Material Safely Data Sheet FERROQUEST LP7200 Page 1 of 6
-
GE Betz, Inc. Material Safety Data Sheet
4636 Somerton Road
Trevose, PA 19053 Issue Date: 27-OCT-1999
Business telephone: (215) 355-3300
EMERGENCY TELEPHONE (Health/Accident): (800) 877-1940
1 PRODUCT IDENTIFICATION
PRODUCT NAME:
FERROQUEST LP7200
PRODUCT APPLICATION AREA:
CHEMICAL CLEANING COMPOUND.
2 COMPOSITION / INFORMATION ON INGREDIENTS
Information for specific product ingredients as required by the U.S. OSHA HAZARD COMMUNICATION
STANDARD is listed. Refer to additional sections of this MSDS for our assessment of the potential hazards of this
formulation. This product is subject to the Pennsylvania and New Jersey Worker and Community Right to Know Law.
HAZARDOUS INGREDIENTS:
CAS# CHEMICAL NAME
TRADE SECRET INGREDIENT(E195);TSRN 125438 5118P
Irritant (eyes)
TRADE SECRET INGREDIENT(122);;TSRN 125438 - 52l4P
Potential irritant (eyes)
No component is considered to be a carcinogen by the National Toxicology
Program, the International Agency for Research on Cancer, or the
Occupational Safety and Health Administration at Pennsylvania thresholds
for carcinogens.
NON-HAZARDOUS INGREDIENTS:
CAS# CHEMICAL NAME
7732 18-5 WATER
123 76-2 LEVULINIC ACID
TRADE SECRET (NK55) TSRN: 125438 - 5628P
http ://tsg/ge betz msds/Betz_HTML/PRODUCTS/PA_NJ/FERROQUESTLP7200.html
9/11/2003
Material Safety Data Sheet FERROQUEST LP7200 Page 2 of 6
-
3 HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
WARNING
May cause slight irritation to the skin. Severe irritant to the eyes. Vapors, gases, mists and/or aerosols cause
irritation to the upper respiratory tract.
DOT hazard: Corrosive to steel
Emergency Response Guide #153
Odor: Pungent; Appearance: Colorless To Green, Liquid
Fire fighters should wear positive pressure self-contained breathing apparatus(full face-piece type). Proper fire-
extinguishing media~ dry chemical, carbon dioxide, foam or water
POTENTIAL HEALTH EFFECTS
ACUTE SKIN EFFECTS:
Primary route of exposure; May cause slight irritation to the skin.
ACUTE EYE EFFECTS:
Severe irritant to the eyes.
ACUTE RESPIRATORY EFFECTS:
Primary route of exposure; Vapors, gases, mists and/or aerosols cause irritation to the upper respiratory tract.
INGESTION EFFECTS:
May cause slight gastrointestinal irritation with possible nausea, vomiting, diarrhea, incoordination, mental
confusion, dizziness and lethargy.
TARGET ORGANS:
Prolonged or repeated exposures may cause primary irritant dermatitis and/or toxicity to the lung.
MEDICAL CONDITIONS AGGRAVATED:
Not known.
SYMPTOMS OF EXPOSURE:
Inhalation may cause irritation of the respiratory tract. Skin contact may cause itching and/or redness.
4 FIRST AID MEASURES
SKIN CONTACT:
Wash thoroughly with soap and water. Remove contaminated clothing. Thoroughly wash clothing before reuse.
Get medical attention if irritation develops or persists.
EYE CONTACT:
Remove contact lenses. Hold eyelids apart. Immediately flush eyes with plenty of low-pressure water for at least
15 minutes. Get immediate medical attention.
INHALATION:
Material Safety Data Sheet FERROQUEST LP7200 Page 3 of 6
-
If nasal, throat or lung irritation develops remove to fresh air and get medical attention.
INGESTION:
Do not feed anything by mouth to an unconscious or convulsive victim. Do not induce vomiting. Immediately
contact physician. Dilute contents of stomach using 3-4 glasses milk or water.
NOTES TO PHYSICIANS:
No special instructions
5 FIRE FIGHTING MEASURES
FIRE FIGHTING INSTRUCTIONS:
Fire fighters should wear positive pressure self-contained breathing apparatus (full face-piece type)
EXTINGUISHING MEDIA:
dry chemical, carbon dioxide, foam or water
HAZARDOUS DECOMPOSITION PRODUCTS:
Thermal decomposition (destructive fires) yields elemental oxides.
FLASH POINT:
200F > 93C P-M(CC)
MISCELLANEOUS:
Corrosive to steel
UN3265;Emergency Response Guide #153
6 ACCIDENTAL RELEASE MEASURES
PROTECTION AND SPILL CONTAINMENT:
Ventilate area. Use specified protective equipment. Contain and absorb on absorbent material. Place in waste
disposal container. Flush area with water. Wet area may be slippery. Spread sand/grit.
DISPOSAL INSTRUCTIONS:
Water contaminated with this product may be sent to a sanitary sewer treatment facility, in accordance with any
local agreement a permitted waste treatment facility or discharged under a permit. Product as is - Incinerace or land
dispose in an approved landfill.
7 HANDLING & STORAGE
HANDLING:
Contains an oxidizer. Avoid all contact with reducing agents, oils, greases, organics and acids.
STORAGE:
Keep containers closed when not in use. Reasonable and safe chemical storage. Protect from freezing.
