MATERIAL SAFETY DATA SHEET
MATERIAL IDENTITY: SUPERCLEAN TOUGH TASK DEGREASER
SECTION 1 - MANUFACTURER'S INFORMATION
SuperClean Brands, LLC (651) 365-7500
Manufacturer: Telephone:
1380 Corporate Center Curve, Suite 107
Eagan, MN 55121 (651) 365-7599
Facsimile:
Transportation Emergency (for immediate information about a chemical or to seek assistance from a
manufacturer): 1-800-535-5053
Date Updated: April 02, 2010
SECTION 2 - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Common Name: Cleaner Product Use: Multi-purpose cleaner/degreaser
Product Identification: Cleaner
NFPA HAZARD RATINGS
HEALTH - 3
FLAMMABILITY - 0
REACTIVITY - 1
OTHER - NOT APPLICABLE
INGREDIENTS - EXPOSURE LIMITS LD 50 LC 50 %
CHEMICAL/COMMON NAME -TVL
Water [CASRN 7732 - 18 -5] ND ND ND 60-100
2-Butoxyethanol PEL/TWA: 25 ppm Oral, rabbit: 300 mg/kg Inhalation, 7 hr. 5-10
[CASRN 111-76-2] skin (OSHA, ACGIH) Dermal, rabbit: 220 mg/kg mouse: 700
Intravenous, rabbit: 252 mg/kg ppm
Intraperitoneal, rat: 220 mg/kg
Sodium xylene sulfonate ND ND ND 1-5
[CASRN 1300-72-7]
Nonylphenol ethoxylate ND ND ND 1-5
[CASRN 127087-87-0]
Sodium hydroxide PEL/TWA: 2 mg/m3 Oral, mouse: 40 mg/kg ND 1-5
[CASRN 1310-73-2] (OSHA, ACGIH),
Ceiling
Sodium metasilicate
ND Oral, mouse: 770 mg/kg ND 1-5
pentahydrate
[CASRN 6834-92-0]
Other additives [CASRN, NA] ND ND ND 0.5-1.5
Dye and fragrance
ND ND ND 0.1-1
[CASRN, NA]
Page 1 of 6
MSDS SUPERCLEAN TOUGH TASK DEGREASER
MATERIAL SAFETY DATA SHEET
MATERIAL IDENTITY: SUPERCLEAN TOUGH TASK DEGREASER
SECTION 3 - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: ~ (212 F) 100 C Specific Gravity (Water=1): 1.04
Flash Point (COC): NA
Vapor Pressure (mm . Hg. @ 25 C): ND Vapor Density (Air=1): ND
Percent Volatiles: 85-95% Evaporation Rate (Water=1): 1
Solubility in Water: Complete Freeze Point: ~28 f (2 c)
pH-Value: Neat -13.0; 2% - 11.7 Viscosity @ 4O 'c, cSt.: ND
Odor Threshold: NA Coefficient of Water/Oil Distribution: NA
Appearance, Odor & Physical State: Clear , purple liquid ; lemon odor
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
Flammability Yes [ ] No [X] Aqueous fluid
Fire Point (COC): NA
Autoignition Temperature: NA
Flammability limits in Air, % Vol.: Upper - NA Lower - NA
Extinguishing Media:
Use media appropriate for any surrounding combustible substances (Waterfog, CO2, dry chemical, foam).
Special Firefighting Procedures/Unusual and Explosion Hazards:
Coolfire exposed containers with water. Do not enter confined areas without full protective equipment, including
a positive pressure NIOSH approved self-contained breathing apparatus.
EXPLOSION DATA
Sensitivity to Mechanical Impact: NA
Sensitivity to Static Discharge: NA
SECTION 5 - REACTIVITY DATA
Stability: Stable at ambient temperatures
Hazardous Polymerization: Will not occur
Conditions and Materials to Avoid (Incompatibilities):
Strong acids.
Strong oxidizers.
Avoid contact with glass.
Hazardous Combustion or Decomposition Products:
Smoke, fumes, oxides of carbon
Page 2 of 6
MSDS SUPERCLEAN TOUGH TASK DEGREASER
MATERIAL SAFETY DATA SHEET
MATERIAL IDENTITY: SUPERCLEAN TOUGH TASK DEGREASER
SECTION 6 - HEALTH HAZARD DATA
Exposure Limits:
See Section II, Product/Ingredient
PRIMARY ROUTES OF ENTRY:
[X] Eye Contact
[X] Skin Contact
[ ] Skin Absorption
[X] Inhalation (Acute)
[ ] Inhalation (Chronic)
[ ] Ingestion
EFFECTS OF EXPOSURE
Acute ?DANGER! CORROSIVE LIQUID
Eyes: Can cause severe Irritation or burns. Avoid contact.
