Safety data sheet
Basonat* F 200 WD
Revision date : 2008/03/18 Page: 1/6
Version: 3.0 (30041220/MDS_GEN_US/EN)
1. Substance/preparation and company identification
Company 24 Hour Emergency Response Information
BASF CORPORATION CHEMTREC: 1-800-424-9300
100 Campus Drive BASF HOTLINE: 1-800-832-HELP
Florham Park, NJ 07932, USA
Chemical family: polyisocyanate, aliphatic
Synonyms: POLYFUNCTIONAL ISOCYANATE
2. Composition/information on ingredients
CAS Number Content (W/W) Chemical name
70.0 - 90.0 % NJTS-50714-NLD
7.0 - 15.0 % Trade Secret NJTS50005NCD
7.0 - 15.0 % NJTS-50715-NLD
822-06-0 0.5 - 1.5 % 1,6-hexamethylene diisocyanate
3. Hazard identification
Emergency overview
CAUTION: May cause sensitization by skin contact.
HARMFUL IF INHALED.
Irritating to eyes and skin.
Avoid inhalation of mists/vapours.
Wear a NIOSH-certified (or equivalent) acid gas/organic vapour respirator.
Use with local exhaust ventilation.
Wear full face shield if splashing hazard exists.
Wear protective clothing.
Potential health effects
Primary routes of exposure
Routes of entry for solids and liquids include eye and skin contact, ingestion and inhalation. Routes of entry
for gases include inhalation and eye contact. Skin contact may be a route of entry for liquified gases.
4. First-aid measures
General advice:
Remove contaminated clothing.
Safety data sheet
Basonat* F 200 WD
Revision date : 2008/03/18 Page: 2/6
Version: 3.0 (30041220/MDS_GEN_US/EN)
If inhaled:
Remove the affected individual into fresh air and keep the person calm. Assist in breathing if necessary.
Immediate medical attention required.
If on skin:
Wash affected areas thoroughly with soap and water. Seek medical attention.
If in eyes:
In case of contact with the eyes, rinse immediately for at least 15 minutes with plenty of water. Seek medical
attention.
If swallowed:
Rinse mouth and then drink plenty of water. Do not induce vomiting. Never induce vomiting or give anything
by mouth if the victim is unconscious or having convulsions. Immediate medical attention required.
5. Fire-fighting measures
Flash point: approx. 140 癈 (DIN 51758)
Suitable extinguishing media:
water, dry extinguishing media, carbon dioxide, foam
Hazards during fire-fighting:
No particular hazards known.
Protective equipment for fire-fighting:
Wear a self-contained breathing apparatus.
6. Accidental release measures
Cleanup:
For small amounts: Pick up with suitable absorbent material (e.g. sand, sawdust, general-purpose binder,
kieselguhr). Dispose of absorbed material in accordance with regulations.
For large amounts: Pump off product.
For residues: Rinse away with water.
7. Handling and storage
Handling
General advice:
Handle in accordance with good industrial hygiene and safety practice.
Ensure adequate ventilation. Provide suitable exhaust ventilation at the processing machines. The viscous
consistency of the polymer can cause disturbances in pipelines.
Protection against fire and explosion:
Containers should be grounded against electrostatic charge.
Storage
General advice:
Avoid all sources of ignition: heat, sparks, open flame. Keep container tightly closed and dry; store in a cool
place.
Storage stability:
Safety data sheet
Basonat* F 200 WD
Revision date : 2008/03/18 Page: 3/6
Version: 3.0 (30041220/MDS_GEN_US/EN)
If moisture enters isocyanate containers, CO2 forms and pressure builds up.
8. Exposure controls and personal protection
Components with workplace control parameters
1,6-hexamethylene
diisocyanate ACGIH TWA value 0.005 ppm ;
Advice on system design:
Provide local exhaust ventilation to maintain recommended P.E.L.
Personal protective equipment
Respiratory protection:
Wear a NIOSH-certified (or equivalent) organic vapour/particulate respirator. Do not exceed the maximum
use concentration for the respirator facepiece/cartridge combination. For emergency or non-routine, high
exposure situations, use a NIOSH-certified full facepiece pressure demand self-contained breathing
apparatus (SCBA) or a full facepiece pressure demand supplied-air respirator (SAR) with escape provisions.
Hand protection:
Chemical resistant protective gloves
Eye protection:
Tightly fitting safety goggles (chemical goggles). Wear face shield if splashing hazard exists.
General safety and hygiene measures:
No special measures necessary if stored and handled correctly. Wear protective clothing as necessary to
prevent contact. Avoid inhalation of vapours/mists. Wash soiled clothing immediately.
9. Physical and chemical properties
Form: liquid
Odour: faintly aromatic
Colour: colourless to slightly yellow
pH value: No data available.
solidification temperature: approx. -19 癈
Boiling range: No data available.
Vapour pressure: 0.000006 mbar ( 20 癈)
0.000003 mbar ( 60 癈)
Density: 1.1 g/cm3 ( 20 癈) (ISO 2811-1)
( 23 癈) (DIN EN ISO 3219)
Viscosity, dynamic: 1,500 - 3,500
mPa.s
Solubility in water: emulsifiable
10. Stability and reactivity
Substances to avoid:
amines, amine compounds, alcohols, water
Hazardous reactions:
Reacts with water, with formation of carbon dioxide. Reacts with substances which contain active hydrogen.
