Material Safety Data Sheet
DYNA COOL K56 MSDS No. 5485
Date of Preparation: 2/6/2002 Revision: 2/6/2002
Section 1 - Chemical Product and Company Identification
Product/Chemical Name: DYNA COOL K56 HMIS
Chemical Formula: 5485 H1
General Use: 0
F
Manufacturer: DYNA TECH 0
R
PPEX
P.O. BOX 71 PHONE: 262-646-7600
PEWAUKEE, WI 53072 EMERGENCY: 800-535-5053
Emergency Overview
Section 2 - Composition / Information on Ingredients
% wt or
Ingredient Name CAS Number
% vol
HEXYLENE GLYCOL 107-41-5 <5%
MONOETHANOLAMINE 141-43-5 <5%
MINERAL OIL PROPRIETARY <10%
TRIETHANOLAMINE 102-71-6 <5%
Trace Impurities:
Ingredient OSHA PEL ACGIH TLV NIOSH REL
HEXYLENE 25 PPM 25 PPM
GLYCOL
3 PPM 6 PPM
MONOETHANOLA
MINE
MINERAL OIL 5 MG/M3 (AS MIST) 5 MG/M3 (AS MIST)
TRIETHANOLAMI 5 MG/M3
NE
Toxicity Data:
Section 3 - Physical and Chemical Properties
Physical State: LIQUID Water Solubility: COMPLETE
Boiling Point: N/A
Appearance and Odor: CLEAR BLUE CLEAR,
SASSAFRAS Vapor Density (Air=1): N/A
% Volatile: N/A
Vapor Pressure: N/A
Evaporation Rate: N/A
Specific Gravity (H2O=1, at 4 癈): 1.030
pH: N/A
Section 4 - Fire-Fighting Measures
Flash Point: NONE NFPA
Flash Point Method: N/A
#
LEL: NONE
#
#
UEL: NONE
--
Flammability Classification: NONE
Extinguishing Media: WATER SPRAY, DRY CHEMICAL, FOAM, CO2 FIRE EXTINGUISHERS
Unusual Fire or Explosion Hazards: NONE KNOWN
Fire-Fighting Instructions: Do not release runoff from fire control methods to sewers or waterways.
Fire-Fighting Equipment: Because fire may produce toxic thermal decomposition products, wear a self-contained breathing
apparatus (SCBA) with a full facepiece operated in pressure-demand or positive-pressure mode.
MSDS No. 5485 DYNA COOL K56 Revision: 2/6/2002
Section 5 - Stability and Reactivity
Stability: DYNA COOL K56 is stable at room temperature in closed containers under normal storage and handling conditions.
Polymerization: Hazardous polymerization cannot occur.
Chemical Incompatibilities: STRONG OXIDIZING AGENTS
Conditions to Avoid: CONTACT WITH INCOMPATIBLE MATERIAL AND EXPOSURE TO EXTREME TEMPERATURES.
Hazardous Decomposition Products: Thermal oxidative decomposition of DYNA COOL K56 can produce OXIDES OF
CARBON, TRACES OF FORMALDEHYDE, AMMONIA AND OXIDES OF NITROGEN, INCOMPLETELY BURNED
HYDROCARBON AS FUMES AND SMOKE.
Section 6 - Health Hazard Information
Potential Health Effects
Primary Entry Routes: INHALATION - SKIN CONTACT - EYE - INGESTION
Acute Effects
Inhalation: DUST OR MIST MAY CAUSE IRRITATION TO THE UPPER RESPIRATORY TRACT AND LUNGS
Eye: DUST OR MIST MAY CAUSE IRRITATION TO THE EYES
Skin: DUST OR MIST MAY CAUSE IRRITATION TO THE SKIN
Ingestion: DUST OR MIST MAY CAUSE IRRITATION TO THE STOMACH AND DISCOMFORT.
Carcinogenicity: IARC, NTP, and OSHA do not list DYNA COOL K56 as a carcinogen.