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
EXPOSURE LIMITS
CHEMICAL NAME
TRADE SECRET INGREDIENT(E195);TSRN 125438 - 5118P
PEL (OSHA) : NOT DETERMINED
TLV (ACGIH) NOT DETERMINED
TRADE SECRET INGREDIENT{122);;TSRN 125438 - 5214P
PEL (OSHA) NUISANCE DUST
TLV (ACGIH) : 5 MG/M3
Note: manufacturer鈥檚 recommended exposure limit: 10 mg/m3.
MISC:
Material Safety Data Sheet FERROQUEST LP7200 Page 4 of 6
-
ENGINEERING CONTROLS:
Adequate ventilation to maintain air contaminants below exposure 1 imits.
PERSONAL PROTECTIVE EQUIPMENT:
Use protective equipment in accordance with 29CFR 1910 Subpart I
RESPIRATORY PROTECTION:
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA鈥橲 29 CFR
1910.134 AND ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED WHENEVER
WORKPLACE CONDITIONS WARRANT A RESPIRATOR鈥橲 USE.
USE AIR PURIFYING RESPIRATORS WITHIN USE LIMITATIONS ASSOCIATED
WITH THE EQUIPMENT OR ELSE USE SUPPLIED AIR-RESPIRATORS.
If air-purifying respirator use is appropriate, use a
respirator with dust/mist filters.
SKIN PROTECTION:
neoprene gloves-- Wash off after each use. Replace as
necessary.
EYE PROTECTION:
splash proof chemical goggles
9 PHYSICAL & CHEMICAL PROPERTIES
Specific Gray. (70F,2lC) 1.070 Vapor Pressure (mmHG) 36.0
Freeze Point (F) 27 Vapor Density (air~l) < 1.00
Freeze Point (C) -3
Viscosity(cps 70F,21C) 9 Solubility (water) 100.0
Odor Pungent
Appearance Colorless To Green
Physical State Liquid
Flash Point P-M(CC) > 200F > 93C
pH As Is (approx.) 1.4
Evaporation Rate (Ether=l) < 1.00
NA = not applicable ND = not determined
10 STABILITY & REACTIVITY
STABILITY:
Stable under normal storage conditions.
HAZARDOUS POLYMERIZATION:
Will not occur.
INCOMPATIBILITIES:
May react with strong oxidizers.
DECOMPOSITION PRODUCTS:
Thermal decomposition (destructive fires) yields elemental oxides.
INTERNAL PUMPOUT/CLEANOUT CATEGORIES:
I鈥? 鈥?
11 TOXICOLOGICAL INFORMATiON
Oral LD5O RAT: 6,829 mg/kg
Dermal LD5O RABBIT: i~5,000 mg/kg
NOTE - Estimated value
12 ECOLOGICAL INFORMATION
Material Safety Data Sheet FERROQUEST LP鈥? 720() Page 5 of 6
-
AQUATIC TOXICOLOGY
Daphnia magna 48 Hour Static Screen
0% Mortality= 1000 mg/L
Fathead Minnow 96 Hour Static Screen
0% Morta1ity~ 1500 mg/C
BIODEGRADATION
BOD-28 (mg/g) 447
BOD-5 (mg/g) 336
COD (mg/g) : 388
TOO (mg/g) 177
13 DISPOSAL CONSIDERATIONS
If this undiluted product is discarded as a waste, the US RCRA hazardous waste identification number is
0002=Corrosive(pH, steel)
Please be advised; however, that state and local requirements for waste disposal may be more restrictive or
otherwise different from federal regulations. Consult state and local regulations regarding the proper disposal of
this material.
14 TRANSPORT INFORMATiON
DOT HAZARD Corrosive to steel
UN / NA NUMBER: UN3265
DOT EMERGENCY RESPONSE GUIDE tf: 153
15 REGULATORY INFORMATION
TSCA:
All components of this product are listed in the TSCA inventory.
CERCLA AND/OR SARA REPORTABLE QUANTITY (RQ):
No regulated constituent present at OSHA thresholds
SARA SECTION 312 HAZARD CLASS:
Immediate (acute) ;Delayed(Chronic)
SARA SECTION 302 CHEMICALS:
No regulated constituent present at OSHA thresholds
SARA SECTION 313 CHEMICALS:
No regulated constituent present at OSHA thresholds
CALIFORNIA REGULATORY INFORMATION
CALIFORNIA SAFE DRINKING WATER AND TOXIC
ENFORCEMENT ACT (PROPOSITION 65) CHEMICALS PRESENT:
No regulated constituent present at OSHA thresholds
MICHIGAN REGULATORY INFORMATION
No regulated constiiiiient present at OSHA thresholds
16 OTI-IER INFORMATION
NFPA/HMIS CODE TRANSLATION
Health Moderate Hazard
2
Material Safety Data Sheet FERROQUEST LP7200 Page6of6
-
Fire 1 Slight Hazard
Reactivity 0 Minimal Hazard
Special CORR DOT corrosive
(1) Protective Equipment B Goqqles, Gloves
(1) refer to section 8 of MSDS for additional protective equipment recommendations.
CHANGE LOG
EFFECTIVE
DATE REVISIONS TO SECTION: SUPERCEDES
MSDS status: 25-SEP-l997 ** NEW **
27-OCT-l999 3,4 25-SEP-1997
http ://tsg/ge betz rnsds/Betz_HTML/PRODUCTS/PA_NJ/FERROQUESTLP7200.html
9/11/2003
|