MATERIAL SAFETY DATA SHEET
Manufactured by: Flammability
Anderson 0
Health
3 0
Chemical Company
?br>
SU RFLEX Reactivity
Special
325 SOUTH DAVIS AVENUE * See Bottom
SERIES
Hazard
LITCHFIELD, MINNESOTA 55355 of Page
NFPA Hazard Rating*
(320) 693-2477
Product
Delimer
Name:
Revised: 2/26/2010 lmt
24-HOUR EMERGENCY PHONE #: 1-800-424-9300 (CHEMTREC)
Supersedes: 4/28/2004
I. IDENTIFICATION
Chemical Name And Synonyms: DOT Shipping Name
Not applicable Corrosive liquid, acidic, inorganic, n.o.s.
(Phosphoric acid / Nitric Acid)
PG
Chemical Family: DOT Hazard Class & I.D. Number #
Inorganic acid Corrosive Material UN3264 8 III
II. HAZARDOUS INGREDIENTS
Component CAS NO. % TLV PEL Toxic Hazard
Phosphoric Acid 7664-38-2 28 1 mg/M3 1 mg/M3 NA Corrosive to skin and eyes.
Nitric Acid 7697-37-2 4 5 mg/M3 5 mg/M3 313** Corrosive to skin and eyes.
NA: Not applicable
**Toxic chemical subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR ?72).
NE: Not established
III. PHYSICAL DATA
Boiling Point: Form:
Above 212?F Liquid pH, 1% Soln.: 1.9
Specific Gravity: Solubility In Water:
1.188 Complete
Appearance: Odor:
Clear, colorless liquid None
IV. FIRE AND EXPLOSION HAZARD DATA
Flashpoint: Not Applicable
Extinguishing Media: Not combustible. Use media appropriate to surrounding fire.
Special Fire Although this product is not combustible, if a fire occurs in the near vicinity, good fire-fighting practice dictates the use of self-
Fighting Procedures: contained breathing apparatus and other protective gear. Cool fire exposed drum with water spray to prevent overheating.
Unusual Fire And If the stock solution container breaks, the product should be handled with care as it is corrosive.
Explosion
Hazards:
V. HEALTH HAZARD DATA
Carcinogenic: The raw materials used in this product are not considered to be a carcinogen by ACGIH, NTP, IARC, and OSHA
Effects Of Corrosive. Causes tissue destruction, permanent damage to the cornea, blindness. Causes irritation (possibly severe), burns to the
Over-exposure: skin. Mists may cause lung irritation, shortness of breath, fluid in lungs. Ingestion causes nausea, vomiting, diarrhea, corrosion,
burns to mouth and esophagus, abdominal pain, chest pain, shortness of breath, seizures, death.
Emergency And First Eyes: Flush immediately with water for 15 minutes. Lift upper and lower eyelids for complete rinsing. Get immediate medical
Aid Procedures: attention.
Skin: Flush with water for 15 minutes. Get medical attention. Remove contaminated clothing and wash before reuse.
Ingestion: Rinse mouth with water. Give water to dilute. Do not induce vomiting. Get immediate medical attention. Never give
anything by mouth to a semi-comatose, comatose, convulsing or unconscious person.
Inhalation: Remove victim to fresh air. If breathing difficulty occurs or persists, get medical attention.
* NFPA/HMIS Degree or Hazard: 4 = Extreme; 3 = High; 2 = Moderate; 1 = Slight; 0 = Insignificant. Continued On Back
HMIS A. Safety Glasses B. Safety Glasses, Gloves C. Safety Glasses, Gloves, Apron D. Face Shield, Gloves, Apron E. Safety Glasses, Gloves, Dust Respirator F. Safety
Glasses, Gloves, Apron, Dust Respirator G. Safety Glasses, Gloves, Vapor Respirator H. Splash Goggles, Gloves, Apron, Vapor Respirator I. Safety Glasses, Gloves, Vapor and
Dust Respirator J. Splash Goggles, Gloves, Apron, Vapor and Dust Respirator K. Air Line, Hood or Mask, Gloves, Full Suit, Boots X. Ask your supervisor for guidance.
Delimer
Page 2; Product Name:
VI. REACTIVITY DATA
Stability - Unstable: Stable: X
Conditions To Avoid: None known.
Incompatibility: Fluorine, strong oxidizing and reducing agents, bases, metals, sulfur tiroxide, and phosphorus petoxide. Contact with
(Materials to Avoid) reactive metals (aluminum, zinc, mild steel) may produce flammable explosive hydrogen - air mixtures.
Hazardous At flame temperatures, toxic phosphoric oxide and nitrogen oxide fumes may be emitted.
Decomposition Products:
VII. SPILL OR LEAK PROCEDURES
Steps To Be Taken In Case Material Is Released Or Spilled:
Evacuate nonessential personnel. Wear appropriate personal protection equipment. Completely contain spilled material
with dikes or sandbags, etc., and prevent run-off into ground or surface waters or sewers. Recover as much material as
possible into containers for disposal. Remaining material may be diluted with water and neutralized with lime or other
base. Neutralization products, both solid and liquid, must be recovered for disposal.
Waste Disposal Method: If material can not be salvaged, neutralize and then discharge into a treatment system in accordance with local, state and
federal regulations.
VIII. SPECIAL PROTECTION INFORMATION
Respiratory Protection: When respirators are required, select NIOSH/MSHA approved equipment based on actual or potential airborne
concentrations and in accordance with the appropriate regulatory standards and/or industrial recommendations.
Ventilation: Should be adequate to keep mist level below the TLV.
Protective Gloves: Rubber or neoprene.
Eye Protection: Eye contact should be prevented through use of chemical safety glasses with side shields or splash proof goggles. If
splashing is anticipated, face contact should be prevented through use of a faceshield.
Protective Clothing: Skin contact should be prevented through use of suitable protective clothing, gloves and footwaear selected with regard for
use conditions.
IX. SPECIAL PRECAUTIONS
Precautions To Be Taken In Handling And Storing:
Do not get in eyes, on skin, or clothing. Do not breathe vapors or mists. Do not ingest. Wash thoroughly after handling.
Wear protective clothing/equipment. Use with adequate ventilation. Keep containers tightly closed and properly labeled.
This product reacts violently with bases liberating heat and causes spattering. Store in a cool, dry, well-ventilated area.
Wash hands before eating, drinking, using tobacco, applying make-up or using the toilet. Do not store, use, and/or
consume foods, beverages, tobacco in areas where this product is stored.
Other Precautions: Safety showers and eyewash stations should be provided in the areas where this product is handled.
X. REVISED INFORMATION
MSDS Status: Review and update
The opinions expressed herein are those of qualified experts within ANDERSON Chemical Company. We believe that the information contained herein is current as of the date of this Material
Safety Data Sheet. Since the use of this information and these opinions and the conditions of use of the product are not within the control of ANDERSON Chemical Company, it is the user's
obligation to determine the conditions of safe use of the product.
|