HEALTH 2 MATERIAL SAFETY DATA SHEET
HAZARD RATING
VEXCON NO. CP108B CLEAR
4=EXTREME
3=HIGH
FLAMMABILITY 2
2=MODERATE
1=SLIGHT
0=INSIGNIFICANT REACTIVITY 1
------------------------------------------------------------------------ -------------------------------------------------------------------------
SECTION IV FIRE AND EXPLOSION DATA
GENERAL INFORMATION
--------------------------------------------------------------------------
------------------------------------------------------------------------
PRODUCT IDENTIFICATION: VEXCON POWER?COAT U 1500 V PART B FLASH POINT (TEST METHOD): 106O F AUTOIGNITION TEMP: 425O C
CLEAR FLAMMABLE LIMITS IN AIR, % BY VOL: LOWER: 0.6 UPPER: 7.5
VOC CONTENT: 413 GR./LITER OR 3.45 #/GAL. UNUSUAL FIRE AND EXPLOSION HAZARD: NO UNUSUAL HAZARDS -
CATEGORY: INDUSTRIAL MAINTENANCE COATING KEEP WORK AREAS FREE OF HOT METAL
COMMON NAME: URETHANE TOPCOAT ELECTROSTATIC ACCUMULATION HAZARD - USE PROPER GROUNDING
GENERAL HAZARD: COMBUSTIBLE LIQUID, CAN FORM COMBUSTIBLE
DOT SHIPPING NAME: IN CONTAINERS LESS THAN 119 GALS: VEXCON
MIXTURES AT TEMPERATURES AT OR ABOVE THE FLASH POINT. STATIC
POWERCOAT PART CRA: (NON-REGULATED)
DISCHARGE, MATERIAL CAN ACCUMULATE STATIC CHARGES WHICH
FOR LIMITED QUANITY AIR & OCEAN SHIPMENT: RQ (AROMATIC CAN CAUSE AN INCENDIARY ELECTRICAL DISCHARGE. "EMPTY"
SOLVENT) RESIN SOLUTION, FLAMMABLE, 3, UN1866, III CONTAINERS RETAIN PRODUCT RESIDUE (LIQUID AND/OR VAPOR) AND
HEALTH AND SAFETY: COMBUSTIBLE LIQUID. REACTS VIOLENTLY WITH CAN BE DANGEROUS. DO NOT ELECTRICITY, OR OTHER SOURCES OF
COMMON MATERIALS INCLUDING WATER, ALCOHOLS, BASES AND AMINES. IGNITION: THEY MAY EXPLODE AND CAUSE INJURY OR DEATH. EMPTY
TOXIC IF INHALED. EYE, SKIN AND RESPIRATORY TRACT IRRITANT. DRUMS SHOULD BE COMPLETELY DRAINED, PROPERLY BUNGED AND
POSSIBLE SENITIZER. PROMPTLY RETURNED TO A DRUM RECONDITIONER, OR PROPERLY
-------------------------------------------------------------------------- DISPOSED OF.
FIRE FIGHTING: USE WATER SPRAY TO COOL FIRE EXPOSED
SECTION I SURFACES AND TO PROTECT PERSONNEL. ISOLATE "FUEL" SUPPLY
-------------------------------------------------------------------------- FROM FIRE. USE FOAM, DRY CHEMICAL, OR WATER SPRAY TO
EXTINGUISH FIRE. AVOID SPRAYING WATER DIRECTLY INTO STORAGE
MANUFACTURER: VEXCON CHEMICALS
CONTAINERS DUE TO DANGER OF BOIL OVER. THE USE OF SELF-
EMERGENCY NO: 1-800-858-2828
CONTAINED BREATHING APPARATUS IS RECOMMENDED FOR FIRE
CHEMTREC NO: 1-800-424-9300
FIGHTERS. SEE ALSO SECTION IX.
