MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens Electronic Cleaner
MSDS NO. 4600
Revision Date: 09/17/2008
Date Printed 12/30/2008
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Trade Name: Johnsens Electronic Cleaner
Chemical Family: Non-Chlorinated Hydrocarbon
Synonyms: None
Emergency Telephone (24 hr.): 24-Hour Emergency Information: CHEMTREC (800) 424-9300
Supplier: Technical Chemical Company, P.O. Box 139, Cleburne, Texas 76033
2. COMPOSITION/INFORMATION ON INGREDIENTS
Weight % OSHA TWA OSHA STEL OSHA SKIN
Component
70-75 Not Listed Not Listed Not Listed
Isohexane
107-83-5
22-28 Not Listed Not Listed Not Listed
HFC-152a
75-37-6
1-4 Not Listed Not Listed Not Listed
Methanol
67-56-1
Weight % OSHA Z PEL OSHA Z TWA OSHA Z Ceiling
Component
1800 mg/m3 500 ppm
70-75 Not Listed Not Listed
Isohexane
107-83-5
22-28 Not Listed Not Listed Not Listed
HFC-152a
75-37-6
260 mg/m3 200 ppm 260 mg/m3 200 ppm
1-4 Not Listed
Methanol
67-56-1
ACGIH TLV TWA ACGIH TLV STEL ACGIH TLV Ceiling
Component
500 ppm 1000 ppm Not Listed
Isohexane
107-83-5
Not Listed Not Listed Not Listed
HFC-152a
75-37-6
200 ppm 250 ppm Not Listed
Methanol
67-56-1
Other: This product does not contain Normal Hexane (N-Hexane).
3. HAZARDS IDENTIFICATION
Emergency Overview: Warning: Extremely Flammable. Content under pressure. This material is an eye and skin irritant. Keep
away from heat, sparks and flame. Gross inhalation overexposure may cause: Central nervous system
depression with dizziness, confusion, incoordination, drowsiness or unconsciousness or death. Causes
respiratory irritation.
HMIS Classification: Health: *2 Flammability: 3 Physical Hazard: 2
NFPA Rating: Health: 1 Flammability: 3 Reactivity: 0
4. FIRST AID MEASURES
Eye Contact: In case of contact, or suspected contact, immediately flush eyes with plenty of water for at least 15 minutes
and get medical attention immediately after flushing.
Page 1 of 5
MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens Electronic Cleaner
MSDS NO. 4600
Revision Date: 09/17/2008
Date Printed 12/30/2008
4. FIRST AID MEASURES
Ingestion: If swallowed, do NOT induce vomiting. Call a physician immediately. Never give anything by mouth to an
unconscious person. Get medical attention! If vomiting occurs, keep head lower than hips to prevent
aspiration.
Inhalation: If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If
breathing is difficult give oxygen. Get medical attention.
Skin Contact: Wash with soap and water for 15 minutes. If irritation persists or signs of toxicity occur, seek medical
attention. Remove contaminated clothing and shoes, and launder before reuse.
5. FIRE FIGHTING MEASURES
Flammable Properties
Flash Point 癋(癈): 15 F (Lowest Component)
Flash Point Method: TAG Closed Cup
Flammable Limits in Air - Lower (%): 1.2% (Lowest Component)
Flammable Limits in Air - Upper (%): 6.7% (Lowest Component)
Autoignition Temperature 癋(癈): Not Determined
Extinguishing Media: Dry chemical. Carbon dioxide. Use water spray to keep containers cool that are exposed to heat or flames.
Protection Of Fire-Fighters:
Special Fire-Fighting Procedures: Wear approved positive-pressure self-contained breathing apparatus and protective clothing. Vapor may
cause flash fire. Warning!! Contents under pressure. Container may rupture under fire conditions.
Decomposition may occur.
Hazardous Combustion Products: Carbon Dioxide. Carbon Monoxide.
Aerosol Comments: NFPA Level 3 Aerosol
6. ACCIDENTAL RELEASE MEASURES
Personal Precautions: Wear appropriate protective clothing and equipment to prevent skin and eye contact.
