MATERIAL SAFETY DATA SHEET
BEER CLEAN Last Rinse Sanitizer
HMIS NFPA Personal protective equipment
Health 3 Health 3
Fire Hazard 0 Flammability 0
Reactivity 0 Instability 0
Version Number: 2 Preparation date: 2010-03-18
1. PRODUCT AND COMPANY IDENTIFICATION
Product name: BEER CLEAN Last Rinse Sanitizer
MSDS #: MS0100446
Product Code: 90223, 90203
Recommended use: Industrial/Institutional. Sanitizer.
Manufacturer, importer, supplier:
US Headquarters
JohnsonDiversey, Inc.
8310 16th St.
Sturtevant, Wisconsin 53177-1964
Phone: 1-888-352-2249
MSDS Internet Address:
www.johnsondiversey.com
Emergency telephone number: 1-800-851-7145 (U.S.); 1-651-917-6133 (Int'l)
2. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
DANGER. CORROSIVE. CAUSES EYE AND SKIN BURNS. HARMFUL IF SWALLOWED.
Principle routes of exposure: Eye contact. Skin contact. Inhalation.
Eye contact: Corrosive. Causes permanent eye damage, including blindness.
Skin contact: Corrosive. May cause permanent damage.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract.
Ingestion: Corrosive. May cause burns to mouth, throat and stomach .
3. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient(s) CAS # Weight % LD50 Oral - Rat LD50 Dermal - LC50 Inhalation -
(mg/kg) Rabbit Rat
Trichloromelamine 7673-09-8 20 490 Not available Not available
4. FIRST AID MEASURES
Eye contact: Immediately flush eyes with running water for at least 15 minutes, keeping eyelids open. Get medical
attention immediately.
Skin contact: Flush immediately with plenty of water for at least 15 minutes. Get medical attention immediately.
Inhalation: If breathing is affected, remove to fresh air. Get medical attention immediately.
Ingestion: Do not induce vomiting. Immediately drink one cupful of water or milk. Never give anything by mouth
to an unconscious person. Get medical attention immediately.
Notes to physician: Probable mucosal damage may contraindicate the use of gastric lavage.
Aggravated Medical Conditions: Individuals with chronic respiratory disorders such as asthma, chronic bronchitis, emphysema, etc.,
may be more susceptible to irritating effects
5. FIRE-FIGHTING MEASURES
BEER CLEAN Last Rinse Sanitizer 1 of 4
Suitable extinguishing media: Dry chemical, water spray, foam, carbon dioxide.
Specific hazards: Not applicable.
Unusual hazards: Corrosive material (See sections 8 and 10).
Specific methods: No special methods required.
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions: Use personal protective equipment.
Environmental precautions Use appropriate containment to avoid environmental contamination. Sweep up and shovel into
and clean-up methods: suitable containers for disposal. Keep in suitable and closed containers for disposal. Use a water rinse
for final clean-up.
7. HANDLING AND STORAGE
Handling:
Avoid contact with skin, eyes and clothing. Do not taste or swallow. Avoid breathing dust . Use only with adequate ventilation. Remove and wash
contaminated clothing and footwear before re-use. Wash thoroughly after handling. Do not mix with acids or acid detergents . Product residue
may remain on/in empty containers. All precautions for handling the product must be used in handling the empty container and residue. . FOR
COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage:
Keep tightly closed in a dry, cool and well-ventilated place. Store in a cool, dry, well ventilated area away from heat or open flame. Keep out of
the reach of children.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels Respiratory protection is not required if good ventilation is maintained
Personal Protective Equipment
Eye protection: Chemical-splash goggles.
Hand protection: Chemical-resistant gloves. Includes: neoprene gloves.
Skin and body protection: Protective footwear. If major exposure is possible, wear suitable protective clothing and footwear.
Respiratory protection: If aerosols, mists, or vapors are not adequately controlled by ventilation, use appropriate respiratory
protection to avoid over-exposure . A respiratory protection program that meets OSHA's 29 CFR
1910.134 and ANSI Z88.2 requirements must be followed whenever workplace conditions warrant a
respirator's use.
Hygiene measures: Handle in accordance with good industrial hygiene and safety practice.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Powder Bulk density: No information available
Appearance: Powder Evaporation Rate No information available
Specific gravity: 0.81 Vapor density: No information available
Color: Light Yellow Odor: Chlorine
Boiling point/range: Not determined Melting point/range: Not determined
Decomposition temperature: Not determined Autoignition temperature: No information available
Solubility: Completely Soluble Solubility in other solvents: No information available
Density: 6.76 lbs/gal 0.81 Kg/L Flash point: Not applicable
Viscosity: No information available Partition coefficient (n-octanol/water): No information available
Elemental Phosphorus: 12.4 % by wt. VOC: 0 % *
pH: Not applicable
Dilution pH: 6 @ 1536
Explosion limits: - upper: Not determined - lower: Not determined
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
10. STABILITY AND REACTIVITY
BEER CLEAN Last Rinse Sanitizer 2 of 4
Stability: The product is stable
Polymerization: Hazardous polymerization does not occur.
Hazardous decomposition products: None reasonably foreseeable.
Materials to avoid: Acids. Strong oxidising agents.
Conditions to avoid: Keep away from heat.
11. TOXICOLOGICAL INFORMATION
Acute toxicity: Corrosive; Oral LD50 estimated to be between 1000 - 2000 mg/kg ; Dermal LD50 estimated to be >
2000 mg/kg.
Component Information: See Section 3.
Chronic toxicity: None known
Specific effects
Carcinogenic effects: None known
Mutagenic effects: None known
Reproductive toxicity: None known
Target organ effects: None known
12. ECOLOGICAL INFORMATION
Environmental Information: No data available.
13. DISPOSAL CONSIDERATIONS
Do not contaminate water, food, or feed by storage or disposal.
Waste from residues / unused products:
PESTICIDAL WASTE - Observe all applicable Federal/Provincial/State regulations and Local/Municipal ordinances regarding disposal of pesticide
wastes.
Pesticide Storage:
Store in original container in areas inaccessible to children. Open dumping is prohibited. Do not reuse empty container .
Pesticide Disposal:
Pesticide wastes are acutely hazardous. Improper disposal of excess pesticide, spray mixture, or rinsate is a violation of Federal Law.
Container Disposal:
Triple rinse (or equivalent). Then offer for recycling or reconditioning, or puncture and dispose of in a sanitary landfill, or incinerate, or, if
allowed by State and local authorities burn. If burned, stay out of smoke.
14. TRANSPORT INFORMATION
DOT/TDG: Please refer to the Bill of Lading/receiving documents for up to date shipping information .
15. REGULATORY INFORMATION
International Inventories
All components of this product are listed on the following inventories: U.S.A. (TSCA)
U.S. Regulations
EPA Reg. No. : 70627-26
California Proposition 65: This product is not subject to the reporting requirements under California's Proposition 65.
CERCLA/ SARA
SARA 311/312 Hazard Categories
Immediate: X
BEER CLEAN Last Rinse Sanitizer 3 of 4
Delayed: -
Fire: -
Reactivity: -
Sudden Release of Pressure: -
16. OTHER INFORMATION
Reason for revision: Not applicable
Prepared by: NAPRAC
Additional advice: None.
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
BEER CLEAN Last Rinse Sanitizer 4 of 4
|