Huntsman Advanced Materials Americas Inc.
Distributed by Freeman Mfg & Supply Co.
800.321.8511 www.freemansupply.com
24-Hour Emergency Phone: (800) 328-8501
MSDS No: 6762
Effective Date: 1/22/07 Material Safety Data Sheet
Health: 1
1. PRODUCT IDENTIFICATION 3
Flammability: 3
1 0
Reactivity: 0
Trade Name: RP 802 Green Sealer
Personal Protection:
Chemical Family: Vinyl Lacquer
HMIS RATING
NFPA RATING
Intended Use or Product Type:
Sealer
2. COMPOSITION / INFORMATION ON INGREDIENTS
O CAS No. CHEMICAL IDENTITY EXPOSURE LIMITS CARCINOGEN
S STATUS
H ACGIH OSHA MFR. IARC NTP OSHA
A TWA STEL PEL STEL
* 108-10-1 2-Pentanone, 4-methyl- 50 ppm 75 ppm 100 75 ppm NE NR NR NR
ppm
Common Methyl isobutyl ketone
Name:
* 108-88-3 Benzene, methyl- 50 ppm NE NE 150 NE NR NR NR
ppm
Common Toluene
Name:
* 78-93-3 2-Butanone 200 300 200 300 NE NR NR NR
ppm ppm ppm ppm
Common Methyl ethyl ketone
Name:
* 9003-22-9 Acetic Acid Ethenyl Ester, Polymer NE NE NE NE NE NR NR NR
with Chloroethene
Common Vinyl chloride-vinyl acetate resin
Name:
NE = Not Established NR = Not Reviewed * = OSHA Hazardous Ingredient
3. HAZARDS IDENTIFICATION
Emergency Overview: Flammable. Causes skin and eye irritation.
Printed: 4/17/2007 Page 1 of 6
RP 802 Green Sealer Huntsman Advanced Materials
Effective Date: 1/22/07 Americas Inc. (EL)
Primary Route(s) of Entry: Dermal; heated product may produce inhalable vapors.
4. FIRST AID MEASURES
Ingestion: Do not induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an
unconscious person. Seek immediate medical attention.
Skin: Immediately wash with soap and water. Remove contaminated clothing and launder before reuse. Destroy contaminated
shoes. Seek immediate medical attention.
Inhalation: Remove to fresh air. Seek immediate medical attention.
Eyes: Immediately flush eyes with water for at least 15 minutes. Seek immediate medical attention.
Overexposure Effects: Causes skin and eye irritation.
Medical Conditions Aggravated by Exposure: Skin and eye conditions.
Additional Information: Referral to a physician is recommended if there is any question about the seriousness of any injury.
5. FIRE FIGHTING MEASURES
39掳F (4 掳C)
Flash Point:
TCC
Flash Point Method Used:
1.2
Flammable Limits in Air (Lower - % by volume):
Not established
Flammable Limits in Air (Upper - % by volume):
Fire Fighting Extinguishing Media: Carbon dioxide, dry chemical, foam, water.
Fire Fighting Equipment: Use self-contained breathing apparatus.
Fire and Explosion Hazards: Decomposition and combustion products may be toxic.
6. ACCIDENTAL RELEASE MEASURES
Accidental Release Measures: Remove spillage by absorbing in absorbent material.
7. HANDLING AND STORAGE
Signal Word: Warning!
Precautions: Flammable liquid. Keep away from heat, sparks, and flame. Keep container closed when not in use. Use with
adequate ventilation. Can cause skin and eye irritation. Avoid contact with eyes, skin, and clothing. Wash thoroughly after
handling.
Other Handling Information: Nuisance dust may be generated when sanding or sawing cured material.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Printed: 4/17/2007 Page 2 of 6
RP 802 Green Sealer Huntsman Advanced Materials
Effective Date: 1/22/07 Americas Inc. (EL)
Skin Protection: Wear impermeable gloves.
