Commercial Food Equipment Service Association P_0000393220 D_0000423024
B5
MATERIAL SAFETY DATA SHEET
Radiator Specialty Company
1900 WILKINSON BLVD. CHARLOTTE, NC 28208 (704) 377-6555
POISON INFORMATION & EMERGENCY: 303-623-5716
MATERIAL SAFETY DATA SHEET US DEPARTMENT OF LABOR
May be used to comply with OSHA鈥檚 Hazard Occupational Safety and Health Administration.
Communication Standard 29 CFR 1910.1200. (Non-Mandatory Form) Form Approved OMB No.
Standard must be consulted for specific require- 1218-0072
ments.
SECTION I GENERAL INFORMATION
PRODUCT NAME RUST RAIDER
PART NUMBER B5 32, 34, 40
NOTE: Blank spaces are not permitted. If any item is not applicable or no information is available, the space must
be marked to indicate that.
SECTION II HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
COMPONENT WT% C.A.S. NO. TLV (ACGIH-------OSHA-------)
Sodium Tetraborate
3
decahydrate 1-5 1303-96-4 5 mg/M
Note: This product contains a mixture of corrosion inhibitors considered to be proprietary in nature.
Comments:
Components not identified are non-hazardous according to 29 CFR 1910.1200
SECTION III PHYSICAL/CHEMICAL CHARACTERISTICS
Specific Gravity (H2O=1) 1.05 pH 11-12
Solubility in Water Complete Solubility in Solvent insoluble
0
Flash Point (Method) - F none % Volatiles By Wt. >70
0 0 0
Melting Point - F N/A Boiling Point - F over 215 F
Vapor Pressure (mm Hg) N/A Vapor Density (Air=1) N/A
Evaporation Rate (Butyl Acetate=1) <1
Appearance and Odor Fluorescent green, transparent liquid
SECTION IV FIRE AND EXPLOSION HAZARD DATA
EXTINGUISHING MEDIA: NON-FLAMMABLE
Water Fog Foam CO2 Dry Chemical
SPECIAL FIRE FIGHTING PROCEDURES. Wear self-contained, positive pressure breathing apparatus and
protective clothes.
UNUSUAL FIRE AND EXPLOSION HAZARDS
None known
B5
Commercial Food Equipment Service Association P_0000393220 D_0000423024
SECTION V REACTIVITY DATA
Stable X Unstable Corrosive No Hazardous Polymerization? Yes No X
Incompatibilities
Oxidizing agents, acids.
Hazardous Decomposition or Byproducts
Not known
SECTION VI HEALTH HAZARD INFORMATION
3
Recommended TLV of Product Sodium Tetraborate (dust) 5mg/m
EYE CONTACT Eye irritant SKIN CONTACT Slightly irritating
INHALATION N/A INGESTION May be harmful or fatal. Can cause nausea, diarrhea,
vomiting, damage central nervous system.
OTHER N/A
SECTION VII EMERGENCY AND FIRST AID PROCEDURES
EYE CONTACT Flush eyes with water for 15 minutes while lifting eyelids. Consulta physician immediately.
SKIN CONTACT Wash with soap and water, thoroughly. Remove contaminated clothing. If irritation persists, see a physician.
INHALATION May be mildly irritating on prolonged exposure. If affected, move to fresh air. If symptoms persist, see a physician.
INGESTION Drink 2 glasses of water. INDUCE VOMITING. See a physician immediately.
SECTION VIII SPECIAL PROTECTION INFORMATION
CONSUMER BULK HANDLING (Prolonged Exposure)
RESPIRATORY
PROTECTION N/A If dust over TLV use dust mask
VENTILATION N/A General
EYE PROTECTION N/A Fully protective goggles or face shield.
PROTECTIVE
CLOTHING N/A Rubber gloves, apron.
SECTION IX PRECAUTIONS FOR SAFE HANDLING AND USE
SPILL OR LEAK PROCEDURE Contain spill , add dry absorbent and shovel or sweep up and transfer to waste drum.
WASTE DISPOSAL METHOD Dispose of in accordance with all applicable government laws and regulations.
STORAGE AND HANDLING PRECAUTIONS Store away from oxidizing agents and acids.
OTHER PRECAUTIONS KEEP AWAY FROM CHILDREN AND ANIMALS
Supersedes DECEMBER 1996 OSHA Revised APRIL 1999
Title R. GEER- CHEMIST
While Radiator Specialty Company believes this data is accurate
as of the revision date, we make no warranty with respect to the data
and we expressly disclaim all liability for reliance thereon. The data
is offered solely for information, investigation, and verification.
|