astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET-GRAM STAIN SET (6060)
1 OF 8
Section I: IDENTIFICATION
Date Prepared: 04/16/03
Product Name: Gram Stain Crystal Violet Item Number: 6081, 6060, 6400, 6251
Emergency Phone: 800-424-9300
Section II: HAZARDOUS INGREDIENTS
Hazardous Component(s): CAS# OHSA PEL, ACGIH TLV/STEL(PPM) NFPA
Phenol < 1% 108-95-2 5/250 Health 1
Methanol < 1% 67-56-1 200/250 Flammability 1
Ethanol ~11% 64-17-5 1000 1000/NR Reactivity 0
Section III: PHYSICAL DATA
Boiling Point: ~200掳F Specific Gravity (H2O = 1): ~1
Vapor Pressure mm Hg/20掳C: 79 Percent Volatile by Vol: 10%
Vapor Density (Air 1:1): >1 Evaporation Rate (ether = 1): >1
Solubility in H2O: Complete Appearance & Odor: Purple liquid, phenolic odor
Section IV: FIRE/EXPLOSION HAZARD
Flash Point: 62潞F Flammable Limits: LEL, NA UEL, NA
Extinguishing Media: Water spray, dry chemical, CO2 and foam for alcohol
Special Fire Fighting Procedures: Wear protective clothing with NIOSH approved breathing apparatus.
Products of combustion may be harmful in a fire situation. Do not use direct water stream.
Unusual Fire & Explosion Hazards: Eliminate potential sources of ignition.
Section V: REACTIVITY
Stability: Stable Material to Avoid: Strong oxidizers, chromic anhydride, perchloric acids etc.
Hazardous Decomposition or Byproducts: Oxides of carbon
Hazardous Polymerization: Does not occur Conditions to Avoid: Excessive heat
Section VI: HEALTH HAZARDS
Routes of Entry: Inhalation, Skin and Ingestion
Acute: Vapors may cause eyes, skin and respiratory irritation, drowsiness, nausea, headache and vomiting.
Chronic: May cause liver, heart and kidney damage. May cause gastrointestinal disturbances and convulsions.
Carcinogenicity: Not classified as a human carcinogen.
Signs/Symptoms of Exposure: Vision blurring, drowsiness and headache.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
Gram Stain CV 2 OF 8
Section VI: HEALTH HAZARDS
Emergency First Aid:
Skin: Remove contaminated clothing. Wash affected area with soap and water.
Eyes: Thoroughly flush eyes with water. Contact a physician if irritation persist.
Ingestion: Rinse mouth thoroughly with water, provided person is conscious and contact a physician.
Inhalation: Remove person to fresh air. If not breathing, give artificial respiration and contact physician.
Section VII: SAFE HANDLING
Chemical Release or Spill: Eliminate source of ignition in the vicinity of the spill or released vapor. Isolate the
spill area with sand, or other absorbent material. Place all contaminated material in closed container for
disposal.
Waste Disposal Method: All liquid and or contaminated material should be disposed of in DOT approved waste
containers. Incineration for liquids is the suggested method of disposal. Comply with all Federal, State and
Local regulations for disposal.
Precautions for Handling and Storing: Use precautions for combustible liquids. Avoid excessive heat and
sources of ignition. Use in ventilated area.
Section VIII: CONTROL MEASURES
Respiratory Protection: Not normally required. If used in a poorly ventilated area use under an approved fume
hood or NIOSH approved respirator.
Ventilation: Mechanical exhaust is sufficient.
Protective Gloves: Chemical resistant Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Normal laboratory apparel suggested by Good Laboratory Practices
Work/Hygienic Practices: Wash thoroughly with soap and water after handling.