Decomposition products:
Hazardous decomposition products: carbon monoxide, carbon dioxide, hydrogen cyanide, nitrogen oxides
Thermal decomposition:
No decomposition if used correctly.
Safety data sheet
Basonat* F 200 WD
Revision date : 2008/03/18 Page: 4/6
Version: 3.0 (30041220/MDS_GEN_US/EN)
Corrosion to metals:
No corrosive effect on metal.
11. Toxicological information
Acute toxicity
Oral:
LD50/rat: > 5,000 mg/kg
Skin irritation:
rabbit: Irritant. (BASF-Test)
Eye irritation :
rabbit: Irritant. (BASF-Test)
Chronic toxicity
Other information:
The statement was derived from products of similar composition.
12. Ecological information
Environmental toxicity
Toxicity to microorganisms:
Inhibition of degradation activity in activated sludge is not to be anticipated during correct introduction of low
concentrations.
Other ecotoxicological advice:
Do not release untreated into natural waters. The local regulations on waste-water treatment must be
followed.
13. Disposal considerations
Waste disposal of substance:
Dispose of in accordance with national, state and local regulations.
Incinerate or dispose of in a licensed facility.
Do not discharge into drains/surface waters/groundwater.
Container disposal:
Dispose of in a licensed facility. Recommend crushing, puncturing or other means to prevent unauthorized
use of used containers.
14. Transport information
Land transport
USDOT
Safety data sheet
Basonat* F 200 WD
Revision date : 2008/03/18 Page: 5/6
Version: 3.0 (30041220/MDS_GEN_US/EN)
Not classified as a dangerous good under transport regulations
Sea transport
IMDG
Not classified as a dangerous good under transport regulations
Air transport
IATA/ICAO
Not classified as a dangerous good under transport regulations
15. Regulatory information
Federal Regulations
Registration status:
TSCA, US released / listed
OSHA hazard category: Chronic target organ effects reported, ACGIH TLV established
CERCLA RQ CAS Number Chemical name
100 LBS 822-06-0 1,6-hexamethylene diisocyanate
SARA hazard categories (EPCRA 311/312): Acute, Chronic
SARA 313:
CAS Number Chemical name
822-06-0 1,6-hexamethylene diisocyanate
State regulations
State RTK
CAS Number Chemical name State RTK
Trade Secret NJTS50005NCD NJ, PA, MA
822-06-0 1,6-hexamethylene diisocyanate MA, NJ
CA Prop. 65:
THIS PRODUCT CONTAINS A CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
16. Other information
HMIS III rating
Health: 2? Flammability: 1 Physical hazard: 0
HMIS uses a numbering scale ranging from 0 to 4 to indicate the degree of hazard. A value of zero means that the
substance possesses essentially no hazard; a rating of four indicates high hazard.
Local contact information
prod_reg@basf.com
Basonat is a registered trademark of BASF Corporation or BASF SE
IMPORTANT: WHILE THE DESCRIPTIONS, DESIGNS, DATA AND INFORMATION CONTAINED HEREIN
ARE PRESENTED IN GOOD FAITH AND BELIEVED TO BE ACCURATE , IT IS PROVIDED FOR YOUR
Safety data sheet
Basonat* F 200 WD
Revision date : 2008/03/18 Page: 6/6
Version: 3.0 (30041220/MDS_GEN_US/EN)
GUIDANCE ONLY. BECAUSE MANY FACTORS MAY AFFECT PROCESSING OR APPLICATION/USE,
WE RECOMMEND THAT YOU MAKE TESTS TO DETERMINE THE SUITABILITY OF A PRODUCT FOR
YOUR PARTICULAR PURPOSE PRIOR TO USE. NO WARRANTIES OF ANY KIND, EITHER
EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE, ARE MADE REGARDING PRODUCTS DESCRIBED OR DESIGNS, DATA OR
INFORMATION SET FORTH, OR THAT THE PRODUCTS, DESIGNS, DATA OR INFORMATION MAY BE
USED WITHOUT INFRINGING THE INTELLECTUAL PROPERTY RIGHTS OF OTHERS. IN NO CASE
SHALL THE DESCRIPTIONS, INFORMATION, DATA OR DESIGNS PROVIDED BE CONSIDERED A
PART OF OUR TERMS AND CONDITIONS OF SALE. FURTHER, YOU EXPRESSLY UNDERSTAND AND
AGREE THAT THE DESCRIPTIONS, DESIGNS, DATA, AND INFORMATION FURNISHED BY BASF
HEREUNDER ARE GIVEN GRATIS AND BASF ASSUMES NO OBLIGATION OR LIABILITY FOR THE
DESCRIPTION, DESIGNS, DATA AND INFORMATION GIVEN OR RESULTS OBTAINED, ALL SUCH
BEING GIVEN AND ACCEPTED AT YOUR RISK.
END OF DATA SHEET
|