MATERIAL SAFETY DATA SHEET
KWIKSEAL
====================================================================================
SECTION I - IDENTIFICATION
====================================================================================
NFPA PROTECTION ........ X
TRANSPORTATION EMERGENCY: NFPA HEALTH ............ 0
CHEM-TEL 1-800-255-3924 NFPA FLAMMABILITY ...... 2
INFORMATION: 860-347-2505 NFPA REACTIVITY ........ 0
DU-LITE CORPORATION
171 RIVER ROAD PREPARED BY: WALTER J. SMITH
DATE: 4/01/2006
MIDDLETOWN, CT 06457
PRODUCT NAME .........KWIKSEAL
DESCRIPTION ..........Rust Preventative Oil
DOT DESCRIP.: COMBUSTIBLE LIQUID, N.O.S., (CONTAINS MINERAL SPIRITS)
NA-1993, PG-III
DOT LABEL: (No DOT label required) DOT PLACARD: Combustible or Flammable
====================================================================================
SECTION II - HAZARDOUS INGREDIENTS
====================================================================================
HAZARDOUS COMPONENT CAS NUMBER TLV(MG/M3) PEL(MG/M3) PERCENT
LOW AROMATIC
HYDROCARBON SOLVENT 8032-32-4 100 PPM REC. <77-87
NON-HAZARDOUS N/A N/A N/A <13-23
__________________________________________________________________________
N/E = NOT ESTABLISHED N/A = NOT APPLICABLE N/D = NOT DETERMINED
====================================================================================
SECTION III - PHYSICAL DATA
====================================================================================
BOILING POINT(掳F).........300掳F SPECIFIC GRAVITY (H20=1)... 0.815
VAPOR PRESSURE (mm Hg)....1 @ 100掳F MELTING POINT.............. N/A
VAPOR DENSITY (Air=1)....5.1 EVAPORATION RATE........... <0.1
SOLUBILITY IN H20.........Negligible PH.................Neutral
APPEARANCE/ODOR....Clear, dark, low viscosity liquid - slight hydrocarbon odor.
====================================================================================
SECTION IV - REACTIVITY DATA
====================================================================================
CHEMICAL STABILITY: Stable
CONDITIONS TO AVOID: Open flame or excessive heat.
INCOMPATIBLE MATERIALS: Strong oxidizers.
DECOMPOSITION PRODUCTS: Fumes, smoke, carbon monoxide, carbon dioxide and
organic compounds.
HAZARDOUS POLYMERIZATION: Will not occur.
====================================================================================
SECTION V - FIRE AND EXPLOSION HAZARD DATA
====================================================================================
FLASH POINT................112掳F PMCC FLAMMABLE LIMITS..LEL-0.9% VEL-7%
AUTOIGNITION TEMP..........490掳F
IN CASE OF FIRE: Material is flammable petroleum liquid.
Use extinguishing carbon dioxide, foam or dry chemical media.
SPECIAL FIREFIGHTING PROCEDURES: Wear protective clothing with self-contained
breathing apparatus.
UNUSUAL FIRE HAZARDS: Petroleum liquid. Product will float and spread on water.
====================================================================================
SECTION VI - HEALTH HAZARD DATA
====================================================================================
ROUTES OF ENTRY: Eye contact, skin contact, inhalation, ingestion.
HEALTH HAZARDS (ACUTE, CHRONIC):
Skin - repeated or prolonged contact may cause dermatitis or loss of skin oils.
Eyes - Contact may cause mild irritation.
Inhalation - Mildly irritating in high concentrations.
Ingestion - Low oral toxicity.
CARCINOGENICITY: None. NTP?: No. IARC?: No. OSHA REGULATED?: No.
FIRST AID:
INHALATION:
Move victim to fresh air.
If not breathing, use artificial respiration.
If breathing is difficult, give oxygen.
Seek medical attention.
EYES:
Flush well with water.
SKIN:
Wash well with soap and water.
Remove contaminated clothing and launder.
Seek medical attention if irritation occurs.
INGESTION:
Low oral toxicity. Do not induce vomiting.
====================================================================================
SECTION VII - PRECAUTIONS/PROCEDURES
====================================================================================
IN CASE OF SPILL: Contain and collect free liquid.
Contain spills with absorbent such as sand or clay.
WASTE DISPOSAL METHOD: Dispose of in accordance with local, state and federal EPA
regulations. Treat waste as an oil product.
PRECAUTIONS: Wear proper protective clothing when using this product.
Use with adequate ventilation.
Wash thoroughly after handling. Store away from excessive heat or open flame.
This is an oil product. Do not allow spills to enter waterways or drainage system.
If spill enters waterway and causes sheen, report to
National Response Center at 800-424-8602.
OTHER PRECAUTIONS: Emptied containers of this product may contain hazardous vapors and
residue. Clean thoroughly before reusing or discarding.
Do not use a welding torch to cut container.
Do not use for water or food storage.
====================================================================================
SECTION VIII - SPECIAL PROTECTION
====================================================================================
RESPIRATORY PROTECTION:
Use NIOSH approved respirator if vapors are excessive.
VENTILATION: Maintain below TLV. MECHANICAL EXHAUST...X
PROTECTIVE GLOVES: Rubber. LOCAL EXHAUST........X
EYE PROTECTION: Safety goggles, face shield.
OTHER PROTECTIVE EQUIPMENT... Apron, boots, full cover work clothes.
WORK/HYGIENIC PRACTICES...... Wash thoroughly after handling, launder clothes.
====================================================================================
SECTION IX - SARA TITLE III INFORMATION
====================================================================================
HAZARDOUS CERCLA SECT 302 SECT 313 SECT 311/312
COMPONENT RQ LBS. TPQ LBS. TOXIC HAZARDS
Low Aromatic N/A N/A N/A A,C
Hydrocarbon Solvent
A=IMMEDIATE (ACUTE HEALTH HAZARD) B=DELAYED (CHRONIC) HEALTH HAZARD
C=FIRE HAZARD D= SUDDEN RELEASE OF PRESSURE HAZARD E=REACTIVE HAZARD
漏 Du-Lite Corporation 2004. All Rights Reserved.
|