Respiratory Protection: Use NIOSH approved organic vapor cartridge respirator when vapor/mist exposure is likely.
Eye Protection: Wear splash-proof chemical goggles.
Engineering Controls: General mechanical and local exhaust in accordance with ACGIH recommendations.
9. PHYSICAL AND CHEMICAL PROPERTIES
Green
Color:
Ketone
Odor:
Liquid
Physical State:
Nil
Solubility in Water:
70 mm Hg at 25掳C (77 掳F)
Vapor Pressure:
0.9 - 0.91 (water = 1)
Specific Gravity:
174 - 243掳F (79 - 117 掳C)
Boiling Point:
Slower than Ether
Evaporation Rate:
Not Determined
Vapor Density:
360 - 540 g/L
VOC:
Not Determined
pH:
Percent Volatile: Negligible.
10. STABILITY AND REACTIVITY
Conditions to Avoid: Excessive heat for prolonged periods of time.
Stability: Stable.
Hazardous Decomposition Products: Combustion may form toxic materials, such as carbon dioxide, carbon monoxide.
Hazardous Polymerization: Will not occur.
11. TOXICOLOGICAL INFORMATION
Skin Irritation: Irritant.
Eye Irritation: Irritant.
12. ECOLOGICAL INFORMATION
13. DISPOSAL CONSIDERATIONS
Waste Disposal Method: Consult qualified local or corporate personnel for method that will comply with local, state and federal
health and environmental regulations.
Printed: 4/17/2007 Page 3 of 6
RP 802 Green Sealer Huntsman Advanced Materials
Effective Date: 1/22/07 Americas Inc. (EL)
14. TRANSPORT INFORMATION
DOT: Non-Bulk
Flammable Liquid, n.o.s.
Proper Shipping Name:
Methyl Isobutyl Ketone, Methyl ethyl ketone
Technical Shipping Name (If n.o.s.):
3
Hazard Class:
UN 1993
ID Number:
PG II
Packing Group:
Flammable liquid
Label:
15. REGULATORY INFORMATION
US Federal Regulations:
Occupational Safety and Health Act (OSHA): This Material Safety Data Sheet (MSDS) has been prepared in compliance with
the federal OSHA Hazard Communication Standard 29 CFR 1910.1200. This product is considered to be a hazardous chemical
under that standard.
Resource Conservation and Recovery Act (RCRA): D 001 ignitable.
SARA Title III: Section 313 Toxic Chemical List (TCL): This product contains a toxic chemical(s) for routine annual toxic
chemical release reporting under section 313 (40 CFR 372). This information must be included in all MSDS's copied or distributed
for this material.
Chemical Name: 2-Pentanone, 4-methyl-
Common Name: Methyl isobutyl ketone
Percent in Composition: 36.97 % by wt
Comment:
Chemical Name: Benzene, methyl-
Common Name: Toluene
Percent in Composition: 36.43 % by wt
Comment:
Chemical Name: 2-Butanone
Common Name: Methyl ethyl ketone
Percent in Composition: 7.37 % by wt
Comment:
TSCA Section 8(b) - Inventory Status: All chemical components of this product are in compliance with TSCA inventory
requirements.
TSCA Section 12(b) - Export Notification: This product does not contain any chemical(s) that are subject to a Section 12(b)
export notification.
State Regulations:
California Proposition 65: The following is required composition information. This product contains the following chemical(s)
which are currently listed on the California list of Known Carcinogens and Reproductive Toxins:
Chemical Name: Benzene, methyl-
Printed: 4/17/2007 Page 4 of 6
RP 802 Green Sealer Huntsman Advanced Materials
Effective Date: 1/22/07 Americas Inc. (EL)
Common Name: Toluene
CAS Number: 108-88-3
Percent in Composition: 36.43 % by wt
Comment: Warning! This chemical is known to the State of California to cause birth defects or other reproductive harm.