The above information is believed to be correct but does not purport to be all- inclusive and shall be used only as
a guide. Astraldiagnostics shall not be held liable for any damage resulting from handling or contact with this
product.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
3 OF 8
Section I: IDENTIFICATION
Date Prepared: 04/16/03
Product Name: Gram Stain, Iodine Item Number: SP770-25, 6060, 6253, 6552,
6472
Stabilized Emergency Phone: 800-424-9300
Section II: INGREDIENTS
Component(s): CAS# OHSA PEL, ACGIH TLV/STEL NFPA
PVP Iodine < 13% 25655-41-8 NE Health 1
Potassium Iodide < 2% 7681-11-0 NE Flammability 0
Reactivity 0
Section III: PHYSICAL DATA
Boiling Point: 212掳F Specific Gravity (H2O = 1): ~1
Vapor Pressure mm Hg/20掳C: 40 Percent Volatile by Vol: 5%
Vapor Density (Air 1:1): 1 Evaporation Rate (ether = 1): >1
Solubility in H2O: Complete Appearance & Odor: Reddish-brown liquid, iodine odor
Section IV: FIRE/EXPLOSION HAZARD
Flash Point: NA Flammable Limits: LEL, NA UEL, NA
Extinguishing Media: Water spray, dry chemical, CO2 and foam
Special Fire Fighting Procedures: Wear protective clothing with NIOSH approved breathing apparatus.
Products of combustion may be harmful in a fire situation. Do not use direct water stream.
Unusual Fire & Explosion Hazards: None Known.
Section V: REACTIVITY
Stability: Stable Material to Avoid: Strong oxidizers, chromic anhydride, perchloric acids.
Hazardous Decomposition or Byproducts: Oxides of carbon
Hazardous Polymerization: Does not occur Conditions to Avoid: Excessive heat
Section VI: HEALTH HAZARDS
Routes of Entry: Inhalation, Skin and Ingestion
Acute: Vapors may cause eyes, skin and respiratory irritation.
Chronic: Poisoning may may cause gastrointestinal disturbances, convulsions, circulatory problems and
damage kidneys .
Carcinogenicity: Not classified as a human carcinogen.
Signs/Symptoms of Exposure: Skin and respiratory irritation.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
Gram Stain SI 4 OF 8
Section VI: HEALTH HAZARDS
Emergency First Aid:
Skin: Remove contaminated clothing. Wash affected area with soap and water.
Eyes: Thoroughly flush eyes with water. Contact a physician if irritation persist.
Ingestion: Rinse mouth thoroughly with water, provided person is conscious and contact a physician.
Inhalation: Remove person to fresh air. If not breathing, give artificial respiration and contact physician.
Section VII: SAFE HANDLING
Chemical Release or Spill: Isolate the spill area with sand, or other absorbent material. Place all contaminated
material in a closed container for disposal.
Waste Disposal Method: All liquid and or contaminated material should be disposed of in DOT approved waste
containers. Incineration for liquids is the suggested method of disposal. Comply with all Federal, State and
Local regulations for disposal.
Precautions for Handling and Storing: Use normal precautions for liquids. Avoid excessive heat. Use in
ventilated area.
Section VIII: CONTROL MEASURES
Respiratory Protection: Not normally required. If used in a poorly ventilated area use under fume hood or
NIOSH approved respirator.
Ventilation: In ventilated areas, mechanical exhaust is sufficient.
Protective Gloves: Chemical resistant Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Normal laboratory apparel suggested by Good Laboratory Practices
Work/Hygienic Practices: Wash thoroughly with soap and water after handling.