Skin: Can cause severe irritation or burns. Avoid contact.
Respiratory system: Can cause irritation or burns following Inhalation of mists.
Ingestion: Can cause severe irritation or burns to digestive tract. Do not swallow.
Chronic: No chronic effects known.
Medical Conditions Generally Aggravated by Exposure: Pre-existing skin disorders.
TOXICOLOGY DATA (Product)
Acute Data (Median Lethal Dose -species)
Oral LD50-rat: 8.2 glkg
Dermal LD50- rabbit: ND
Inhalation LC 50 - rat : ND
Irritancy Data:
Eye irritation - rabbit: ND
Skin irritation - rabbit : ND
Sensitization - guinea pig: ND
Signs/Syrnptoms:
Eyes: Irritation, redness, tearing, pain; Conjunctival swelling, burns.
Skin: Irritation, redness, extreme dryness and peeling, scarring.
Respiratory system: Nasal and respiratory irritation, pneumonitis, tissue damage
Eye contact: Immediately flush with Plenty of clean water for at least 15 minutes. Consult a physician Immediately.
Skin contact: Remove clothing. Immediately flush skin with plenty of clean water for 15 minutes. Call a physician
Immediately.
Inhalation: Remove from area of exposure. If breathing is difficult or irritation persists, call a physician.
Ingestion: Do not induce vomiting. Give plenty of water or milk and call physician immediately. Do not give anything by
mouth to an unconscious or convulsing person.
Page 3 of 6
MSDS SUPERCLEAN TOUGH TASK DEGREASER
MATERIAL SAFETY DATA SHEET
MATERIAL IDENTITY: SUPERCLEAN TOUGH TASK DEGREASER
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
INFOTRAC EMERGENCY PHONE NUMBER 1-800-535-5053 24 hrs for U.S> transportation related spills, leaks, fire,
exposure or accident.
Spill or leak Procedures:
Use best engineering practices when attempting cleanup of a large spill.
Large spills - Wear respirator and appropriate protective clothing. Stop source of leak if possible. Dike, contain spill and
recover free liquid. Prevent entry into waterways. Neutralize and/or soak up residue with an inert absorbent such as
clay, sand or other suitable materials; Store and dispose of properly. Flush area with water. Where feasible and
appropriate, remove contaminated soil.
Small spills - Neutralize and/or soak up spill with an inert absorbent such as clay, sand or other suitable materials: Store
in a closed container and dispose of properly.
Regulatory spill reporting requirements may apply; Contact governmental agency or legal counsel for advice.
Waste Disposal Method:
If discarded as supplied, material meets RCRA characteristic definition of corrosivity, 0002. The toxicity characteristic
has not been evaluated. Under RCRA, the applicable hazardous waste classification must be evaluated prior to
disposal of the material. Use of the product, processing contamination may render the resulting material hazardous or
alter waste classification.
All recovered material should be packaged, labeled, transported and disposed of or reclaimed in accordance with local,
state and Federal regulations regarding air pollution, water pollution or health.
CAUTION: Improper disposal or reuse of the empty container may be hazardous and illegal. Cutting or welding of
empty containers may cause explosion or toxic fumes from residues. Do not pressurize or expose to open flame or
heat. Keep container closed and drum bungs in place. RE to applicable governmental regulations.
SECTION 8 - SPECIAL PROTECTION INFORMATION
Ventilation: General ventilation and local exhaust recommended. Build up of mists/vapors in the working atmosphere
must be prevented.
PERSONAL PROTECTIVE EQUIPMENT
When Respiratory Respirators should be used when engineering or other controls are not technically feasible.
Protection: required, use only a MSHA/NIOSH approved air supplied respirator or an air-purifying respirator.
Eye: Safety goggles or face shield.
Gloves (specify): Impervious type gloves, such as rubber, neoprene, nitrile, polyethylene.
Clothing: Protective clothing such as a coverall or apron may be used to minimize skin contact.
Footwear: No special requirement.
Other: Eye wash and safety shower recommended in industrial settings
Work/Hygienic Practices: Avoid skin and eye contact. Do not wear contaminated clothing; Launder before re-use or
discard. Wash thorough after handling.
Storage/Handling: Maintain ambient temperatures. Avoid prolonged breathing of mists. Use with adequate ventilation.
Corrosive to the eyes and skin. Severe internal irritation and damage can result when ingested avoid contact with eyes,
skin or clothing
Do not swallow. Keep container tightly closed when not in use.
Keep out of reach of children.
