MATERIAL SAFETY DATA SHEET
DIAMOND SEAL MATCRETE INC.
1495 Hudson Avenue ?Ontario, CA ?91764
HIGH-PERFORMANCE SOLVENT-BASED SEALER
PHONE (800)777-7063 ?FAX (909)635-0165
www.matcrete.com
Read this MSDS before use or disposal of this product. Pass along the information to employees and any persons who could be exposed to the
product to be sure that they are aware of the information before use or other exposure. This MSDS has been prepared according to the OSHA
Hazard Communication Standard (29 CFR 1915, 1916, 1917). This MSDS information is based on sources believed to be reliable. However,
since data, safety standards, and government regulations are subject to change and the conditions of handling and use, or misuse beyond our
control, MATCRETE makes no warranty, either expressed or implied, with respect to the completeness or continuing accuracy of the information
contained herein and disclaims all liability for reliance thereon. Also, additional information may be necessary or helpful for specific conditions
and circumstances of use. It is the user's responsibility to determine the suitability of this product and to evaluate risks prior to use, and then to
exercise appropriate precautions for protection of employees and others.
SECTION I. PRODUCT IDENTIFICATION
DIAMOND SEAL (600 V.O.C.)
PRODUCT NAME:
N/A
CAS NUMBER:
DS-600
MATCRETE MSDS #:
MATCRETE INC. (800)777-7063
GENERAL ASSISTANCE:
CHEMTREC (DOMESTIC) (800)424-9300
EMERGENCY ASSISTANCE:
CHEMTREC (INTERNATIONAL) (703)527-3887
EMERGENCY ASSISTANCE:
SECTION II. HAZARDOUS INGREDIENTS EXPOSURE LIMITS (TWA's IN AIR)
CHEMICAL NAME CAS NUMBER ACGIH TLV OSHA PEL STEL
ETHYL BENZENE 100-41-4 100 ppm 100 ppm 125 ppm
HYDROCARBON SOLVENT 1330-20-7 100 ppm 100 ppm 150 ppm
AMINE SOLVENT 872-50-4 N/E N/E N/P
METHYL-BUTYL METHACRYLATE 28262-63-7 100 ppm (SKIN) 200 ppm N/A
SECTION III. PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: LIQUID
pH: N/A
BOILING POINT/RANGE: 275-390癋 @ 760 mm. Hg
MELTING POINT/RANGE: N/A
SOLUBILITY IN WATER: NEGLIGIBLE
SPECIFIC GRAVITY(WATER=1): 0.92-0.94
VAPOR DENSITY(AIR=1): 3.7
VAPOR PRESSURE(mm. Hg): 185 @ 20癈
% VOLATILES: 71.5-72.4 BY VOLUME
MOLECULAR WEIGHT: N/A
HOW TO DETECT THIS COMPOUND: N/A
APPEARANCE/COLOR/ODOR: LIQUID/CLEAR/HYDROCARBON
VOC: 600 OR LESS GRAMS/LITER (5 LBS./GALLON)
SECTION IV. STABILITY AND REACTIVITY
STABILITY: STABLE
CONDITIONS TO AVOID: HEAT, SPARKS AND OPEN FLAMES
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
MATERIALS TO AVOID: STRONG ALKALIES OR STRONG OXIDIZERS. THIS SEALER MAY DISSOLVE SOME
PLASTICS, RUBBER MATERIALS OR COATING.
HAZARDOUS DECOMPOSITION PRODUCTS: FROM THERMAL DECOMPOSITION, OXIDES OF CARBON AND
ACRYLIC MONOMER VAPORS MAY BE PRODUCED.
DIAMOND SEAL (600 V.O.C.) PAGE 1 of 3
PREPARED: 03/07
SECTION V. FIRE FIGHTING MEASURES
FLASH POINT: 0癋 - TCC
AUTOIGNITION TEMPERATURE: 450?F
LOWER EXPLOSIVE LIMIT: 1% BY VOLUME IN AIR
UPPER EXPLOSIVE LIMIT: 7% BY VOLUME IN AIR
UNUSUAL FIRE AND EXPLOSION HAZARDS: HANDLE AS AN EXTREMELY FLAMMABLE MATERIAL. VAPORS MAY
FORM AN EXPLOSIVE MIXTURE WITH AIR BETWEEN THE UPPER AND LOWER EXPLOSIVE LIMITS.
EXTINGUISHING MEDIA: USE FOAM, CARBON DIOXIDE OR DRY CHEMICAL. USE OF WATER MAY CAUSE FIRE TO
SPREAD DUE TO COMPOUNDS THAT FLOAT ON WATER.
SPECIAL FIREFIGHTING PROCEDURES: WEAR A SELF-CONTAINED BREATHING APPARATUS (PRESSURE-DEMAND,
MSHA/NIOSH-APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
SECTION VI. HEALTH HAZARD INFORMATION
ROUTES OF EXPOSURE: DIAMOND SEAL LACQUER SEALER (600 VOC) CAN AFFECT THE BODY IF IT IS INHALED,
INGESTED, OR COMES IN CONTACT WITH THE EYES AND SKIN.
SUMMARY OF ACUTE HEALTH HAZARDS
INGESTION: MAY CAUSE IRRITATION OF ESOPHAGUS AND STOMACH.
INHALATION: MAY CAUSE IRRITATION OF NOSE AND THROAT.
SKIN: MAY CAUSE A RASH.
EYES: CAN CAUSE IRRITATION OF THE EYE.
SIGNS AND SYMPTOMS OF EXPOSURE: CONTACT WITH SKIN OR EYES MAY CAUSE IRRITATION.
