Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 81668 STRIPPED THREAD REPAIR PART 1
Item No: 390220D
Product Type: Adhesive
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH TLV: TWA OSHA PEL:
ETHOXYLATED BISPHENOL A 50-70 Not listed Not Listed
DIMETHACRYLATE
24448-20-2
10 mg/m3 TWA (metal dust) 15 mg/m3 TWA (total dust), 5
ALUMINIUM POWDER 20-40
7429-90-5 mg/m3 TWA (respirable)
ACGIH
10 ppm TWA; 30 mg/m3 TWA
ACRYLIC ACID <5 2 ppm TWA
79-10-7
TETRAHYDROFURFURYL <5 Not listed Not Listed
METHACRYLATE
2455-24-5
10 mg/m3 TWA 6 mg/m3 TWA
SILICON DIOXIDE, AMORPHOUS <5
112945-52-5
3. HAZARDS IDENTIFICATION
May cause eye, skin and respiratory irritation. May cause skin sensitization. Note: This product does not
Toxicity:
contain microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. May cause redness to eyes and irritation to
Signs and Symptoms of Exposure:
nasal passages.
Component Weight% NTP ACGIH Carcinogens IARC
ACRYLIC ACID <5 A4 - Not Classifiable Group 3 Monograph 71,
79-10-7 as a Human 1999; Supplement 7, 1987;
Carcinogen Monograph 19, 1979
SILICON DIOXIDE, AMORPHOUS <5 Amorphous Silica, Group 3:
112945-52-5 Vol. 68: 1997
Acrylic acid: Upper respiratory and lung diseases, dermatitis.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Oxygen or artificial respiration if needed.
Inhalation:
Obtain medical attention.
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
>200癋 TCC
Flash Point (癋/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Irritating vapors, Oxides of nitrogen, Oxides of carbon
Hazardous Products of Combustion:
If ignited, burns with unusual evolution. In a fire, reaction with water is
Unusual Fire/Explosion Hazards:
possible.
2.0% Acrylic acid; 30.0 Aluminum metal
Lower Explosive Limit:
1 of 3
Product Name: 81668 STRIPPED THREAD REPAIR Item No: 390220D
PART 1
5. FIRE FIGHTING MEASURES
8.0% Acrylic acid
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store below 100 degrees F.
Storage:
Do not inhale vapors. Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses
Eyes:
Rubber or plastic gloves.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Gray liquid
Appearance:
MILD
Odor:
>300?F
Boiling Point:
Does not apply
pH:
Slight
Solubility in Water:
1.39
Specific Gravity:
<10% by weight
VOC Content(Wt.%):
Not determined
Vapor Pressure:
>1
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR.
Hazardous Polymerization:
Strong oxidizers, free radical initiators, inert gases
Incompatabilities:
Heat.
Conditions to Avoid:
Irritating vapors, Oxides of nitrogen, Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
Unrestricted
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
2 of 3
Product Name: 81668 STRIPPED THREAD REPAIR Item No: 390220D
PART 1
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
ALUMINUM, ACRYLIC ACID
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 1.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILILTY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: January/30/2008
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 8
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 81668 STRIPPED THREAD REPAIR PART 2
Item No: 390222D
Product Type: Activator
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH TLV: TWA OSHA PEL:
ETHOXYLATED BISPHENOL A 50-70 Not listed Not Listed
DIMETHACRYLATE
24448-20-2
10 mg/m3 TWA (metal dust) 15 mg/m3 TWA (total dust), 5
ALUMINIUM POWDER 20-40
7429-90-5 mg/m3 TWA (respirable)
ACGIH
10 mg/m3 TWA 6 mg/m3 TWA
SILICON DIOXIDE, AMORPHOUS <5
112945-52-5
TETRAHYDROFURFURYL <5 Not listed Not Listed
METHACRYLATE
2455-24-5
3. HAZARDS IDENTIFICATION
May cause eye, skin and respiratory irritation. May cause skin sensitization. Note: This product does not
Toxicity:
contain microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. May cause redness to eyes and irritation to
Signs and Symptoms of Exposure:
nasal passages.