Spill Procedures: Contain any liquid from leaking containers. Avoid all sources of ignition; heat, sparks and open flames.
Action to be taken if material is released Do not puncture or incinerate container. Contents under pressure. Wear proper protective equipment as
or spilled: specified in the protective equipment section. Remove sources of ignition. Leaking containers should be
removed to an isolated, well-ventilated area and transferred to other suitable containers. Wipe, scrape, or
soak up in an inert material and put in a container intended for flammable materials for disposal.
Environmental Precautions: Do not allow to enter sanitary drains, sewer or surface and subsurface waters. Keep out of lakes, ponds or
streams.
7. HANDLING AND STORAGE
Handling and Storage: Caution: Contents under pressure. Keep away from heat and open flame. Use only in a well ventilated
area. Avoid breathing vapors, if exposed to high vapor concentration, leave area at once. Avoid contact
with skin and eyes. Do not puncture, incinerate or store above 120 F. Exposure to high temperatures may
cuase bursting. DO NOT store in the passenger compartment of an automobile.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Controls: Use in a well ventilated area. Local exhaust ventilation as necessary to maintain exposures to within
applicable limits.
Eyes: Chemical goggles; also wear a face shield if splashing hazard exists.
Skin Protection: Avoid skin contact. Wear protective clothing and gloves.
Respiratory Protection: Do not breath mist or vapor. Use in a well ventilated area. Appropriate respiratory protection shall be worn
when applied engineering controls are not adequate to protect against inhalation exposure.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Colorless to pale yellow liquid
Odor: MILD
pH Value: Not Determined
Vapor Pressure: 2.3 psia @ 100 F (Liquid)
Vapor Density (Air=1): 3.5 Approximate
Page 2 of 5
MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens Electronic Cleaner
MSDS NO. 4600
Revision Date: 09/17/2008
Date Printed 12/30/2008
9. PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (癋): 195 F
Melting/Freezing Point: Not determined.
Solubility in Water: NEGLIGIBLE
Bulk Density at 20癈: 5.8 lb/gal (liquid)
Molecular Weight: Mixture
Specific Gravity (H20=1): .69 - .79 @ 60 F
Viscosity: .83 cSt @ 100 F (liquid)
Evaporation Rate: >1 (liquid)
VOC Content(%): 75%
Decomposition Temperature: Not Determined
10. STABILITY AND REACTIVITY
Chemical Stability: STABLE.
Conditions to Avoid: Keep away from heat,sparks and flame. Avoid any source of ignition. Do not expose to heat or store at
temperatures above 120 F.
Materials to Avoid: Contact with oxidizing agents. Concentrated oxygen.
Hazardous Decomposition Products: Carbon monoxide. Carbon dioxide.
Hazardous Polymerization: WILL NOT OCCUR
11. TOXICOLOGICAL INFORMATION
Toxicological Data:
Component
Route Species Dose
Inhalation Rats Not known.
Isohexane
107-83-5
Inhalation Rats Not known.
HFC-152a
75-37-6
Inhalation Rats LC50 64,000 ppm
Methanol
67-56-1
Carcinogenicity:
Component
IARC NTP OSHA
Not Listed Not Listed Not Listed
Isohexane
107-83-5
Not Listed Not Listed Not Listed
HFC-152a
75-37-6
Not Listed Not Listed Not Listed
Methanol
67-56-1
12. ECOLOGICAL INFORMATION
Remarks: Ecological testing has not been conducted on this product.
13. DISPOSAL CONSIDERATION
Waste Classification: Residues and spilled material are hazardous waste due to ignitability.
Waste Management: Not determined.
Disposal Method: Disposal should be made in accordance with federal, state and local regulations.
