U0-105.TXT



 MATERIAL SAFETY DATA SHEET 05/05/2006 

For Coatings, Resins and Related Materials 



=============================================================================== 



SECTION I - PRODUCT IDENTIFICATION 



Manufacturer: Crawford Laboratories, Inc. Information Phone: 773-376-7132 

4165 South Emerald Avenue Emergency Phone: 800-424-9300 

-----------------------------------



Chicago IL 60609 ! Hazard Ratings: Health - 3 

Product Class: ACTIVATOR ! none -> extreme Fire - 2 

Trade Name : SPS COLORFAST HARDNER ! 0 ---> 4 Reactivity - 0 

Product Code : U0-105 ! 



C.A.S. Number: SEE BELOW ! 

=============================================================================== 

SECTION II - HAZARDOUS INGREDIENTS 



Weight --- Exposure Limits ---- VP 

Ingredients CAS # % ACGIH/TLV OSHA/PEL mm HG 



ALIPHATIC DIAMINE 2855-13-2 50-75 Undetermined?0. 



* ?XYLENE?1330-20-7 5-20 100 ppm 100 21. 

S.T.E.L.= 150 150 

The above item contains approx. 15 % Ethylbenzene,CAS# 100-41-4 

The International Agency for Research on Cancer (IARC) has 

evaluated ethylbenzene and classified it as a possible human 

carcinogen (group 2B) based on sufficient evidance for carcinogy 

in experimantal animals, but inadequate evidance for cancer in 

exposed humans. 



NONYLPHENOL?84852-15-3 5-20 Undetermined 0.9 



EPOXY RESIN?25085-99-8 5-20 Undetermined 

This is a Bisphenol A / Epichlorohydrin Epoxy Resin. 

Repeated exposure may cause skin irritation. Has caused 

allergic skin reaction in humans. 



* SECTION 313 SUPPLIER NOTIFICATION?br>
This ingredient is subject to the reporting requirements?br>
of section 313 of the Emergency Planning and Community?br>
Right-To-Know Act of 1986 and of 40 CFR 372.

?br>
=============================================================================== 



SECTION III - PHYSICAL DATA 



Boiling Range: 278 - 545 Deg. F Vapor Density: Heavier than Air. 

Evap. Rate: 0.7 x n-Butyl Acetate Liquid Density: Lighter than Water. 

Volatiles volume: 6.2 % Wgt per gallon: 7.94 Pounds. 

Appearance: CLEAR LIQUID V.O.C.: 54 gpl. 

=============================================================================== 



SECTION IV - FIRE AND EXPLOSION HAZARD DATA 



Flammability Class: Flash Point: 154F SETA LEL : 1.1 % 

-EXTINGUISHING MEDIA: 

FOAM, CO2, OR DRY CHEMICAL 



-SPECIAL FIREFIGHTING PROCEDURES: 

WATER MAY BE USED TO KEEP EXPOSED CONTAINERS COOL, AND TO KEEP 

FLAMMABLE STRUCTURES WET. DO NOT ENTER FIRE AREA WITHOUT PROPER 



Page 1 





U0-105.TXT 

PROTECTION BECAUSE HAZARDOUS DECOMPOSITION PRODUCTS MAY BE 

PRESENT (SEE VI). 



Crawford Laboratories, Inc. 

Material Safety Data Sheet for: U0-105 



=============================================================================== 



SECTION IV - FIRE AND EXPLOSION HAZARD DATA (cont.) 



-UNUSUAL FIRE & EXPLOSION HAZARDS: 

WATER PRESSURE MAY SPREAD A COMBUSTIBLE LIQUID FIRE. 

SEALED CONTAINERS MAY EXPLODE IF OVERHEATED. 



=============================================================================== 



SECTION V - HEALTH HAZARD DATA 



-PERMISSIBLE EXPOSURE LEVEL: 

IF PEL'S ARE KNOWN, THEY ARE LISTED IN SECTION II 

W A R N I N G : CARE MUST BE TAKEN TO ASSURE THAT THE 

LOWEST OF THE EXPOSURE LIMITS SET FORTH IN SECTION II 

IS NOT EXCEEDED. WHEN IN DOUBT - WEAR AN APPROVED RESPIRATOR, 

AND ORDER AIR SAMPLING TESTS. (SEE SECTION VIII) 



-EFFECTS OF OVEREXPOSURE: 

OVEREXPOSURE MAY PRODUCE VARIOUS EFFECTS, INCLUDING: 

1-ACUTE TOXICITY, RESULTING IN HEADACHE, DIZZINESS, NAUSEA, AND 

LOSS OF CONSCIOUSNESS. 

2-SEVERE EYE IRRITATION POSSIBLY RESULTING IN PERMANENT DAMAGE. 

3-IRRITATED MUCOUS MEMBRANES. 

4-VOMITING DUE TO INGESTION. 

5-DEFATTING AND DRYING OF THE SKIN, WHICH MAY RESULT IN 

IRRITATION AND DERMATITIS. 

6-SENSITIZATION AFTER REPEATED CONTACT. 



-FIRST AID: 

--EYE CONTACT-FLUSH WITH PLENTY OF FRESH WATER FOR 15 MINUTES 

WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. 



--INHALATION-REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF 

BREATHING IS DIFFICULT. GIVE ARTIFICIAL RESPIRATION IF NOT 

BREATHING. GET MEDICAL ATTENTION. KEEP VICTIM WARM AND 

COMFORTABLE. NEVER GIVE AN UNCONSCIOUS PERSON LIQUIDS. 



-INGESTION- IF SWALLOWED, CALL PHYSICIAN IMMEDIATELY. 

ONLY INDUCE VOMITING ON INSTRUCTION OF PHYSICIAN. IF VOMITING 

OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT 

ASPIRATION OF LIQUID INTO THE LUNGS. 