Component Weight% NTP ACGIH Carcinogens IARC
SILICON DIOXIDE, AMORPHOUS <5 Amorphous Silica, Group 3:
112945-52-5 Vol. 68: 1997
Preexisting pulmonary and dermatological disorders.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
>200癋 TCC
Flash Point (癋/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Irritating vapors, Oxides of nitrogen, Oxides of carbon
Hazardous Products of Combustion:
If ignited, burns with unusual evolution. In a fire, reaction with water is
Unusual Fire/Explosion Hazards:
possible.
30.0 Aluminum metal
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
1 of 3
Product Name: 81668 STRIPPED THREAD REPAIR Item No: 390222D
PART 2
7. HANDLING AND STORAGE
Store below 100 degrees F.
Storage:
Do not inhale vapors. Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses
Eyes:
Rubber or plastic gloves.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Blue-grey liquid
Appearance:
MILD
Odor:
>300癋
Boiling Point:
Does not apply
pH:
Slight
Solubility in Water:
1.37
Specific Gravity:
<2%
VOC Content(Wt.%):
Not determined
Vapor Pressure:
>1
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR.
Hazardous Polymerization:
Strong oxidizers, free radical initiators, inert gases, Oxygen scavengers
Incompatabilities:
Heat.
Conditions to Avoid:
Irritating vapors, Oxides of nitrogen, Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
Unrestricted
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
2 of 3
Product Name: 81668 STRIPPED THREAD REPAIR Item No: 390222D
PART 2
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
ALUMINUM
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 1.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILILTY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: January/30/2008
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 7
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 81668 FORM-A-THREAD STRIPPED THREAD REPAIR PART 3
Item No: 390505D
Product Type: Release agent
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH TLV: TWA OSHA PEL:
WATER >75 Not listed Not Listed
7732-18-5
POLYDIMETHYLSILOXANE 1-10 Not listed Not Listed
63148-62-9
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. Note: This product does not contain microcyrstalline silica.
Toxicity:
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Overexposure may cause eye and skin redness.
Signs and Symptoms of Exposure:
None known.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
None reasonably foreseeable.
Inhalation:
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
None
Flash Point (癋/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Formaldehyde, Irritating vapors
Hazardous Products of Combustion:
None.
Unusual Fire/Explosion Hazards:
Not determined.
Lower Explosive Limit:
Not determined.
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store below 100 degrees F. Do not allow freezing.
Storage:
Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses
Eyes:
Rubber or plastic gloves.
Skin:
Provide adequate ventilation .
Ventilation:
Not required under normal use.
Respiratory Protection:
1 of 3
Product Name: 81668 FORM-A-THREAD STRIPPED Item No: 390505D
THREAD REPAIR PART 3
9. PHYSICAL AND CHEMICAL PROPERTIES
Blue liquid
Appearance:
NONE
Odor:
212癋
Boiling Point:
9-11
pH:
SOLUBLE
Solubility in Water:
1.0
Specific Gravity:
None
VOC Content(Wt.%):
Not determined
Vapor Pressure:
<1
Vapor Density (Air=1):
Slower than ether
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR.
Hazardous Polymerization:
None known
Incompatabilities:
Heat.
Conditions to Avoid:
Formaldehyde, Irritating vapors
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
Unrestricted
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
NONE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 1, FLAMMABILITY 0 , REACTIVITY 0.
Estimated NFPA Rating:
HEALTH 1, FLAMMABILITY 0, PHYSICAL HAZARD 0
Estimated HMIS Classification:
2 of 3
Product Name: 81668 FORM-A-THREAD STRIPPED Item No: 390505D
THREAD REPAIR PART 3
16. OTHER INFORMATION
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: January/30/2008
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 5
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|