Permatex, A Brand of ITW Devcon
30 Endicott St.
Danvers, MA 01934 USA
Telephone: 978-777-1100
Emergency: 800-424-9300
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: HIGH TEMPERATURE THREAD SEALANT 250 ML
Item No: 59225
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
POLYGLYCOL DIMETHACRYLATE 20-40 Not Listed Not Listed
25852-47-5
BISPHENOL A FUMARATE RESIN 25-35 Not Listed Not Listed
39382-25-7
OCTANOL 10-20 Not Listed Not Listed
111-87-5
3 mg/m3 TWA
SILICA, MICA 10-20 20 mppcf
12001-26-2
POLYTETRAFLUOROETHYLENE 1-10 Not Listed Not Listed
9002-84-0
10 mg/m3 mist; 3 mg/m3 resp.
SILICA, AMORPHOUS TREATED 1-10 20 mppcf
MIXTURE
10 mg/m3 10 mg/m3; 15 mg/m3 total dust
TITANIUM DIOXIDE 1-10
13463-67-7
__-DIMETHYLBENZYL 0.5-5.0 Not Listed Not Listed
HYDROPEROXIDE
80-15-9
3. HAZARDS IDENTIFICATION
Note: This product does not contain microcyrstalline silica. Ingestion may irritate digestive tract and
Toxicity:
cause nausea, vomiting and diarrhea. May cause eye and skin irritation. May cause skin sensitization.
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Signs and Symptoms of Exposure: Repeated skin contact may cause allergic skin reactions. May cause redness to eyes and irritation to
nasal passages.
Ingredients Percent NTP: ACGIH IARC:
Carcinogens
TITANIUM DIOXIDE 1-10 Not listed Not listed Group 3; Vol 47, pg 307,
13463-67-7 1989
Medical Conditions Recognized as Preexisting skin disorders.
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapors. Obtain medical attention.
Inhalation:
Wash off immediately with soap and plenty of water removing all contaminated clothes and shoes If
Skin Contact:
skin irritation persists, call a physician
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
More than 200 degrees F. Method: Tag Closed Cup
Flash Point (癋/C):
Water fog, carbon dioxide, foam, dry chemical.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Irritating vapors. Oxides of carbon.
Hazardous Products Formed by Fire or Thermal
Decomposition:
None
Unusual Fire/Explosion Hazards:
1 of 3
Product name: HIGH TEMPERATURE THREAD Item 59225
SEALANT 250 ML
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store below 100 degrees F. Keep in cool and dark place. Avoid direct sunlight.
Storage:
Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Rubber or plastic gloves
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits during the use of this product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits..
9. PHYSICAL AND CHEMICAL PROPERTIES
White paste
Appearance:
MILD
Odor:
More than 300 degrees C.
Boiling Point (癋):
Does not apply
pH:
Insoluble
Solubility in Water:
1.15
Specific Gravity:
16.9%
VOC Content(Wt.%):
Not determined
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR
Hazardous Polymerization:
Metal salts, heat and amines.
Incompatabilities:
Heat
Conditions to Avoid:
Irritating vapors. Oxides of carbon.
Hazardous Products Formed by Fire or Thermal
Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
IATA
not regulated
Proper Shipping Name:
None
Class or Division:
2 of 3
Product name: HIGH TEMPERATURE THREAD Item 59225
SEALANT 250 ML
None
UN/NA Number:
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
SARA 313 Information
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 1
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: 02/14/2005
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 3
Company: Revision
06106 Number:
Telephone Number: 1-87-Permatex (877) 376-2839