TELEPHONE NO: 1-215-332-7709
----------------------------------------------------------------------
ADDRESS : 7240 STATE RD., PHILA., PA 19135
PREPARED: NOVEMBER 1999
SECTION V REACTIVITY DATA
UPDATED: DECEMBER 2006
-----------------------------------------------------------------------
PREPARED BY: DARRYL F. MANUEL
--------------------------------------------------------------- CONDITIONS CONTRIBUTING TO INSTABILITY: PRODUCT REACTS WITH
SECTION II HAZARDOUS INGREDIENTS WATER AND HIGH TEMPERATURE.
----------------------------------------------------------------- INCOMPATIBILITY: THIS PRODUCT IS INCOMPATIBLE WITH STRONG
OXIDIZING AGENTS STRONG ACIDS OR BASES AND SELECTED
MATERIAL OR COMPONENT CAS NO. % OSHA HAZARD TWA
AMINESAND WATER. HAZARDOUS DECOMPOSITION PRODUCTS:
HEXANE, 1,6 DIISOCYANATO-,
THERMAL DECOMPOSITION IN THE PRESENCE OF AIR YIELD CARBON
HOMOPOLYMER 28182-81-2 >46 Y 0.005 PPM ACGIH
MONOXIDE AND/OR CARBON DIOXIDE, OXIDES OF NITROGEN.
BUTYL ACETATE 123-86-4 <2 Y 150 PPM ACGIH
CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERIZATION: WILL
C8-C10 AROMATIC
NOT OCCUR.
HYDROCARBONS 64742-95-6 3.25 Y
------------------------------------------------------------
TRIMETHYLBENZENE 95-63-6 <1.6 Y
HEXAMETHYLENE
DIISOCYANATE 822-06-0 <0.2 Y SECTION VI HEALTH HAZARD INFORMATION
------------------------------------------------------------------------- ------------------------------------------------------------
SECTION III PHYSICAL/CHEMICAL CHARACTERISTICS HEALTH HAZARD DATA HAZARD CLASSIFICATION BASIS FOR
--------------------------------------------------------------------------- CLASSIFICATION SOURCE
BOILING POINT, 760 mm Hg: 145OC MELTING POINT: N/A ROUTES OR EXPOSURE/INHALATION: TOXIC IF INHALED. MAY CAUSE
SHORTNESS OF BREATH, INTOXICATION, HEADACHE, NAUSEA, VOMITING,
SPECIFIC GRAVITY (H20=1) 1.12
RESPIRATORY TRACT INFECTIONS.
VAPOR PRESSURE: NOT AVAILABLE
SKIN CONTACT: MAY BE HARMFUL IF ABSORBED THROUGH THE SKIN.
VAPOR DENSITY (AIR = 1): NOT AVAILABLE
MAY CAUSE IRRITATION. MAY CAUSE HARMFUL ALLERGIC REACTION.
SOLUBILITY IN H2O % BY WT: REACTS
% VOLATILES BY VOL: 12 SKIN ABSORPTION: SEE ABOVE
EYE CONTACT: MAY CAUSE IRRITATION
EVAPORATION RATE (BUAC=1): .1
INGESTION: SMALL AMOUNTS OF LIQUID ASPIRATED INTO THE
PH (AS IS) N/A PH (1% SOLN.): N/A RESPIRATORY SYSTEM DURING INGESTION, OR FROM VOMITING, MAY
CAUSE BRONCHOPNEUMONIA OR PULMONARY EDEMA. DO NOT INDUCE
APPEARANCE AND ODOR: WATER WHITE LIQUID W/AROMATIC ODOR
VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION.
OR GRAY PAINT
-------------------------------------------------------------
EFFECTS OF OVEREXPOSURE TLV-50 ppm
SECTION IX SPECIAL PRECAUTIONS
---------------------------------------------------------------
ACUTE OVEREXPOSURE: ANESTHESIA, HEADACHE, NAUSEA,
DIZZINESS: MODERATE IRRITATION BY LIQUID TO SKIN AND EYES. PRECAUTIONARY STATEMENTS:
EMERGENCY AND FIRST AID PROCEDURES: FIRE FIGHTING: WATER MAY BE UNSUITABLE AS AN EXTINGUISHING
MEDIA BUT HELPFUL IN KEEPING ADJACENT CONTAINERS COOL.