Pennsylvania Right-to-Know: The following is required composition information:
Chemical Name: 2-Pentanone, 4-methyl-
Common Name: Methyl isobutyl ketone
CAS Number: 108-10-1
Comment: Environmental Hazardous Substance
Chemical Name: Benzene, methyl-
Common Name: Toluene
CAS Number: 108-88-3
Comment: Environmental Hazardous Substance
Chemical Name: Acetic Acid Ethenyl Ester, Polymer with Chloroethene
Common Name: Vinyl chloride-vinyl acetate resin
CAS Number: 9003-22-9
Comment: Not on Pennsylvania Hazardous Substance List
Chemical Name: 2-Butanone
Common Name: Methyl ethyl ketone
CAS Number: 78-93-3
Comment: Environmental Hazardous Substance
16. OTHER INFORMATION
6762
MSDS No:
Dianne Blessing
Approved By:
EH&S Specialist
Title:
Disclaimer: The information and recommendations contained herein are based upon tests in controlled laboratory conditions, are
believed to be correct, and are provided for the sole purpose of hazard communication as part of Huntsman's product safety
program. This product has not been tested for, and therefore is not recommended or suitable for, uses for which prolonged contact
with mucous membranes, abraded skin, or blood is intended or likely, or for uses for which implantation within the human body is
intended, and Huntsman assumes no liability for any such uses.
The information and recommendations contained herein are not intended to constitute performance information concerning the
product, which is available in separate technical data sheets available from Huntsman upon request. Users are urged, and are urged
to urge others who may come in contact with the product, to obtain and consult data sheets prior to purchase, use, transportation or
storage of the product.
HUNTSMAN MAKES NO REPRESENTATION OR WARRANTY, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY, QUALITY, OR FITNESS FOR A PARTICULAR PURPOSE. HUNTSMAN'S LIABILITY IS
STRICTLY LIMITED TO REIMBURSEMENT OF BUYER'S PURCHASE PRICE, OR IN HUNTSMAN'S DISCRETION
REPLACEMENT, OF THE PRODUCT IN RESPECT OF WHICH SUCH CLAIM IS MADE. HUNTSMAN'S LIABILITY IS
STRICTLY LIMITED BY LEGAL NOTICES IN TECHNICAL DATA SHEETS, PRODUCT LITERATURE, AND/OR SALE
DOCUMENTS. The foregoing DISCLAIMERS and LIMITATION OF LIABILITY supercede inconsistent or contradictory
provisions in Buyer's documents.
Printed: 4/17/2007 Page 5 of 6
RP 802 Green Sealer Huntsman Advanced Materials
Effective Date: 1/22/07 Americas Inc. (EL)
USER SHOULD CONSULT A LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENTAL AGENCY TO DETERMINE
THE APPLICABILITY OR EFFECT OF ANY LAW OR REGULATION WITH RESPECT TO THE PRODUCT. HUNTSMAN
DOES NOT UNDERTAKE TO FURNISH ADVICE ON SUCH MATTERS.
NO PERSON OR ORGANIZATION EXCEPT A DULY AUTHORIZED HUNTSMAN EMPLOYEE IS AUTHORIZED TO
PROVIDE OR MAKE AVAILABLE DATA SHEETS FOR HUNTSMAN PRODUCTS. DATA SHEETS FROM
UNAUTHORIZED SOURCES MAY CONTAIN INFORMATION THAT IS NO LONGER CURRENT OR ACCURATE. NO
PART OF THIS DATA SHEET MAY BE REPRODUCED OR TRANSMITTED IN ANY FORM, OR BY ANY MEANS,
WITHOUT PERMISSION IN WRITING FROM HUNTSMAN. ALL REQUESTS FOR PERMISSION TO REPRODUCE
MATERIAL FROM THIS DATA SHEET SHOULD BE DIRECTED TO HUNTSMAN, MANAGER, PRODUCT SAFETY AT
THE ABOVE ADDRESS.
Printed: 4/17/2007 Page 6 of 6
|