Page 4 of 6
MSDS SUPERCLEAN TOUGH TASK DEGREASER
MATERIAL SAFETY DATA SHEET
MATERIAL IDENTITY: SUPERCLEAN TOUGH TASK DEGREASER
SECTION 9 - OTHER HAZARDOUS INFORMATION AND DEFINITIONS
OSHA PEL: The Occupational Safety and Health Administration's Permissible Exposure Limit, which is
defined as the maximum concentration of contaminant to which a normal healthy individual may be exposed 8-
hours per day, 40-hours per week, without experiencing adverse health effects over a working lifetime.
ACGIH TLV: American Conference of Governmental Industrial Hygienist's Threshold Limit Value, similar to the
OSHA PEL but not considered a legal standard.
SECTION 10 ?TRANSPORTATION INFORMATION
TRANSPORTATION
Special Shipping Information/DOT Proper Shipping Name:
In inner packaging not over 1 L (0.3 gallon)
Proper Shipping Name Limited Quantity ORM-D
Per 49 CFR 173.154 (b) (1)
In inner packaging over 1 L (1 gallon, 2.5 gallon 5 gallon, 30 gallon, & 55 gallon)
UN3266, CORROSIVE LIQUID, BASIC, INORGANIC, N.O.S. (SODIUM
Proper Shipping Name
HYDROXIDE, SODIUM METASILICATE), 8, PG II
CHEMICALCONTROL REGULATIONS:
TSCA Status: All components of this material appear on the Toxic Substance Control Act Chemical Substances
Inventory.
CEPA Status: All components of this product appear on the Canadian Domestic substances list
Canadian Workplace Hazardous Material Identification System (WHMIS) Classification:
Material is a controlled product.
[ ] Class A - Compressed Gas
[ ] Class 8-1 - Flammable Gases
[ ] Class B-2 - Flammable Liquids
[ ] Class B-3 - Combustible Liquids
[ ] Class B-4 - Flammable Solids
[ ] Class 8-5 - Flammable Aerosols
[ ] Class C -Oxidizing Material
[ ] Class 8-6 - Reactive Flammable Materials
Class D, Div.1 - Materials Causing Immediate and Serious Toxic Effects
[ ] Class D-1A .Very Toxic Material
[ ] Class 0-1 B - Toxic Material
Class D. Div.2 - Materials Causing Other Toxic Effects
[ ] Class D-2A - Very Toxic Materials
[X] Class D-2B .Toxic Materials
[X] Glass E-Corrosive Material
[ ] Class 0-3 - 8iohazardous Infectious Material
[ ] Class F - Dangerously Reactive Material
EPCRA . Emergency Planning and Community Right to Know Act (SARA TItle III):
Section 302/304 Extremely Hazardous Substance: NA
CERCLA Section 102(a) Hazardous Substance:
Sodium hydroxide. Reportable quantity for product=25,000 pounds (11,250 kg).
Section 311 Hazard Category
[X] Acute (immediate)
[ ] Chronic (delayed)
[ ] Fire
[ ] Sudden Release of Pressure
[ ] Reactive
[ ] Not applicable
Page 5 of 6
MSDS SUPERCLEAN TOUGH TASK DEGREASER
MATERIAL SAFETY DATA SHEET
MATERIAL IDENTITY: SUPERCLEAN TOUGH TASK DEGREASER
Section 313 Toxic Release Inventory Chemical/Category:
Glycol Ethers, 3.99% (wt.) max.
U.S. STATE RIGHT TO KNOW LAWS
New Jersey Worker and Community Right to Know Act, N.J.A.C. 8:59 -5 Labeling Information:
See Section ll.
California Safe Drinking Water Enforcement Act ( Proposition 65):
This product contains one or more chemicals known to the State of California to cause cancer or reproductive harm.
ABBREVIATIONS:
NE = NOT ESTABLISHED NDA = NO DATA AVAILABLE
> = GREATER THAN <= LESS THAN
BCF = BIOCONCENTRATION FACTOR ND = NO DATA
The information presented herein is compiled from sources considered to be dependable, believed to be accurate to
the best of SuperClean Brands, LLC knowledge and offered in good faith for the purpose of hazard communication.
Because product use is beyond our control no warranty is given expressed or implied. SuperClean Brands, LLC
cannot assume any liability for the use of information contained herein. To determine applicability or effect of any law
or regulation with respect to the product use is beyond our control no warranty is given expressed or implied.
SuperClean Brands, LLC cannot assume any liability; user should consult a legal advisor or appropriate
governmental agency.
Page 6 of 6
MSDS SUPERCLEAN TOUGH TASK DEGREASER
|