Medical Conditions Aggravated by Long-Term Exposure:
Chronic Effects:
Emergency and First Aid Procedures
Inhalation: REMOVE VICTIM TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION, PREFERABLY
MOUTH-TO-MOUTH. IF BREATHING IS DIFFICULT, GIVE OXYGEN. CALL A PHYSICIAN.
Eye Contact: IMMEDIATELY FLUSH EYE WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. HOLD EYELIDS
OPEN DURING THIS FLUSHING WITH WATER. CALL A PHYSICIAN IMMEDIATELY.
Skin Contact: FLUSH AREA WITH WATER WHILE REMOVING CONTAMINATED CLOTHES AND SHOES. FOLLOW
BY WASHING WITH SOAP AND WATER. DO NOT REUSE CLOTHING OR SHOES UNTIL CLEANED. IF
IRRITATION PERSISTS, GET MEDICAL ATTENTION. DO NOT APPLY OILS OR OINTMENTS, UNLESS ORDERED
BY PHYSICIAN.
Ingestion: IF CONSCIOUS, DRINK A QUART OF WATER. DO NOT INDUCE VOMITING. CALL A PHYSICIAN
IMMEDIATELY. IF UNCONSCIOUS OR IF IN CONVULSIONS, TAKE IMMEDIATELY TO A HOSPITAL OR
PHYSICIAN. NEVER INDUCE VOMITING OR GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS VICTIM.
AFTER DILUTION WITH WATER, FRUIT JUICE MAY BE ADMINISTRATED TO ACCOMPLISH NEUTRALIZATION.
SEVERAL GLASSES OF MILK OR SEVERAL OUNCES MILK OF MAGNESIA MAY BE GIVEN FOR THEIR
SOOTHING EFFECT. GET MEDICAL ATTENTION.
After first aid, get appropriate in-plant, paramedic, or community medical support.
Note to Physicians: NONE
Special Precautions/Procedures: NONE
Section 7 - Spill, Leak, and Disposal Procedures
Spill /Leak Procedures: EVACUATE UNPROTECTED PERSONNEL FROM AREA. MAINTAIN ADEQUATE
VENTILATION. USE PROPER SAFETY EQUIPMENT. SWEEP UP MATERIAL INTO CONTAINERS AND DISPOSE OF
PROPERLY. AVOID DIRECT DISCHARGE TO SEWERS AND SURFACE WATERS. NOTIFY AUTHORITIES IF
ENTRY OCCURS.
Spills
Containment: For large spills, dike far ahead of liquid spill for later disposal. Do not release into sewers or waterways.
Regulatory Requirements: Follow applicable OSHA regulations (29 CFR 1910.120).
Disposal: Contact your supplier or a licensed contractor for detailed recommendations. Follow applicable Federal, state, and local
regulations.
Disposal Regulatory Requirements: OBSERVE ALL LOCAL, STATE, AND FEDERAL REGULATIONS.
Container Cleaning and Disposal: OBSERVE ALL LOCAL, STATE, AND FEDERAL REGULATIONS. DISPOSE OF AT
APPROVED WASTE TREATMENT FACILITY. IF APPROVED NEUTRALIZE MATERIAL AND FLUSH TO SEWER.
DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOIDER, DRILL, GRIND, OR EXPOSE EMPTY CONTAINERS TO HEAT,
FLAME, SPARKS OR OTHER SOURCES OF IGNITION.
Ecological Information:
EPA Regulations:
Revision: 2/6/2002 DYNA COOL K56 MSDS No. 5485
This information may be subject to the provision reporting requirements of Section 313 of the Superfund Amendment and
Reauthorization Act of 1986 (SARA). All sections - CERCLA, RCRA, and OSHA.
Section 8 - Exposure Controls / Personal Protection
Engineering Controls:
Ventilation: Provide general or local exhaust ventilation systems to maintain airborne concentrations below OSHA PELs (Sec. 2).
Local exhaust ventilation is preferred because it prevents contaminant dispersion into the work area by controlling it at its source.
