Material Safety Data Sheet
Emergency Phone:(248)-373-8100 24-Hour CHEMTREC (800)-424-9300 CHEMTREC, D.C. Area (800)-483-7616
I. Chemical Product And Company Data
2
Health
PRODUCT: ISO-FLEX 628
CHEMICALFAMILY: Silane Emulsion 1
Flammability
REVISION DATE: MAR 2007 1
Reactivity
MANUFACTURER: LymTal International, Inc. H
Personal Protection
4150 S. Lapeer Rd. Orion, MI 48359
II. Composition / Information On Ingredients
This document is prepared pursuant to the OSHA Hazard Communication Standard (29 CFR 1910.1200).
Where a proprietary ingredient is shown, the identity may be made available as provided in this standard.
All components of this product are included in the EPA Toxic Substances Control Act (TSCA) Chemical
Substance Inventory.
EXPOSURE LIMITS
HAZARDOUS INGREDIENTS CAS NO TLV STEL PEL CONTENT
N/A N/A N/A
Dimethyl, methylhydrogen 68037-59-2 15 ?40 %
siloxane
N/A N/A N/A
N-Octyltriethoxysilane 2943-75-1 15 ?40 %
N/A N/A N/A
Polyethylene oxide lauryl 9002-92-0 1?%
ether
1000ppm 1000ppm
Ethyl alcohol (by product Generated on
when exposed to moisture ) exposure to
moisture.
California Proposition 65 ingredients
Acetaldehyde 75-07-0 <0.1
Section 313 Supplier Notification
This product contains the following toxic chemicals subject to the reporting requirements of section 313 of
the Emergency Planning and Community Right to Know Act of 1986 (40CFR372)
None
III. Hazards Identification
HMIS Hazard Rating No. 2
PRIMARY ROUTE OF ENTRY: Eye and skin contact, breathing and ingestion.
Symptoms of Exposure
Skin Contact: Prolonged contact may cause moderate skin irritation.
Eyes: Product may cause moderate irritation.
Inhalation May irritate nose and throat. Vapor exposure may cause drowsiness.
LymTal International, Inc. Iso-Flex 628 Page 1 of 4
Ingestion: Not expected to be a relevant route of exposure although it may cause gastrointestinal
irritation, nausea, vomiting, diarrhea, headache and drowsiness.
IV. First Aid Measures
Inhalation Remove victim from exposure. If difficulty with breathing, administer oxygen and
seek medical assistance
Eyes Flush eyes with cold water for a minimum of 15 minutes, lifting lower and upper eye
lids throughout. Seek immediate medical attention.
Skin Immediately remove contaminated clothing. Wash thoroughly with soap and water. If
irritation persists seek medical attention. Wash contaminated clothing before reuse.
Ingestion Do not induce vomiting, get immediate medical attention, if vomiting occurs
spontaneously keep head below hips to prevent aspiration of liquids into lungs. Do
not give anything by mouth to an unconscious person
V. Fire Fighting Methods
HMIS Hazard Rating No. 1
Flash Point: > 100 oC ( 212 oF ) Method: T C.C.
General Hazard: Decomposition and combustion products may be toxic.
Auto-Ignition Temp.: 310 oC ( silane )
Limits of Flammability LEL: Not Available UEL: Not Available
Extinguishing Media For small fires, use water spray, foam, CO2, or dry chemical. For large
fires, use water spray, fog, or foam.
Special Fire & Unusual Hazards Move containers from area if it can be done without risk. Cool fire-
exposed containers with water from the side. As in any fire, wear
NIOSH/MSHA approved, pressure demand self contained breathing
apparatus and full protective gear.
VI. Accidental Release Measures
Action To Take For Spills/ Leaks: Avoid contact with skin or eyes. Ventilate the area, and eliminate all
sources of ignition. Wear appropriate protective gear, contain leak or spill, salvage, and clean up residue
with absorbent material.
Waste Disposal Method: Handle disposal of waste material in a manner that complies with local, state,
province and federal regulation. Landfill if solidified, or incineration at agency approved waste-disposal
facilities.
VII. Handling And Storage
Average Shelf Life: Refer to Product Data Sheet
Special Instructions Product generates ethyl alcohol on exposure to
water / air. Provide ventilation during use. Avoid
breathing vapor, mist or fumes. Product evolves
minute quantities of hydrogen gas which can
accumulate, ensure adequate ventilation to maintain
vapors below flammability limits. Do not repackage,
as pressure build up will occur, do not store in glass
as the pressure will cause the container to shatter.