The above information is believed to be correct but does not purport to be all- inclusive and shall be used only as
a guide. Astraldiagnostics shall not be held liable for any damage resulting from handling or contact with this
product.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
5 OF 8
Section I: IDENTIFICATION
Date Prepared: 04/16/03
Product Name: Gram Stain, Decolorizer Item Number(s): 6084, 6060, 6400, 6254
Emergency Phone: 800-424-9300
Section II: COMPOSITION
Component(s): CAS Number OHSA PEL, ACGIH TLV/STEL(ppm) NFPA
Acetone < 20% 67-56-1 1000 TWA 500/750 Health 1
Isopropanol < 80% 67-63-0 400 400/500 Flammability 3
Reactivity 0
Section III: PHYSICAL DATA
Boiling Point: 60掳F Specific Gravity (H2O = 1): 0.8
Vapor Pressure mm Hg/20掳C: 40 Percent Volatile by Vol: 91%
Vapor Density (Air 1:1): 1.6 Evaporation Rate (ether = 1): >1
Solubility in H2O: Complete Appearance & Odor: Clear liquid/sweet odor
Section IV: FIRE/EXPLOSION HAZARD
Flash Point: 50掳F TCC Flammable Limits: LEL 2.5 UEL 13
Extinguishing Media: Water spray, Dry chemical, CO2 and foam for alcohol
Special Fire Fighting Procedures: Wear protective clothing with NIOSH approved breathing apparatus.
Products of combustion may be harmful in a fire situation. Do not use direct water stream.
Unusual Fire & Explosion Hazards: Eliminate sources of ignition. Burns with invisible flame.
Section V: REACTIVITY
Stability: Stable Material to Avoid: Strong oxidizers
Hazardous Decomposition or Byproducts: Oxides of carbon
Hazardous Polymerization: Does not occur Conditions to Avoid: Excessive heat, sparks or flames
Section VI: HEALTH HAZARDS
Routes of Entry: Inhalation, Skin and Ingestion Target Organs: Kidneys, nervous system, liver and eyes
Acute: Vapors may cause eyes, skin and respiratory irritation, drowsiness, nausea, headache and vomiting.
Chronic: May cause liver, heart and kidney damage. May cause gastrointestinal disturbances and convulsions.
Carcinogenicity: Not classified as a human carcinogen.
Signs/Symptoms of Exposure: Vision blurring, drowsiness and headache.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
Gram Stain D 6 OF 8
Section VI: HEALTH HAZARDS
Emergency First Aid:
Skin: Remove contaminated clothing. Wash affected area with soap and water.
Eyes: Thoroughly flush eyes with water. Contact a physician if irritation persist.
Ingestion: Rinse mouth thoroughly with water, provided person is conscious and contact a physician.
Inhalation: Remove person to fresh air. If not breathing, give artificial respiration and contact physician.
Section VII: SAFE HANDLING
Chemical Release or Spill: Eliminate source of ignition in the vicinity of the spill or released vapor. Isolate the
spill area with sand, or other absorbent material. Place all contaminated material in closed container for
disposal.
Waste Disposal Method: All liquid and or contaminated material should be disposed of in DOT approved waste
containers. Incineration for liquids is the suggested method of disposal. Comply with all Federal, State and
Local regulations for disposal.
Precautions for Handling and Storing: Use precautions for flammable liquids. Avoid excessive heat and
sources of ignition. For large quantities, store in flammable safety cabinet. Use in well- ventilated area.
Section VIII: CONTROL MEASURES
Respiratory Protection: Not normally required. If used in a poorly ventilated area use under an approved fume
hood or NIOSH approved respirator.
Ventilation: Special flammable exhaust hood if vapor concentration is high. In well- ventilated areas,
mechanical exhaust is sufficient.
Protective Gloves: Chemical resistant Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Normal laboratory apparel suggested by Good Laboratory Practices
Work/Hygienic Practices: Wash thoroughly with soap and water after handling.