BREATHING OF THE VAPOR MAY IRRITATE THE NOSE AND THROAT.
EFFECTS OF OVEREXPOSURE: MAY CAUSE ANESTHESIA, HEADACHE, NAUSEA, OR DIZZINESS.
MEDICAL CONDITIONS GENERALLY AGGRIVATED BY EXPOSURE: ASTHMA AND OTHER RESPIRATORY CONDITIONS.
EMERGENCY AND FIRST AID PROCEDURES
INGESTION: DO NOT INDUCE VOMITING UNLESS ADVISED TO DO SO BY A PHYSICIAN. GET MEDICAL ATTENTION.
INHALATION: REMOVE VICTIM TO FRESH AIR AND RESTORE BREATHING IF REQUIRED. GET MEDICAL ATTENTION.
SKIN: FLUSH SKIN WITH PLENTY OF WATER. IF RASH DEVELOPS, GET MEDICAL ATTENTION.
EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION,
IF DISCOMFORT PERSISTS.
SECTION VII. PRECAUTIONS FOR SAFE HANDLING AND USE
HANDLING AND STORING PRECAUTIONS: CAUTION! EXTREMELY FLAMMABLE! KEEP AWAY FROM HEAT,
SPARKS AND OPEN FLAME. KEEP CONTAINER CLOSED. USE WITH ADEQUATE VENTILATION.
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: ELIMINATE ALL SOURCES OF IGNITION. PROVIDE
ADEQUATE VENTILATION. FLUSH WITH WATER TO A TANK OR AN OPEN WELL-VENTILATED AREA. ABSORB OR
REMOVE TO A CONTAINER AND DISPOSE OF PROPERLY IN CONFORMANCE WITH LOCAL REGULATIONS.
WASTE DISPOSAL METHODS: DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL, COUNTY, STATE, AND
FEDERAL REGULATIONS.
OTHER PRECAUTIONS: DO NOT ALLOW MATERIAL TO COME IN CONTACT WITH SOIL.
SECTION VIII. CONTROL MEASURES
RESPIRATORY PROTECTION: ALL-PURPOSE CANISTER MASK OR AIR-SUPPLIED MASK IF THE TLV IS EXCEEDED. ONLY
MSHA OR NIOSH APPROVED RESPIRATORS SHOULD BE USED.
VENTILATION: LOCAL IS PREFERABLE, BUT MECHANICAL IS ACCEPTABLE.
PROTECTIVE CLOTHING: PROTECTIVE GLOVES ARE ADVISABLE, AND GOGGLES OR A FACE SHIELD SHOULD BE USED.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: AN EYE BATH AND A SAFETY SHOWER SHOULD BE AVAILABLE.
WORK/HYGIENIC PRACTICES: EMPLOYEES WHO HANDLE DIAMOND SEAL LACQUER SEALER (600 VOC) SHOULD
WASH THEIR HANDS THOROUGHLY BEFORE EATING, SMOKING, OR USING TOILET FACILITIES.
SECTION VIII. CONTROL MEASURES
RESPIRATORY PROTECTION: ALL-PURPOSE CANISTER MASK OR AIR-SUPPLIED MASK IF THE TLV IS EXCEEDED. ONLY
MSHA OR NIOSH APPROVED RESPIRATORS SHOULD BE USED.
VENTILATION: LOCAL IS PREFERABLE, BUT MECHANICAL IS ACCEPTABLE.
PROTECTIVE CLOTHING: PROTECTIVE GLOVES ARE ADVISABLE, AND GOGGLES OR A FACE SHIELD SHOULD BE USED.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: AN EYE BATH AND A SAFETY SHOWER SHOULD BE AVAILABLE.
WORK/HYGIENIC PRACTICES: EMPLOYEES WHO HANDLE DIAMOND SEAL LACQUER SEALER (600 VOC) SHOULD
WASH THEIR HANDS THOROUGHLY BEFORE EATING, SMOKING, OR USING TOILET FACILITIES.
DIAMOND SEAL (600 V.O.C.) PAGE 2 of 3
PREPARED: 03/07
SECTION IX. TRANSPORT INFORMATION
SYNONYMS/COMMON NAMES: LACQUER SEALER
CHEMICAL FAMILY/TYPE : PAINT
DOT PROPER SHIPPING NAME: PAINT
DOT HAZARD CLASS/I.D. #: 3, UN1263, II
SECTION X. REGULATORY INFORMATION
REPORTABLE QUANTITY: N/A
HEALTH - 2; FLAMMABILITY - 3; REACTIVITY - 0
NFPA RATING:
0=INSIGNIFICANT 1=SLIGHT 2=MODERATE 3=HIGH 4=EXTREME
CARCINOGENICITY LISTS: NO
NTP: NO
IARC MONOGRAPH: NO
OSHA REGULATED: NO
WARNING! THIS PRODUCT CONTAINS BENZENE AND TOLUENE, CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
SECTION 313 SUPPLIER NOTIFICATION: THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMCIAL(S)
SUBJECT TO THE REPORTING REQUIREMENTS OF SARA TITLE III SECTION 313 OF THE EMERGENCY PLANNING
AND COMMUNITY RIGHT-TO KNOW ACT OF 1986 AND OF 40 CFR 372:
CHEMICAL NAME CAS NUMBER % BY WEIGHT
MIXED XYLENES 1330-20-7 < 14
ETHYL BENZENE 100-41-4 <2
1-METHYL-2-PYRROLIDONE 872-50-4 <1
DIAMOND SEAL (600 V.O.C.) PAGE 3 of 3
PREPARED: 03/07
|