MATERIAL SAFETY DATA SHEET
.
SECTION I - PRODUCT IDENTIFICATION
space
RFCCU Equilibrium Catalyst
Product Name: LEGEND Health * 2
HMIS/NFPA
FCC Equilibrium Catalyst
Synonym(s):
Severe 4 Flammability 0
FCC Regenerated Catalyst
Serious 3
Catalyst
Product Use: Physical Hazard 0
Moderate 2
Class D - Division 2A, 2B
WHMIS Class: Slight 1 Personal Protection
X
Minimal 0
Not regulated as dangerous goods.
DOT Classification:
Not regulated as dangerous goods.
TDG Classification:
0
Irving Oil Refining G.P.
Manufacturer/Supplier:
2 0
Box 1260
Saint John, NB E2L 4H6 CA
Phone: (506) 202-2000
Refinery: (506) 202-3000
Emergency Phone: 1-800-424-9300 (CHEMTREC)
.
SECTION II - HAZARDOUS INGREDIENTS
space
Ingredient(s) CAS # Wt% OSHA PELS ACGIH-TLV LC50 Oral LD50
Mullite 1302-93-8 30 - 60 Not established Not established Not available Not available
Zeolite 76774-74-8 30 - 60 Not established Not established 0.6 mg/l/4h rat Not available
Lanthanum oxide (La2O3) 1312-81-8 3-7 Not established Not established Not available 8500.0001 mg/kg rat
Titanium oxide 13463-67-7 0.5 - 1.5 15 mg/m3 - TW A 10 mg/m3 - TW A Not available 24000 mg/kg rat
Antimony trioxide 1309-64-4 <1 Not established Not established Not available > 34600 mg/kg rat
Magnesium oxide 1309-48-4 <1 15 mg/m3 - TW A 10 mg/m3 - TW A Not available Not available
Nickel (II) oxide 1313-99-1 <1 Not established Not established Not available 5000.0001 mg/kg rat
Silica-crystalline, quartz 14808-60-7 <1 0.1 mg/m3 - TW A 0.1 mg/m3 - TW A Not available 500 mg/kg rat
Sodium sulfate 7757-82-6 <1 Not established Not established Not available 10000 mg/kg rat;
5989 mg/kg mouse
Vanadium pentoxide 1314-62-1 <1 0.5 mg/m3 - CEIL 0.05 mg/m3 - TW A 2.21 mg/l/4h rat 23 mg/kg mouse; 10
mg/kg rat
Zinc oxide 1314-13-2 <1 5 mg/m3 - TW A 2 mg/m3 - TW A; 10 Not available 7950 mg/kg mouse;
mg/m3 - STEL 5000 mg/kg rat
.
SECTION III - PHYSICAL DATA
space
Not available 0.8 (bulk)
Boiling Point: Specific Gravity:
Not applicable
Not available
Freezing Point: Coefficient of Water/Oil
Distribution:
Not available
Vapor Pressure:
Not applicable
% Volatile:
Not available
Vapor Density:
Not applicable
Evaporation Rate:
Insoluble
Solubility in Water:
4 - 7 @ 20癈
pH:
Solid
Physical State:
Not available
Viscosity:
dark grey Powder
Appearance:
Not available
Odor Threshold:
Mineral-oil-like
Odor:
.
SECTION IV - FIRE AND EXPLOSION DATA
space
Not flammable by WHMIS/OSHA criteria.
Flammability:
space
Not applicable Not applicable Not applicable
Flash Point: LEL: UEL:
space
May include and are not limited to: Oxides of carbon. Nickel carbonyl. Corrosive
Hazardous Combustion Products:
vapours.
space
Not applicable
Autoignition Temperature:
space
Explosion Data:
Sensitivity to Mechanical Impact: Not expected to be sensitive to mechanical impact.
space
Not expected to be sensitive to static discharge.
Sensitivity to Static Discharge:
space
Treat for surrounding material.
Means of Extinction:
space
Firefighters should wear a self-contained breathing apparatus. Some
Special Fire Hazards:
components may burn if heated to very high temperatures.
RFCCU Equilibrium Catalyst (03019)
19421 Page 1 of 3
.
SECTION V - REACTIVITY DATA
space
Conditions for Chemical Instability: Stable under recommended storage conditions.
space
Acids. Caustics. Oxidizers. Chlorinated products. Fluorinated materials. Bromine
Incompatible Materials:
trifluoride. Lithium
space
Do not mix with other chemicals.
Reactivity, and Under What
Conditions:
space
May include and are not limited to: Nickel carbonyl. Orthophosphoric acid. Oxides of
Hazardous Decomposition
carbon.
Products:
.
SECTION VI - TOXICOLOGICAL PROPERTIES
space
Eye, Skin contact, Inhalation, Ingestion.
Route of Entry:
space
EFFECTS OF ACUTE EXPOSURE:
May cause irritation.
Eye:
space
Contact with skin can cause irritation and allergic reaction (sensitization) in some
Skin:
individuals.
space
This product may cause metal fume fever with resulting flu-like symptoms.
Inhalation:
Excessive intentional inhalation may cause respiratory tract irritation and central
nervous system effects (headache, dizziness).
space
May cause stomach distress, nausea or vomiting.
Ingestion:
space
EFFECTS OF CHRONIC EXPOSURE:
Prolonged or repeated exposure can cause drying, defatting and dermatitis.
space
Prolonged or repeated exposure to fine airborne crystalline silica dust may cause severe scarring of the lungs, a disease
called silicosis. Early symptoms of silicosis include cough, mucous production and shortness of breath upon exertion.
space
Prolonged or repeated exposure can cause drying, defatting and dermatitis.
Skin:
space
Skin, eyes, respiratory tract.