Store away from water or moisture.
Avoid eye and skin contact.
See exposure limits in hazardous materials section
II.
LymTal International, Inc. Iso-Flex 628 Page 2 of 4
VIII. Exposure Controls / Personal Protection
Ventilation: Ventilation is recommended. Air movement must be designed to insure turnover at all
locations in work area to avoid build up of heavy vapors.
Personal Protection Equipment: Do NOT wear contact lenses when working with this material. Use
chemical goggles/safety glasses with side shields and impervious gloves. Wear clothing with long sleeves
and pants. In operations where mists can be generated or the exposure limits for crystalline silica
exceeded, wear a NIOSH/MSHA approved dust/fume respirator selected by a technically qualified person
for the specific work conditions. Wear respirator protection whenever airborne concentrations exceed TLV
ceilings or TWA, use NIOSH approved respirators for listed hazard.
Confined spaces, room, or tanks are areas where concern for TLV's is especially important. Reference
OSHA regulation CFR 29 1910.134 for recommended respiratory protection.
IX. Physical And Chemical Properties
Boiling Point (oC): >35 Water/Oil Distribution N/A
Coefficient:
Percent Volatile: N/A Solubility in Water: Soluble
Freezing Point (oC): N/A Specific Gravity @20?C 1.0
Vapor Pressure @ 20o C N/A pH: N/A
Vapor Density N/A Evaporation Rate: N/A
Odor Threshold: N/A Odor: Slight
Appearance: milky liquid
N/A = Not Available N/D=NOT Determined Ca. = Approximate
X. Stability And Reactivity
HMIS Hazard Rating No. 1
Stability Stable
Incompatibility: Strong acids and bases, oxidizing and reducing agents and many
metals or metallic compounds will liberate flammable hydrogen gas.
Hazardous Decomposition Products Oxides of Carbon; Decomposition and Combustion products may be
toxic.
Conditions To Avoid Avoid source of ignition and contamination.
XI. Toxicity Information
HMIS Hazard Rating No. 2
PRIMARY ROUTE OF ENTRY: Inhalation, dermal, skin and eyes.
Effects Of Overexposure
Inhalation: May cause lung damage at prolonged or repeated inhalation or at higher
concentrations.
Eyes: Contact can cause moderate irritation.
Skin Contact: May cause moderate skin irritation.
Ingestion: May cause permanent damage to the mouth throat and stomach.
Chronic: Prolonged exposure to ethanol has caused human birth defects.
This product does not contain chemicals considered to be carcinogenic by
NTP, IRAC, ACGIH, OSHA.
LymTal International, Inc. Iso-Flex 628 Page 3 of 4
XII. Ecological Information
Marine Pollutant: NL
(NL = Not Listed; P = Moderate; PP = Severe; ND = Not Determined)
XIII. Disposal Considerations
Handle disposal of waste material in manner which complies with all applicable local, state, provincial and
federal regulations.
XIV. Transport Information
DOT SHIPPING INFORMATON
DOT Proper Shipping Name NOT REGULATED
IATA Bill of Lading - Air NOT REGULATED (Vented packages forbidden for air transport.
XV. Regulatory Information
OSHA Hazard Communication Standard See section II
(29 CFR 1910.1200)
CERCLA/ Super fund (40 CFR 117,302) N/A
SARA Extremely Hazardous Substances N/A
(40 CFR 355)
SARA Hazard Categories (40 CFR 370) N/A
SARA Toxic Chemicals (40 CFR 372) None
Inventory Status The chemicals in this product are listed on the US
TSCA Chemical Substance Inventory and the
Canadian Domestic Substances List.
XVI. Other Information
THE INFORMATION HEREIN HAS BEEN COMPLIED FROM SOURCES BELIEVED TO BE RELIABLE
AND IS ACCURATE TO THE BEST OF OUR KNOWLEDGE. HOWEVER, LymTal INTERNATIONAL INC.
CANNOT GIVE ANY GUARANTEES REGARDING INFORMATION FROM OTHER SOURCES, AND
EXPRESSLY DOES NOT MAKE ANY WARRANTIES, NOR ASSUMES ANY LIABILITY, FOR ITS USE.
LymTal International, Inc. Iso-Flex 628 Page 4 of 4
|