OATEY PURPLE PRIMER CLEANER
Latest Revision Date...02/29/00
==================================================================================
Section 1 IDENTITY OF MATERIAL
TRADE NAME OATEY PURPLE PRIMER CLEANER
PRODUCT NUMBERS 30768, 30780, 30783, 30796, 30806
FORMULA CH(3)COC(2)H(5)+CH(2)CH(2)CH(2)CH(2)0+CH(3)CO
SYNONYMS Methyl Ethyl Ketone, Tetrahydrofuran, Cyclohexanone,
Acetone
==================================================================================
SECTION 2 HAZARDOUS INGREDIENTS
INGREDIENTS % CAS NUMBER SEC 313
Tetrahydrofuran (See 1-5% 109-99-9 No
SECTION-6)
Methyl Ethyl Ketone 13-17% 78-93-3 Yes
Cyclohexanone 5-10% 108-94-1 No
Acetone 70-80% 67-64-1 No
Violet Dye <1% 81-48-1 No
Red Dye <1% 4477-79-6 No
==================================================================================
SECTION 3 KNOWN HAZARDS UNDER 29 CFR 1910.1200
HAZARDS YES NO HAZARDS YES NO
Combustible Liquid X Skin Hazard X
Flammable Liquid X Eye Hazard X
Pyrophoric Material X Toxic Agent X
Explosive Material X Highly Toxic Agent x
Unstable Material X Sensitizer x
Water Reactive X Kidney Toxin X
Material
Oxidizer X Reproductive Toxin X
Organic Peroxide X Blood Toxin x
Corrosive Material X Nervous System Toxin X
Compressed Gas X Lung Toxin X
Irritant X Liver Toxin X
Carcinogen X
NTP/IARC/OSHA (see
SECTION 6)
==================================================================================
SECTION 4 REGULATION
CHEMICAL TLV (TWA) PEL STEL Hazard
Action
Level
Cyclohexanone 25 ppm 50 ppm N/A N/A
100 mg/cu m 200 mg/cu m
(skin)
Tetrahydrofuran 200 ppm 200 ppm 250 ppm N/A
590 mg/cu m 590 mg/cu m 735 mg/cu m
Methyl Ethyl 200 ppm 200 ppm 300 ppm N/A
Ketone
590 mg/cu m 590 mg/cu m 885 mg/cum
Acetone 500 ppm 1000 ppm 750 ppm N/A
1200 mg/cu m 2400 mg/cu m 1800 mg/cu m
==================================================================================
SECTION 5 REGULATED IDENTIFICATION
DOT PROPER SHIPPING CONSUMER COMMODITY ORM-D; For Gallons: Flammable
NAME Liquid, N.O.S., 3, UN 1993, PG II
DOT HAZARD CLASS Class 3 Flammable Liquid
SHIPPING ID NUMBER UN 1993 (Gallons Only)
EPA HAZARDOUS WASTE ID F-003 & F-005
NUMBER
EPA HAZARD WASTE CLASS Ignitable Waste/Toxic Waste
==================================================================================
SECTION 6 EFFECTS OF EXPOSURE
ENTRY ROUTE INHALE - YES INGEST - YES SKIN - YES EYE - YES
INHALATION May cause irritation of mucous membranes, nose & throat,
headache, dizziness, nausea, numbness of the extremities
and narcosis in high concentrations. Has caused CNS
depression & liver damage in animals, & high
concentrations have caused retardation of fetal
development in rats.
TETRAHYDROFURAN The National Toxicology Program has reported that
WARNING exposure of mice and rats to Tetrahydrofuran (THF) vapor
levels up to 1800 ppm 6 hr/day, 5 days/week for their
lifetime caused an increased incidence of kidney tumors
in male rats and liver tumors in female mice. The
significance of these findings for human health are
unclear at this time, and may be related to "species
specific" effects. Elevated incidences of tumors in
humans have not been reported for THF. THF is not listed
as a carcinogen by NTP, IARC, or OSHA. One THF vendor has
recommended a reduction in the "acceptable exposure
limit" from 200 ppm to 25 ppm, 8 and 12 hour time
weighted average.
TARGET ORGANS Eye, Skin, Kidney, Lung, Liver, Central Nervous System
SKIN Chronic contact may lead to irritation & dermatitis.
Chronic exposure to vapors of high concentration may
cause dermatitis. May possibly be absorbed through the
skin.
EYE Vapors or direct contact may cause irritation.