Irritancy:
space
Respiratory Tract Sensitization: May cause respiratory and skin sensitization. People with asthma or other lung
problems may be more susceptible.
space
Contains potential carcinogens.
Carcinogenicity:
High concentrations of pigment-grade (powdered) and ultrafine titanium dioxide
(titanium oxide) dust have caused respiratory tract cancer in rats exposed by inhalation
and intratracheal instillation.
space
Non-hazardous by WHMIS/OSHA criteria.
Teratogenicity:
space
Contains potential mutagens.
Mutagenicity:
space
Contains a potential reproductive toxin.
Reproductive Effects:
space
Not available
Synergistic Materials:
.
SECTION VII - PREVENTATIVE MEASURES
space
Rubber gloves. Confirm with a reputable supplier first.
Gloves:
space
Wear safety glasses with side shields.
Eye Protection:
space
In case of brief exposure or low concentration, use an air-filtering cartridge respirator.
Respiratory Protection:
For longer exposures or higher concentrations, use an air-supplied respirator. The
recommended filter device for short term use is a P100 filter.
space
If clothing or footwear becomes contaminated with the product, remove it and
Other Protective Equipment:
completely decontaminate it before re-use, or discard it.
space
Use process enclosures, local exhaust ventilation, or other engineering controls to
Engineering Controls:
control airborne levels below recommended exposure limits. General ventilation
normally adequate.
space
Before attempting clean up, refer to hazard data given above. Use broom or dry
Leak and Spill Procedure:
vacuum to collect material for proper disposal without raising dust. Rinse area with
water. Prevent large spills from entering sewers or waterways. Contact emergency
services and supplier for advice.
space
Dispose in accordance with all applicable regulations.
Waste Disposal:
space
Use good industrial hygiene practices in handling this material. When using do not eat
Handling Requirements:
or drink. Wash hands before breaks and immediately after handling the product.
Although the product is not flammable, when pouring powder into a container of
flammable liquid, ground both containers electrically to prevent a static spark.
space
Keep out of reach of children. Store in a closed container away from incompatible
Storage Requirements:
materials.
May be stored at ambient temperatures.
RFCCU Equilibrium Catalyst (03019)
19421 Page 2 of 3
.
SECTION VIII - FIRST AID
space
Flush with cool water. Remove contact lenses, if applicable, and continue flushing. Obtain
Eye:
medical attention if irritation persists.
space
Flush with cool water. Wash with soap and water. Obtain medical attention if irritation
Skin:
persists.
space
If symptoms develop move victim to fresh air. If symptoms persist, obtain medical attention.
Inhalation:
space
Do not induce vomiting. If vomiting occurs naturally, have victim lean forward to reduce risk
Ingestion:
of aspiration. Never give anything by mouth if victim is unconscious, or is convulsing. Obtain
medical attention.
.
SECTION IX - PREPARATION INFORMATION
space
Effective Date: 01-Sep-2009
Expiry Date: 01-Sep-2012
Issue Date: 13-Oct-2009
Prepared By: Dell Tech Laboratories Ltd. (519) 858-5021
space
For an updated MSDS, please contact the supplier/manufacturer listed on the first page of the document.
Information contained herein was obtained from sources considered technically accurate and reliable. W hile every effort has been made to ensure full disclosure of
product hazards, in some cases data is not available and is so stated. Since conditions of actual product use are beyond control of the supplier, it is assumed that users
of this material have been fully trained according to the requirements of all applicable legislation and regulatory instruments. No warranty, expressed or implied, is made
and supplier will not be liable for any losses, injuries or consequential damages which may result from the use of or reliance on any information contained in this
document.
RFCCU Equilibrium Catalyst (03019)
19421 Page 3 of 3
RFCCU Equilibrium Catalyst
Contains toxic material. Contains a potential skin sensitizer. Eye and skin irritant.
Avoid contact with eyes and skin. Wear rubber gloves and safety glasses with side shields. Keep out of reach of
children.
EYE: Flush with cool water. Remove contact lenses, if applicable, and continue flushing. Obtain medical attention if
irritation persists.
SKIN: Flush with cool water. Wash with soap and water. Obtain medical attention if irritation persists.
INHALATION: If symptoms develop move victim to fresh air. If symptoms persist, obtain medical attention.
INGESTION: Do not induce vomiting. If vomiting occurs naturally, have victim lean forward to reduce risk of
aspiration. Never give anything by mouth if victim is unconscious, or is convulsing. Obtain medical attention.
READ MATERIAL SAFETY DATA SHEET BEFORE USING PRODUCT
==================================================================================
Contient mati鑢e toxique. Contient un agent sensibilisateur potentiel de la peau. Irritant pour les yeux et la peau.
蓈iter le contact avec les yeux et la peau. Porter des gants en caoutchouc et des lunettes de s閏urit?pourvues de
protections lat閞ales. Tenir hors de la port閑 des enfants.
YEUX: Rincer ?grande eau froide. Enlever les verres de contact, le cas 閏h閍nt, et continuer ?rincer. Obtenir de
l'attention m閐icale si l'irritation persiste.
PEAU: Rincer ?grande eau froide. Laver ?l'eau et au savon. Obtenir de l'attention m閐icale si l'irritation persiste.
INHALATION: En cas de sympt鬽es, placer la victime ?l'air frais. Si les sympt鬽es persistent, obtenir de l'attention
m閐icale.
INGESTION: Ne pas faire vomir. Si le vomissement se produit spontan閙ent, incliner la victime vers l'avant pour
r閐uire le risque d'inhalation. Ne jamais rien faire boire ou avaler ?une victime inconsciente, ou si la victime a des
convulsions. Appeler un m閐ecin.
LIRE LA FICHE SIGNAL蒚IQUE AVANT D'UTILISER CE PRODUIT
Irving Oil Refining G.P.
|