EYES: FLUSH WITH LARGE QUANTITIES OF WATER FOR AT LEAST 15 AVOIDSPREADING BURNING LIQUID WITH WATER USED FOR COOLING
MINUTES. SEEK IMMEDIATE MEDICAL ATTENTION. PURPOSES. PERSONNEL SHOULD AVOID INHALATION OF VAPORS.
PERSONAL CONTACT WITH THE PRODUCT SHOULD BE AVOIDED.
SKIN: WASH WITH SOAP AND LARGE QUANTITIES OF WATER. SEEK SHOULD CONTACT BE MADE REMOVE SATURATED CLOTHING AND
MEDICAL ATTENTION IF SKIN IRRITATION DEVELOPS AND PERSISTS. FLUSH AFFECTED AREAS WITH WATER.
INHALATION: MOVE TO LOCATION FREE FROM VAPORS. IF OTHER HANDLING AND STORAGE REQUIREMENTS: KEEP PRODUCT
BREATHING STOPS, BEGIN ARTIFICIAL RESPIRATION AND SEEK CONTAINERS COOL, DRY AND AWAY FROM SOURCES OF IGNITION.
IMMEDIATE MEDICAL ATTENTION. USE AND STORE THIS PRODUCT WITH ADEQUATE VENTILATION
EQUIVALENT TO FRESH AIR.
INGESTION: IF VICTIM IS CONSCIOUS AND ALERT, GIVE 2-3 GLASSES
OF WATER TO DRINK AND INDUCE VOMITING BY TOUCHING BACK OF HMIS HAZARD RATINGS: THIS INFORMATION IS FOR PEOPLE
THROAT WITH A FINGER. DO NOT INDUCE VOMITING OR GIVE TRAINED IN: NATIONAL PAINT AND COATING ASSOCIATIONS
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. SEEK (NPCA) HAZARDOUS MATERIALS IDENTIFICATION SYSTEM
IMMEDIATE MEDICAL ATTENTION. DO NOT LEAVE VICTIM (HMIS) NATIONAL FIRE PROTECTION ASSOCIATION (NEPA
UNNATTENDED. VOMITING MAY OCCUR SPONTANEOUSLY. TO 704)IDENTIFICATION OF FIRE HAZARDS OF MATERIALS
PREVENT ASPIRATION OF SWALLOWED PRODUCT, LAY VICTIM ON
SIDE WITH HEAD LOWER THAN WAIST. IF VOMITING OCCURS AND THE NPCA-HMIS NFPA 704 KEY
VICTIM IS UNCONSCIOUS, GIVE WATER TO FURTHER DILUTE THE HEALTH 2 2 4=SEVERE
CHEMICAL. FLAMMABILITY 2 2 3=SERIOUS
------------------------------------------------------------- REACTIVITY 1 1 2=MODERATE
1=SLIGHT
SECTION VII PRECAUTIONS FOR SAFE 0=MINIMAL
HANDLING AND USE -------------------------------------------------------------
------------------------------------------------------------- SECTION X REGULATORY INFORMATION
WASTE DISPOSAL METHOD: IF POSSIBLE, PUMP TO CONTROLLED
-------------------------------------------------------------
CONTAINMENT AREA. ABSORB ON CLAY OR SAND. DISPOSE OF IN
COMPLIANCE WITH EPA, STATE, AND LOCAL REGULATIONS. TSCA: THE SOLVENT PORTION OF THIS PRODUCT IS LISTED ON THE
TSCA INVENTORY AS A UVCB (UNKNOWN, VARIABLE COMPOSITION OR
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: BIOLOGICAL) CHEMICAL AT CAS REGISTRY NUMBER 64742-95-6.