Administrative Controls:
Respiratory Protection: Seek professional advice prior to respirator selection and use. Follow OSHA respirator regulations
(29 CFR 1910.134) and, if necessary, wear a MSHA/NIOSH-approved respirator. Select respirator based on its suitability to
provide adequate worker protection for given working conditions, level of airborne contamination, and presence of sufficient
oxygen. For emergency or nonroutine operations (cleaning spills, reactor vessels, or storage tanks), wear an SCBA.
Warning! Air-purifying respirators do not protect workers in oxygen-deficient atmospheres. If respirators are used, OSHA
requires a written respiratory protection program that includes at least: medical certification, training, fit-testing, periodic
environmental monitoring, maintenance, inspection, cleaning, and convenient, sanitary storage areas.
Protective Clothing/Equipment: Wear chemically protective gloves, boots, aprons, and gauntlets to prevent prolonged or
repeated skin contact. Wear protective eyeglasses or chemical safety goggles, per OSHA eye- and face-protection regulations
(29 CFR 1910.133). Contact lenses are not eye protective devices. Appropriate eye protection must be worn instead of, or in
conjunction with contact lenses.
Safety Stations: Make emergency eyewash stations, safety/quick-drench showers, and washing facilities available in work area.
Contaminated Equipment: Separate contaminated work clothes from street clothes. Launder before reuse. Remove this material
from your shoes and clean personal protective equipment.
Comments: Never eat, drink, or smoke in work areas. Practice good personal hygiene after using this material, especially before
eating, drinking, smoking, using the toilet, or applying cosmetics.
Section 9 - Special Precautions and Comments
Handling Precautions: WEAR CHEMICAL SAFETY GOGGLES OR FACE SHIELD WITH SAFETY GOGGLES, AND
PROTECTIVE CLOTHING. USE SELF-CONTAINED BREATHING APPARATUS IF NECESSARY. DO NOT USE IN
POORLY VENTILATED OR CONFINED SPACES. WHEN MAKING SOLUTIONS, HEAT MAY BE GENERATED. ADD
SLOWLY TO SURFACES OF SOLUTION WHILE STIRRING TO AVOID SPLATTERING. NEVER USE PRESSURE TO
EMPTY CONTAINERS. EMPTY CONTAINERS MAY CONTAIN EXPLOSIVE VAPORS OR DANGEROUS RESIDUES.
DO NOT CUT, PUNCTURE, OR WELD ON OR NEAR CONTAINER. ALL LABELLED HAZARDOUS PRECAUTIONS
MUST BE OBSERVED. DO NOT REUSE EMPTY CONTAINER WITHOUT COMMERCIAL CLEANING OR
RECONDITIONING.
Storage Requirements: STORE IN COOL, WELL-VENTILATED AREA AWAY FROM HEAT AND OUT OF DIRECT
SUNLIGHT. DO NOT STORE OPEN, UNLABELLED, MISLABELLED, OR EMPTY CONTAINERS. KEEP
CONTAINERS TIGHTLY CLOSED. STORE AWAY FROM INCOMPATIBLE MATERIALS. DO NOT EAT, DRINK, OR
SMOKE IN WORK AREA.
DOT Transportation Data (49 CFR 172.101):
Shipping Name: NOT DOT HAZARDOUS AS PACKAGED
Hazard Class: NONE
Packing Group: III
Label: NONE
Prepared By: SLW
Revision Notes:
Disclaimer: THE DATA IN THIS MATERIAL SAFETY DATA SHEET IS BELIEVED TO BE CORRECT. HOWEVER,
SINCE CONDITIONS OF USE ARE OUTSIDE OUR CONTROL IT SHOULD NOT BE TAKEN AS A WARRANTY OR
REPRESENTATION FOR WHICH WE ASSUME LEGAL RESPONSIBILITY. THIS INFORMATION IS PROVIDED
SOLELY FOR YOUR CONSIDERATION, INVESTIGATION, AND VERIFICATION.
|