Material Safety Data Sheet
Section I -- Product Identification
Manufacturer: Hottec Inc. Phone: (860)887-5111
One Terminal Way
Norwich, CT 06360
Product Class: Friction Adhesive !!Hazard Ratings 0 4
Trade Name : E1210 !! Health-2 Fire-3 low-extreme
C.A.S. # : NA !! Reactivity ?
Section II -- Hazardous Ingredients
INGREDIENTS CAS # % ACGIH/TLV OSHA/PEL mm HG
Methyl Ethyl Ketone 78-93-3 40. 200 ppm 200 ppm 70.6
STEL= 300 ppm 300 ppm
Elastomer 9003-18-3 15. N/AP
Phenol (skin) 108-95-2 <5. 5 ppm 5 ppm N/AP
Carbon Black ? 1333-86-4 5. 3.5 mg/M3 3.5 mg/M3 0
Ortho-Cresol (skin) 95-48-7 <1. 5 ppm 5 ppm N/AV
Isopropyl Alcohol 67-63-0 15. 400 ppm 400 ppm 33
STEL= 500 ppm 500 ppm
Formaldehyde 50-00-0 <1. 0.3 ppm 0.75 ppm 0
STEL= 0.3 ppm 2 ppm
Phenolic Resin 9039-25-2 20. 0
稩ARC LISTED AS 2B CARCINOGEN: POSSIBLY CARCINOGENIC TO
HUMANS.
LISTED BY IARC AS PROBABLY CARCINOGENIC TO HUMANS
LISTED BY NTP AS REASONABLY ANTICIPATED TO BE
CARCINOGENIC
LISTED BY OSHA AS A CARCINOGEN
***All ingredients in this product are listed in the T.S.C.A. inventory.
________________________________________________________________________
Section III -- Physical Data
Boiling Range: 175-180癋 Vapor Density: Heavier than Air
Evap. Rate : Faster than
n-butyl acetate Liquid Density: Lighter than water
Volatiles vol %65 wgt %56 Wgt per gallon: 7.99 Pounds
Spec. Gravity : 0.95918
Appearance: THICK BLACK LIQUID SHARP ODOR
V.O.C.: 535 G/L
Section IV -- Fire and Explosion Hazard Data
Flammability Class: 1B Flash Point: 20 F TCC LEL: 2.00% UEL: 12.70%
-Extinguishing Media:
Water Fog, Carbon Dioxide, Foam, Dry Chemical.
-Special Firefighting Procedures:
Do not enter confined fire space without proper protective equipment including
NIOSH approved self contained breathing apparatus.
-Unusual Fire & Explosion Hazards:
Vapors may build up in poorly ventilated areas and be ignited, causing flash
Fires or explosions. Vapors are heavier than air and may travel along ground or
Floor to source of ignition, causing flash fires or explosions.
Section V -- Health Hazard Data
-Permissible Exposure Level:
See Section II
-Effects of Overexposure:
Inhalation: Nose and throat irritation, headache, nausea, loss of
Coordination, dizziness, unconsciousness, and even
Asphyxiation.
Skin Contact : May cause defatting or dermatitis
Eye Contact : May cause irritation or corneal clouding.
Ingestion : Aspiration into lungs may cause chemical pneumonitis
Chronic Effects: May include kidney and liver damage and dermatitis.
NOTICE: Reports have associated repeated and prolonged occupational over-exposure
to solvents with permanent brain and nervous system damage. Intentional misuse by
deliberately concentrating and inhaling the contents may be harmful or fatal.
Embryo/fetotoxic effects have been observed in laboratory rats exposed to over 1000
ppm Methyl Ethyl Ketone for most of gestation period.
-Medical Conditions Aggravated by Exposure: None known.
-First Aide:
Inhalation : Remove to fresh air, if not breathing give mouth to mouth, if
Breathing difficulty give oxygen, call a physician at once.
Skin Contact: Remove contaminated clothing and launder before reuse. Wash
Affected area with plenty of soap and water.
Eye Contact : Flush with plenty of water for at least 15 min (hold eye lids
Open) longer if there is indication of residual material in eye.
Ingestion : Do not induce vomiting. Call a physician immediately.
*Never give anything by mouth to an unconscious person.
Section VI -- Reactivity Data
Stability [ ] unstable [x]stable
Hazardous Polymerization [ ] may occur [x]will not occur
-Incompatibility: Strong oxidizing agents.
-Conditions to Avoid: See above
-Hazardous Decomposition Products: Carbon dioxide, carbon monoxide, smoke,
aliphatics, and others.
Section VII -- Spill or Leak Procedures
-Steps to be taken in case material is released or spilled:
Eliminate all ignition sources, provide adequate ventilation, avoid breathing
Vapors, avoid eye and skin contact. Wipe up with rags, paper or other absorbent
Materials. Place in suitable closed containers for disposal.
-Waste Disposal Method:
This material if discarded is hazardous and must be properly stored, transported,
Disposed of in accordance with applicable local, state, and federal regulations.
Section VIII -- Special Protection Information
-Respiratory Protection:
For air contaminants above TLV or permissible limits use NIOSH approved
Respirator for organic vapors.
-Ventilation:
Local exhaust to keep vapors below TLV or permissible limits.
-Protective Gloves:
Impervious
-Eye Protection:
Chemical Goggles
-Other Protective Equipment:
Eye wash and safety shower near by
Section IX -- Special Precautions
-Precautions to be taken in handling and storing:
Use only in a well ventilated area. Eliminate all sources of ignition such
As sparks, flames, and non-explosion proof devices. Avoid prolonged or
Repeated skin contact or breathing of vapors. For industrial use only, keep
Out of the reach of children. Store in tightly closed containers, in a cool dry place
Away from all sources of ignition and heat. Large containers should be grounded
And interconnected to prevent static build up during transfer operations. Empty
Containers of this material may be hazardous since they may contain residual
Liquid, vapors or dust. Occupational safety and health specialist to insure that
The handling procedures will be adequate and in compliance with applicable laws
And regulations.
-Disclaimer of Liability:
The information contained herein is based on data taken from sources believed
To be both current and reliable at the time of publication. Hottec Inc. however
Makes no warranties express or implied as to its accuracy and assumes no
Liability arising from its use by others. Compliance with all applicable federal,
State and local laws and regulations remains the responsibility of the users.
Section X -- Additional Regulatory Information
-Sara Title II Section 313:
This product contains the following toxic chemicals subject to the reporting
Requirements of section 313 of the Emergency Planning and Community Right
To Know Act of 1986 and of 40 CFR 372:
CAS # Chemical Name Percent by Weight
78-93-3 Methyl Ethyl Ketone <50.
108-95-2 Phenol (skin) 1.93
95-48-7 Ortho-Cresol (skin) <1.
50-00-0 Formaldehyde <1.
-Prop 65 (CARCINOGEN):
WARNING: This product contains a chemical known to the state of California
To cause Cancer.
CAS # 50-00-0 CHEMICAL NAME- Formaldehyde
Product may contain trace amounts of California Proposition 65 listed chemicals
-PROP 65 (TERATOGEN):
WARNING: This product contains a chemical known to the state of California
To cause birth defects or other reproductive harm.
CAS # - CHEMICAL NAME ?None
-PROP 65 (BOTH CARCINOGEN AND TERATOGEN):
WARNING: This product may contain a chemical known to the state of
California to cause cancer or birth defects or other re-
Productive harm.
CAS# - CHEMICAL NAME - None
|