Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: +01-813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: HIGH TEMPERATURE THREAD SEALANT 6ML
Item No: 59214
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH; TLV-TWA OSHA PEL:
POLYGLYCOL DIMETHACRYLATE 20-40 Not listed Not Listed
25852-47-5
POLYESTER RESIN 10-30 Not listed Not Listed
MIXTURE
3 mg/m3
SILICA, MICA 10-30 20 mppcf TWA
12001-26-2
POLYETHYLENE GLYCOL ESTER <20 Not listed Not Listed
18268-70-7
OCTANOL <10 Not listed Not Listed
111-87-5
POLYTETRAFLUOROETHYLENE <5 Not listed Not Listed
9002-84-0
10 mg/m3 10 mg/m3 total dust
TREATED SILICON DIOXIDE, <5
SYNTHETIC, CRYSTALLINE-FREE
67762-90-7
10 mg/m3 15 mg/m3 TWA (total dust)
TITANIUM DIOXIDE <3
13463-67-7
PROPYLENE GLYCOL <3 Not listed Not Listed
57-55-6
DIMETHYLBENZYL <2 Not listed Not Listed
HYDROPEROXIDE
80-15-9
3. HAZARDS IDENTIFICATION
Ingestion may irritate digestive tract and cause nausea, vomiting and diarrhea. May cause eye and skin
Toxicity:
irritation. May cause skin sensitization. Note: This product does not contain microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. May cause redness to eyes and irritation to
Signs and Symptoms of Exposure:
nasal passages.
Component Weight% NTP ACGIH Carcinogens IARC
POLYTETRAFLUOROETHYLENE <5 Group 3 Supplement 7, 1987;
9002-84-0 Monograph 19, 1979
TITANIUM DIOXIDE <3 male rat-negative, A4 Group 2B; Vol 93,2006; Vol
13463-67-7 female rat-negative, 47,1989
male mice-negative,
female mice-negative
Preexisting skin disorders.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
1 of 3
Product Name: HIGH TEMPERATURE THREAD Item No: 59214
SEALANT 6ML
5. FIRE FIGHTING MEASURES
>200?F TCC
Flash Point 癋(C?:
Water fog, carbon dioxide, foam, dry chemical.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Irritating vapors, Oxides of carbon
Hazardous Products of Combustion:
None
Unusual Fire/Explosion Hazards:
1.0: Octanol
Lower Explosive Limit:
8.0: Octanol
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store below 100 degrees F. Keep in cool and dark place. Avoid direct sunlight.
Storage:
Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Neoprene or nitrile gloves recommended.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
Not required under normal use. An approved organic vapor respirator should be worn when exposures are
Respiratory Protection:
expected to exceed the applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
White paste
Appearance:
MILD
Odor:
>300癈.
Boiling Point:
Does not apply
pH:
Insoluble
Solubility in Water:
1.2
Specific Gravity:
2.8%
VOC Content(Wt.%):
Not determined
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR.
Hazardous Polymerization:
Metal salts, heat and amines.
Incompatabilities:
Heat
Conditions to Avoid:
Irritating vapors, Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
2 of 3
Product Name: HIGH TEMPERATURE THREAD Item No: 59214
SEALANT 6ML
14. TRANSPORTATION INFORMATION
Unrestricted
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
None
Marine Pollutant:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 1.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: August/14/2007
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 3
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|