INGESTION May be aspirated into the lungs or cause systemic effects
described under inhalation.
==================================================================================
SECTION 7 EMERGENCY AND FIRST AID PROCEDURES - 303/623-5716 COLLECT
SKIN If irritation arises, wash thoroughly with soap and water. Seek
medical attention if irritation persists.
EYES If fumes cause irritation, move to fresh air and irrigate eyes
with water for 15 minutes. If irritation persists, seek medical
attention.
INHALATION Move to fresh air. If breathing is difficult, give oxygen. If
not breathing, give artificial respiration. Keep victim quiet
and warm. Call a poison control center or physician
immediately.
INGESTION Drink water and call a poison control center or physician
immediately. Avoid alcoholic beverages. Never give anything by
mouth to an unconscious person.
==================================================================================
SECTION 8 PHYSICAL AND CHEMICAL PROPERTIES
NFPA HAZARD HEALTH 2 STABILITY 1 FLAMMABILITY 3 SPECIAL NONE
SIGNAL
BOILING POINT 133 Degrees F / 56 C
MELTING POINT N/A
VAPOR PRESSURE 70 mmHg @ 20 Degrees C
VAPOR DENSITY 2.0
(AIR = 1)
VOLATILE 100%
COMPONENTS
SOLUBILITY IN 28 parts
WATER
PH N/A
SPECIFIC 0.79
GRAVITY
EVAPORATION (BUAC = 1) = 6.0 - 8.0
RATE
APPEARANCE Purple Liquid
ODOR Sharp, either odor
WILL DISSOLVE Water, organic solvents
IN
MATERIAL IS Liquid
==================================================================================
SECTION 9 FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY LEL =2.0 % Volume UEL= 13.0 % Volume
FLASHPOINT AND 0-5 Degrees F. / PMCC
METHOD USED
STABILITY Stable CONDITIONS TO AVOID: Heat, sparks and open
flame. HAZARDOUS DECOMP. PDTS: Carbon monoxide/ carbon
dioxide/hydrogen chloride/smoke.
HAZARDOUS Will Not Occur. CONDITIONS TO AVOID: None
POLYMERIZATION
INCOMPATIBILITY/ Acids, oxidizing materials, alkalis, chlorinated
MAT. TO AVOID inorganics (potassium, calcium and sodium
hypochlorite), copper or copper alloys.
SPECIAL FIRE FOR SMALL FIRES: Use dry chemical, CO2, water or foam
FIGHTING PROCEDURE extinguisher.
FOR LARGE FIRES: Evacuate area and call Fire Department
immediately.
==================================================================================
SECTION 10 SPILL AND DISPOSAL INFORMATION
SPILL OR LEAK Ventilate area, stop leak if it can be done without risk.
PROCEDURES Take up with sand, earth, or other non-combustible absorbing
material.
WASTE DISPOSAL Dispose of according to local, state, and Federal
regulations.
==================================================================================
SECTION 11 SAFE USAGE DATA
PROTECTIVE EYES: Safety glasses with side shields. RESPIRATORY:
EQUIPMENT TYPES NIOSH-approved canister respirator in absence of adequate
ventilation. GLOVES: Rubber gloves. OTHER: Eye wash and
safety shower should be available.
VENTILATION LOCAL EXHAUST: Open doors & windows. Exhaust ventilation
capable of maintaining emissions at the point of use below
PEL. If used in enclosed area, use exhaust fans. Exhaust
fans should be explosion-proof or set up in a way that
explosive concentrations of solvent vapors are not exposed
to electrical fixtures or hot surfaces.
PRECAUTIONS HANDLING & STORAGE: Keep away from heat, sparks and flames;
store in cool, dry place. OTHER: Containers, even empties
will retain residue and vapors.
==================================================================================
SECTION 12 MANUFACTURER OR SUPPLIER DATA
FIRM NAME & MAILING OATEY CO., 4700 West 160th Street, P.O. Box 35906
ADDRESS Cleveland, Ohio 44135
OATEY PHONE NUMBER (216) 267-7100
EMERGENCY PHONE For Emergency First Aid call (303) 623-5716 COLLECT For
NUMBER chemical transportation emergencies ONLY, call Chemtrec
at 1-800-424-9300
==================================================================================
SECTION 13 DISCLAIMER
The information herein has been compiled from sources believed to be
reliable, up-to-date, and is accurate to the best of our knowledge.
However, Oatey cannot give any guarantees regarding information from other
sources, and expressly does not make warranties, nor assumes any liability
for its use.
|