14. TRANSPORTATION INFORMATION
U.S. DOT:
Proper Shipping Name: ORM-D CONSUMER COMMODITY
Hazard Class: ORM-D
Page 3 of 5
MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens Electronic Cleaner
MSDS NO. 4600
Revision Date: 09/17/2008
Date Printed 12/30/2008
14. TRANSPORTATION INFORMATION
UN/NA Number: Not Applicable
DOT Packing Group: Not Applicable
IMDG:
Proper Shipping Name: Aeroslols (Limited Quantity)
Hazard Class: 2.1
Hazard Subclass: Not determined.
UN No.: UN1950
Packing Group: PG II
Marine Pollutant: No
15. REGULATORY INFORMATION
US Federal Regulations:
SARA 313 SARA 302 TPQ RQ
Component
Not Listed Not Listed Not Listed Not Listed
Isohexane
107-83-5
Not Listed Not Listed Not Listed Not Listed
HFC-152a
75-37-6
Listed. Not Listed Not Listed Not Listed
Methanol
67-56-1
US OSHA HEALTH CLASSIFICATION: Hazardous per OSHA 29 CFR 1910.1200
SARA 311/312 Hazard Catagories: Not Determined.
State Regulations:
California Prop. 65 California - Prop 65 California Prop. 65 California Prop. 65
Component
Cancer list Developmental Toxicity Reproductive Female Reproductive Male
Not Listed Not Listed Not Listed Not Listed
Isohexane
107-83-5
Not Listed Not Listed Not Listed Not Listed
HFC-152a
75-37-6
Not Listed Not Listed Not Listed Not Listed
Methanol
67-56-1
Page 4 of 5
MATERIAL SAFETY DATA SHEET
Trade Name: Johnsens Electronic Cleaner
MSDS NO. 4600
Revision Date: 09/17/2008
Date Printed 12/30/2008
New Jersey Right-to-Know List:
Component
Substance no. 2422
Isohexane
Substance no. 2423
107-83-5 Substance no. 2425
Substance no. 2426
Substance no. 2427
Substance no. 2428
Substance no. 2429
Substance no. 2430
Substance no. 1285
Substance no. 0715
HFC-152a
75-37-6
Substance no. 2079
Methanol
Substance no. 2422
67-56-1 Substance no. 2423
Substance no. 2425
Substance no. 2426
Substance no. 2427
Substance no. 2428
Substance no. 2429
Substance no. 2430
Substance no. 1222
U.S. TSCA: The components of this product are listed on the TSCA Inventory.
Canadian Inventory: The components of this product are listed on the Canadian DSL or NDSL Inventory.
Consumer Product Safety Improvement Act of 2008 General Conformity Certification
The Supplier identified in Section 1 of this MSDS has evaluated this product and certifies it to be labeled and packaged in
compliance with the applicable provisions of the Federal Hazardous Substance Act as stated in 16 CFR 1500 and
enforced by the Consumer Product Safety Commission, and where applicable the products that require Child Resistant
Closures are packaged in accordance with the Poison Prevention Packaging Act as stated in 16 CFR 1700 and enforced
by the Consumer Product Safety Commission. All closures have been tested in accordance with the latest protocols. No
other testing is required to certify compliance with the above. The date of manufacture is stamped on the product
container.
16. OTHER INFORMATION
General Notes: Do not allow undiluted material or large quantities to reach groundwater, bodies of water or sewer system.
Disclaimer: The information and recommendations contained herein are based upon tests believed to be reliable.
However, the manufacturer/distributor of this product does not guarantee their accuracy or completeness
NOR SHALL ANY OF THIS INFORMATION CONSTITUTE A WARRANTY, WHETHER EXPRESSED OR
IMPLIED, AS TO THE SAFETY OF THE GOODS, THE MERCHANTABILITY OF THE GOODS, OR THE
FITNESS OF THE GOODS FOR A PARTICULAR PURPOSE. Adjustment to conform to actual conditions
of usage may be required. The manufacturer/distributor assumes no responsibility for results obtained or
for incidental or consequential damages, including lost profits, arising from the use of these data. No
warranty against infringement of any patent, copyright or trademark is made or implied.
Page 5 of 5
|