NEVER GIVE AN UNCONSCIOUS PERSON LIQUIDS. 



--SKIN CONTACT-FLUSH WITH WATER WHILE REMOVING CONTAMINATED 

CLOTHING AND SHOES. FOLLOW BY WASHING WITH SOAP AND WATER. 

DO NOT REUSE CLOTHING OR SHOES UNTIL CLEANED. IF IRRITATION 

PERSISTS, GET MEDICAL ATTENTION. 



=============================================================================== 



SECTION VI - REACTIVITY DATA 



STABLITY: [ ] Unstable [x] Stable 

HAZARDOUS POLYMERIZATION: [ ] May occur [x] Will not occur 

-INCOMPATABILITY: 



MAY BE INCOMPATIBLE WITH STRONG OXIDIZING AGENTS AND STRONG 

ALKALIES. 

Page 2 





U0-105.TXT



 Crawford Laboratories, Inc. 

Material Safety Data Sheet for: U0-105 



=============================================================================== 



SECTION VI - REACTIVITY DATA (cont.) 



-CONDITIONS TO AVOID: 

AVOID HEAT, SPARKS, OPEN FLAMES, AND INCOMPATIBILITIES ABOVE. 

ALSO, AIRCRAFT TRANSPORT MUST BE IN STRICT ACCORDANCE WITH 

APPLICABLE REGULATIONS. 



-HAZARDOUS DECOMPOSITION PRODUCTS: 

INCOMPLETE COMBUSTION FOR PRODUCTS LIKE THIS MAY FORM HIGHLY 

POISONOUS CARBON MONOXIDE AND OTHER TOXIC GASES. 



=============================================================================== 



SECTION VII - SPILL OR LEAK PROCEDURES 



-STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED 

WARNING - COMBUSTIBLE. ELIMINATE ALL IGNITION SOURCES. 

HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING. 

WEARING THE PROTECTIVE CLOTHING OUTLINED IN SECTION VIII, 

SOAK UP WITH AN ABSORBANT AND PLACE IN NON-LEAKING 

CONTAINERS. SEAL TIGHTLY FOR PROPER DISPOSAL. 



-WASTE DISPOSAL METHOD: 

DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT LOCAL, STATE AND 

FEDERAL REGULATION. CONTACT AN APPROVED DISPOSAL FACILITY. 



=============================================================================== 



SECTION VIII - SPECIAL PROTECTION INFORMATION: 



-RESPIRATORY PROTECTION: 

PROPERLY FITTED NIOSH/MSHA APPROVED RESPIRATORS SHALL BE USED 

DURING APPLICATION UNLESS AIR MONITORING DEMONSTRATES VAPOR/ 

MIST LEVELS ARE BELOW APPLICABLE LIMITS. 



-VENTILATION: 

EFFECTIVE ENGINEERING CONTROLS SHOULD BE USED WHENEVER POSSIBLE. 

-PROTECTIVE GLOVES: 

USE RUBBER GLOVES 

-EYE PROTECTION: 

WEAR APPROVED SAFETY GOGGLES 

-OTHER PROTECTIVE EQUIPMENT: 

HAVE EYE BATH AND SAFETY SHOWER AVAILABLE. 

=============================================================================== 



SECTION IX - SPECIAL PRECAUTIONS 



-PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: 

TREAT AS ANY HAZARDOUS-COMBUSTIBLE MATERIAL; STORE IN A COOL, 

DRY PLACE IN BUILDINGS DESIGNED FOR THE STORAGE OF COMBUSTIBLE 

LIQUIDS. 

WARNING: HOT ORGANIC CHEMICAL VAPORS OR MISTS ARE SUSCEPTIBLE 

TO SUDDEN SPONTANEOUS COMBUSTION WHEN MIXED WITH AIR. 

IGNITION TEMPERATURES DECREASE WITH INCREASING VAPOR VOLUME AND 

VAPOR/AIR CONTACT TIME AND ARE INFLUENCED BY PRESSURE CHANGES. 



IGNITION MAY OCCUR AT TYPICAL ELEVATED TEMPERATURE PROCESS 

CONDITIONS, ESPECIALLY IN PROCESS OPERATING UNDER VACUUM IF 

SUBJECTED TO SUDDEN INGRESS OF AIR, OR OUTSIDE PROCESS 

EQUIPMENT OPERATING UNDER ELEVATED PRESSURE IF SUDDEN ESCAPE OF 

VAPORS OR MISTS TO THE ATMOSPHERE OCCURS. ANY PROPOSED USE OF 

THIS PRODUCT IN ELEVATED TEMPERATURE PROCESSES SHOULD BE 



Page 3 





U0-105.TXT 

THOROUGHLY EVALUATED TO ASSURE THAT SAFE OPERATING CONDITIONS 

(cont.) 



Crawford Laboratories, Inc. 

Material Safety Data Sheet for: U0-105 



=============================================================================== 



SECTION IX - SPECIAL PRECAUTIONS (cont.) 



-PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: (cont.) 

ARE ESTABLISHED AND MAINTAINED." 

-OTHER PRECAUTIONS: 



NOTE 



All information and opinions in this report are based on 

experience and computer programming which we believe to be 

reliable. We believe that the information contained herein 

is current as of the date of this report. Since the use of 

this information and of these opinions and the conditions of 

the use of the product are not within the control of 

Crawford Laboratories, Inc.,it's the user's obligation to 

determine the conditions of safe use of this product. 

Crawford Laboratories, Inc., makes no warranty, expressed 

or implied, as to the accuracy of the information and opinions, 

and assumes no responsibility for any damage to person, 

property or business arising from such use. 



text02 



Page 4