Read/Right Products
Read/Right Material Safety Data Sheet 33 Murray Hill Drive
Nanuet, N.Y. 10954
June, 1997
1233
PRODUCT (TRADE) NAME: Keywipe
PRODUCT IDENTIFICATION NUMBER(S): 1233
CHEMICAL NAME AND SYNONYMS: Ethyl Alcohol Solution
CHEMICAL FORMULA: CH3CH2CH2(OH)
EMERGENCY TELEPHONE NUMBERS: Read/Right: 1-800--327-1237
CHEMTREC (Transportation): (800) 424-9300
SECTION 2: COMPOSITION AND INFORMATION ON INGREDIENTS
COMPONENT ___CAS#____ __%__ OSHA PEL(ppm) ACGIH TLV (ppm)
Ethyl Alcohol (Ethanol SDA-40B) 64-17-5 40.0 1000 1000
Deionized Water 7732-18-5 58.6 NA NA
Benzethonium Chloride (USP) 8001-54-5 0.5 NA NA
Methyl Paraben 99-76-3 0.1 NA NA
Imidazolindyl Urea 39236-46-9 0.3 NA NA
Nonylphenol Polyglycol Ether 9016-45-9 0.5 NA NA
SECTION 3: HAZARDS IDENTIFICATION
Product is a single use, presaturated pad in which all the liquid is absorbed by the
applicator. Product is an eye irritant and can produce skin irritation with repeated exposure.
The product contains ethyl alcohol therefore, exposures over 1000ppm may cause headache,
drowsiness, loss of appetite, an inability to concentrate, nausea and vomiting
Carcinogenicity (OSHA/NTP/IARC/ACGIH): None Listed
Medical Conditions Aggravated by Exposure: None Listed
SECTION 4: FIRST AID INFORMATION
EYE CONTACT: Flush with water for 15 minutes, including under eyelids. Get medical help.
SKIN CONTACT: Flush with water.
INHALATION: Remove to fresh air. Restore and/or support breathing as needed. Give oxygen if
breathing is difficult. Call physician immediately.
INGESTION: In the unlikely event of ingestion of a wiper, first aid measures should focus on
removal of the object and preventing choking. Once removed, keep affected person
at rest. Call physician immediately.
SECTION 5: FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (TCC): 79` oF
FLAMMABLE LIMITS (% BY VOLUME): LEL: NA UEL: NA
AUTOIGNITION TEMPERATURE oF(OC): NA
EXTINGUISHING MEDIA: Fires involving Ethyl Alcohol may be extinguished using carbon dioxide, dry
chemical or alcohol foam. Water may be used to cool fire exposed containers. Fine water mist may be
used to smother fire or disperse vapors.
UNUSUAL FIRE OR EXPLOSION HAZARDS: Liquid may release flammable vapors which can ignite at or above
flash point.
NFPA RATING: HEALTH (0)
FLAMMABILITY (3)
REACTIVITY (0)
Formulation is classified as an OSHA Class IB Flammable Liquid
NA=Not Available
June, 1997
1233
Page 2
SECTION 6: ACCIDENTAL RELEASE MEASURES
Since the liquid is completely absorbed by the applicator material, and the amount of liquid per
container is small, the chance of a spill due to container failure is minimal. Absorb small spills
with paper towels, evaporate flammable alcohol in exhaust hood and dispose of properly. If a large
amount of liquid is released, all sources of ignition should be eliminated. Cleanup personnel need
protection against liquid contact and vapor inhalation.
SECTION 7: HANDLING AND STORAGE
Avoid excessive contact with skin. Do not store at temperatures above 120oF. Store away from heat,
sparks and open flame.
SECTION 8: EXPOSURE CONTROL - PERSONAL PROTECTION
No specific controls are required for personnel working with the presaturated pads and canisters.
When working with large quantities of the liquid, eye and skin protection should be worn. Adequate
ventilation should be used to maintain TLV.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
BOILING POINT (oF(oC)): % VOLATILE BY VOLUME @ 25oC:
205(96.1) >98
VAPOR PRESSURE (mmHg @ 25oC): 55 EVAPORATION RATE(BUTYL ACETATE=1): >1.0
VAPOR DENSITY (AIR=1): >1 FORM: Presaturated Pad
% SOLUBLE IN WATER @ 25OC: 100 ODOR: Alcohol
SPECIFIC GRAVITY (G/CC@25oC) 0.94 APPEARANCE OF LIQUID: Clear
SECTION 10: STABILITY AND REACTIVITY
STABILITY: Stable mixture under normal conditions of use.
HAZARDOUS POLYMERIZATION: Will not occur under normal conditions of use.
INCOMPATIBILITIES/CONDITIONS TO AVOID: Avoid contact with acetyl chloride and all oxidizing
agents. Always avoid excess heat or exposure to open
flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon Monoxide may form from incomplete combustion.
SECTION 11: TOXICOLOGICAL INFORMATION
Not Available
SECTION 12: ECOLOGICAL INFORMATION
Not Available.
SECTION 13: DISPOSAL CONSIDERATIONS
Follow Federal, State and Local regulations.
June, 1997
1233
Page 3
SECTION 14: TRANSPORT INFORMATION
DOT CLASSIFICATION: Not Regulated
Proper Shipping Name:
Hazard Class:
UN Number:
Packing Group:
Hazard Labeling:
IATA/ICAO CLASSIFICATION: Not Regulated
Proper Shipping Name:
Hazard Class:
UN Number:
Packing Group:
Hazard Labeling:
IMDG CLASSIFICATION: Not Regulated
Proper Shipping Name:
Hazard Class:
IMDG Page#:
Packing Group:
Flash Point:
Marine Pollutant:
SECTION 15: REGULATORY INFORMATION
SARA TITLE III REPORTING:
Toxic Chemical(Section 313): Not Listed
Extremely Hazardous Substance Not Listed
(Section 302, 304, 311,312):
Hazard Class: Chronic Health Yes
Acute Health Yes
Fire Hazard Yes
Pressure Hazard No
Reactivity Hazard No
TSCA INVENTORY STATUS: All components in
the formulation are
listed in the TSCA
inventory
SECTION 16: OTHER INFORMATION
The information provided herein is compiled from internal reports and data from professional
publication. It is furnished without warranty of any king, expressed or implied. It is intended
solely to assist in evaluating suitability and proper use of the material and in implementing safety
precautions and procedures. Employers should use this information as a supplement to other
information gathered by them and must make independent determination of suitability and completeness
of information from all sources to assure proper use of these materials. All information used must be
determined by the user to be in accordance with applicable federal, state and local laws and
regulations.
|