment facilities. Discharge into
biological sewer treatment facilities may be done with prior approval. Specific concerns are high
BOD load. Dilution will reduce BOD and COD factors proportionately. Low dosage flow rate
or antifoaming agents acceptable to the treatment plant may be helpful. Do not flush to
waterways. Disposal should be made in accordance with federal, state and local regulations.
NOTE: As a service to our customers, National Foam has approvals in place with disposal
facilities throughout the U.S. for waste water treatment and solidification and landfill of our
foam liquid concentrates and foam solutions. If required, National Foam, Inc. can also provide
information on the disposal of drums used for shipping our concentrates. Please contact National
Foam's Risk Management Administrator at (610) 363-1400 for additional information.
NMS#300 Page 6 of 8 10/01/07
Section 14. TRANSPORTATION INFORMATION
Shipping Information
Proper Shipping Name: Fire Extinguisher Charges or Compounds N.O.I., Class 70
National Motor Freight Code: 69160, Sub 0
Hazard Class: None
UN Number: None
Section 15. REGULATORY INFORMATION
U.S. Federal Regulations
Toxic Substances Control Act (TSCA)
All components of this product are listed in the TSCA inventory.
Superfund Amendments and Reauthorization Act of 1986 (SARA), Title III
Section 302/304
There are no components of this material with known CAS numbers which are on the
Extremely Hazardous Substances (EHS) list.
Section 311 & 312
Based on available information, this material contains the following components which
are classified as the following health and/or physical hazards according to Section 311 &
312:
(2-Methoxymethylethoxy) Propanol 34590-94-8 (Flammability)
Section 313
This material does not contain any chemical components subject to Section 313 reporting
requirements.
COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION, AND
LIABILITY ACT (CERCLA)
This material does not contain any components subject to the reporting requirements of
CERCLA.
OTHER REGULATORY INFORMATION
Canadian Environmental Protection Act (CEPA). All ingredients are listed on the DSL
(Domestic Substance List).
STATE REGULATIONS
PENNSYLVANIA RIGHT-TO-KNOW HAZARDOUS SUBSTANCES LIST
PA Hazardous Substances present at levels greater than 1%:
1, 2 Propanediol 57-55-6
(2-Methoxymethylethoxy) Propanol 34590-94-8
NMS#300 Page 7 of 8 10/01/07
Section 16. OTHER INFORMATION
NFPA Rating WHMIS Rating
Health 0 D2B
Flammability 0
Reactivity 0
ADDITIONAL INFORMATION
Revision Summary
5/3/96 ........... Revised to ANSI format.
10/2/96 ......... Updated Section 12 - Environmental Fate.
2/5/99 ........... Added MSDS number, updated Sections 1,3,4,6,7,9,11,12,13,15.
08/10/00 ....... Revised Section 1 and 2.
09/10/03 ....... Updated Sections 2, 5, 9, 14, 15, 16.
05/03/05 ....... Updated Section 9.
10/01/07 ....... Updated Address.
For further information, see National Foam Product Data Sheet for Aer-O-Lite 3%.
The information contained herein is furnished without warranty either expressed or
implied. This data sheet is not a part of any contract of sale. The information contained
herein is believed to be correct or is obtained from sources believed to be generally reliable.
However, it is the responsibility of the user of these materials to investigate, understand
and comply with federal, state and local guidelines and procedures for safe handling and
use of these materials. National Foam, Inc. shall not be liable for any loss or damage arising
directly or indirectly from the use of this product and National Foam, Inc. assumes no
obligation or liabilities for reliance on the information contained herein or omissions
herefrom.
October 1, 2007
NMS#300 Page 8 of 8 10/01/07
|