The above information is believed to be correct but does not purport to be all- inclusive and shall be used only as
a guide. Astral Diagnostics shall not be held liable for any damage resulting from handling or contact with this
product.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
7 OF 8
Section I: IDENTIFICATION
Date Prepared: 04/16/03
Product Name: Gram Stain, Safranin Item Number(s): 6086, 6060, 6400, 6250, 6256
Emergency Phone: 800-424-9300
Section II: COMPOSITION
Component(s): CAS Number OHSA PEL, ACGIH TLV/STEL NFPA
Methanol < 1% 67-56-1 200 200/250 Health 1
Ethanol <19% 64-17-5 1000 1000/NR Flammability 3
Safranin < 1% 477-73-6 NR Reactivit y 0
Section III: PHYSICAL DATA
Boiling Point: ~198掳F Specific Gravity (H2O = 1): <1
Vapor Pressure mm Hg/20掳C: 40 Percent Volatile by Vol: 91%
Vapor Density (Air 1:1): 1.6 Evaporation Rate (ether = 1): >1
Solubility in H2O: Complete Appearance & Odor: Red/purple liquid/alcohol odor
Section IV: FIRE/EXPLOSION HAZARD
Flash Point: 55掳F TCC Flammable Limits: LEL 3.5 UEL 19
Extinguishing Media: Water spray, dry chemical, CO2 and foam for alcohol
Special Fire Fighting Procedures: Wear protective clothing with NIOSH approved breathing apparatus.
Products of combustion may be harmful in a fire situation. Do not use direct water stream.
Unusual Fire & Explosion Hazards: Eliminate sources of ignition. Burns with invisible flame.
Section V: REACTIVITY
Stability: Stable Material to Avoid: Strong oxidizers and organic acids
Hazardous Decomposition or Byproducts: Oxides of carbon and nitrogen
Hazardous Polymerization: Does not occur Conditions to Avoid: Excessive heat, sparks or flames
Section VI: HEALTH HAZARDS
Routes of Entry: Inhalation, Skin and Ingestion Target Organs: Kidneys, nervous system, liver and eyes
Acute: Vapors may cause eyes, skin and respiratory irritation, drowsiness, nausea, headache and vomiting.
Chronic: May cause liver, heart and kidney damage. May cause gastrointestinal disturbances and convulsions.
Carcinogenicity: Not classified as a human carcinogen.
Signs/Symptoms of Exposure: Vision blurring, drowsiness and headache.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
astraldiagnostics
incorporated
MATERIAL SAFETY DATA SHEET
Gram Stain S 8 OF 8
Section VI: HEALTH HAZARDS
Emergency First Aid:
Skin: Remove contaminated clothing. Wash affected area with soap and water.
Eyes: Thoroughly flush eyes with water. Contact a physician if irritation persist.
Ingestion: Rinse mouth thoroughly with water, provided person is conscious and contact a physician.
Inhalation: Remove person to fresh air. If not breathing, give artificial respiration and contact physician.
Section VII: SAFE HANDLING
Chemical Release or Spill: Eliminate source of ignition in the vicinity of the spill or released vapor. Isolate the
spill area with sand, or other absorbent material. Place all contaminated material in closed container for
disposal.
Waste Disposal Method: All liquid and or contaminated material should be disposed of in DOT approved waste
containers. Incineration for liquids is the suggested method of disposal. Comply with all Federal, State and
Local regulations for disposal.
Precautions for Handling and Storing: Use precautions for flammable liquids. Avoid excessive heat and
sources of ignition. For large quantities, store in flammable safety cabinet. Use in well- ventilated area.
Section VIII: CONTROL MEASURES
Respiratory Protection: Not normally required. If used in a poorly ventilated area use under an approved fume
hood or NIOSH approved respirator.
Ventilation: Special flammable exhaust hood if vapor concentration is high. In well- ventilated areas,
mechanical exhaust is sufficient.
Protective Gloves: Chemical resistant Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Normal laboratory apparel suggested by Good Laboratory Practices
Work/Hygienic Practices: Wash thoroughly with soap and water after handling.
The above information is believed to be correct but does not purport to be all- inclusive and shall be used only as
a guide. Astral Diagnostics shall not be held liable for any damage resulting from handling or contact with this
product.
Astral Diagnostics, Inc
1224 Forest Parkway, Suite 200, West Deptford, NJ 08066
856-224-0900
|