MATERIAL SAFETY DATA SHEET
ISSUE DATE: 1/7/98
REVISED DATE: 3/25/02
Supercedes: Any previous M.S.D.S. on this product
EMERGENCY TELEPHONE NUMBER: CHEM-TEL, INC 1-800-255-3924
I. IDENTIFICATION
PRODUCT NAME: C.L. Ward Water Base Duct Sealer C.L. Ward & Family Inc.
PRODUCT CLASS: Water Based Duct Sealant (Caulking) 1460 Delbert's Drive
Monongahela, PA 15063
II. HAZARDOUS INGREDIENTS
REPORTING REQUIREMENTS:
OSHA Hazard Communication Standard (29CFR1910.1200) hazard class鈥︹?︹?︹?︹?︹?︹??.鈥?.None
EPA SARA Title III Section 312 (40CFR370) hazard class鈥︹?︹?︹?︹?︹?︹?︹?︹?︹?︹?︹?︹?︹??..None
EPA SARA Title III Section 313 (40CFR372) toxic chemicals above 鈥渄e minimis鈥? level are鈥?.None
CALIFORNIA PROP 65 substances listed by the State of California under the 鈥淪afe Drinking Water and Toxic Enforcement Act of 1986鈥?.
No such substances are present in reportable amounts for occupational exposure as per OSHA鈥檚 approval of the California Hazard
Communication Standard, Federal Register, page 31159 ff, 6 June 1997.
III. PHYSICAL DATA
APPEARANCE: Gray caulking
SOLUBILITY IN WATER: Dilutable
BOILING POINT: 100掳C / 212掳F
WEIGHT PER GALLON: 11 卤 .2 lbs/gallon
VOLATILE BY WEIGHT: 34% 卤 2% (Water)
VAPOR DENSITY: Heavier than Air.
EVAPORATION RATE: (BAC = 1) Less than 1
ODOR: Mild
PHYSICAL STATE: Paste
Ph: 8 to 9.5
IV. HEALTH HAZARD DATA
CAUTION: May cause discomfort in eyes. Prolonged or repeated contact with skin may cause dryness.
IN EYES: Flush with water for 15 minutes.
ON SKIN: Wash with soap and water.
INGESTED: Seek medical attention.
INHALATION: No effects expected. If difficulty breathing occurs remove to fresh air and consult physician.
V. EMERGENCY AND FIRST AID
FLAMMABILITY CLASS (OSHA/NFPA): None.
FLASHPOINT: >212掳F PM Closed cup
EXTINGUISHING MEDIA: Water or dry type extinguisher.
UNUSUAL FIRE HAZARD: Containers may burst when exposed to extreme heat.
FIRE FIGHTING PROCEDURES: Firemen should wear equipment to protect against noxious fumes. Self contained breathing
apparatus my be needed
PRODUCT OF COMBUSTION: May yield Carbon Monoxide and/or Carbon Dioxide.
VI. SPILL OR LEAK PROCEDURES
Collect spilled material in salvage container. Small amounts may be absorbed into appropriate absorbents. Prevent spill from entering
sewers, drains, and waterways.
Dispose of product in accordance with applicable local, state, and federal regulations.
VII. SPECIAL PROTECTION
VENTILATION: Provide sufficient ventilation to maintain constant fresh air in workplace.
EYE PROTECTION: Use safety goggles when splash potential exists.
HAND PROTECTION: Protective impervious gloves are recommended.
OTHER: A clean source of water should be available for washing eyes and skin.
VIII. REGULATORY INFORMATION
Non-flammable, as a Latex compound
U.S.A.: Regulation by the following: DOT, IMO, ICAD/IATA: None
Canada: Regulation by the following: DSL, WHMIS: None
European: EEC SYMBOL: None
EEC Classification, Packaging and Labeling of Dangerous Substances: None
TSCA 12(b) Export Notification Requirement: All components of this product are either listed on the U.S. Toxic Substances Control Act
(TSCA) inventory of chemicals or are otherwise compliant with TSCA regulations.
IX. REACTIVITY DATA
STABILITY: Stable under normal conditions of handling and use.
INCOMPATIBILITY: Products may react violently with products that react with water.
HAZARDOUS DECOMPOSITION: Fumes produced when heated to decomposition may include: oxides of carbon, nitrogen, and sulfur
along with hydrocarbon residues.
HAZARDOUS POLYMERIZATION: Will not occur.
X. SPECIAL PRECAUTIONS
HANDLING AND STORAGE: Store in tightly closed containers at temperatures 45掳F to 90掳F. . Guard against inhalation of excess
vapors, ingestion, and contact with skin and eyes. Change soiled workclothes frequently. Clean hands after handling. Precautions also
apply to emptied containers. Keep containers away from extreme heat and cold. Prevent from freezing, but if product is allowed to freeze,
thaw completely before use.
This information is taken from sources or based upon data believed to be reliable; however, C.L. Ward & Family Inc. makes no
warranty as to the absolute correctness or sufficiency of any of the foregoing or that additional or other measures may not be required under
particular conditions. Although certain hazards are described herein, we cannot guarantee that these are the only hazards that exist, as all
materials may present unknown health hazards.
155/3-02
|