LAND SPILL: ELIMINATE SOURCES OF IGNITION. PREVENT ADDITIONAL
DISCHARGE OF MATERIAL F POSSIBLE TO DO SO WITHOUT HAZARD. FOR
CERCLA: IF THE REPORTABLE QUANTITY OF THIS PRODUCT IS
SMALL SPILLS IMPLEMENT CLEANUP PROCEDURES: FOR LARGE SPILL
ACCIDENTALLY SPILLED, THE INCIDENT IS SUBJECT TO HE PROVISIONS
IMPLEMENT CLEAN UP PROCEDURES AND, IF IN PUBLIC AREA, KEEP
OF THE COMPREHENSIVE ENVIRONMENTAL RESPONSE COMPENSATION
PUBLIC AWAY AND ADVISE
AND LIABILITY ACT (CERCLA) AND MUST BE REPORTED TO THE
AUTHORITIES. ALSO, IF THIS PRODUCTS SUBJECT TO CERCLA REPORTING
NATIONAL RESPONSE CENTER BY CALLING 800-424-8802. THIS
NOTIFY THE NATIONAL RESPONSE CENTER. PREVENT LIQUID FROM
MATERIAL IS COVERED BY CERCLA'S PETROLEUM EXCLUSION,
ENTERING SEWERS, WATERCOURSES, OR LOW AREAS. CONTAIN SPILLED
THEREFORE, RELEASES TO AIR, LAND AND WATER ARE NOT
LIQUID WITH SAND OR EARTH. DO NOT USE COMBUSTIBLE MATERIALS
REPORTABLE UNDER EPA-CERCLA (SUPERFUND).
SUCH AS SAWDUST. RECOVER BY PUMPING (USE AN EXPLOSION PROOF
OR HAND PUMP) OR WITH A SUITABLE ABSORBENT. CONSULT AN
THIS PRODUCT CONTAINS: TRIMETHLBENZENE
EXPERT ON DISPOSAL OF RECOVERED MATERIAL AND ENSURE
CONFORMITY TO LOCAL DISPOSAL REGULATIONS.
SARA TITLE III: UNDER THE PROVISIONS OF TITLE III, SECTIONS 311/312
OF THE SUPERFUND AMENDMENTS AND RE-AUTHORIZATION ACT, THIS
WATER SPILL: REMOVE FROM SURFACE BY SKIMMING OR WITH SUITABLE
PRODUCT IS CLASSIFIED INTO THE FOLLOWING HAZARD
ABSORBENTS. IF ALLOWED BY LOCAL AUTHORITIES AND ENVIRONMENTAL
CATEGORIES.RCRA (40 CFR 261.21) IF THIS PRODUCT BECOMES A
AGENCIES, SINKING AND/OR SUITABLE DISPERSENTS MAY BE USED IN
WATER MATERIAL, IT WOULD BE AN IGNITABLE HAZARDOUS WASTE.
ON-CONFINED WATERS. CONSULT AN EXPERT ON DISPOSAL OF
HAZARDOUS WASTE NUMBER D001. REFER TO LATEST EPA OR STATE
RECOVERED MATERIAL AND ENSURE CONFORMITY TO LOCAL DISPOSAL
REGULATIONS REGARDING PROPER DISPOSAL.
REGULATIONS.
------------------------------------------------------------- DELAYED HEALTH, FIRE.
FEDERAL:
SECTION VIII CONTROL MEASURES
FDA:
--------------------------------------------------------------- USDA:
TSCA: IS THIS PRODUCT, OR ALL ITS INGREDIENTS, BEING CERTIFIED
VENTILATION REQUIREMENTS: LOCAL MECHANICAL VENTILATION MAY BE
FOR INCLUSION ON THE TOXIC SUBSTANCESCONTROL ACT INVENTORY
SUFFICIENT TO KEEP PRODUCT VAPOR CONCENTRATIONS WITHIN
OF CHEMICAL SUBSTANCES? YES
SPECIFIED TIME-WEIGHTED TLV RANGES. IF GENERAL VENTILATION
PROVES INADEQUATE TO MAINTAIN SAFE VAPOR CONCENTRATIONS,
PREPARED BY: DARRYL MANUEL
SUPPLEMENTAL LOCAL EXHAUST MAY BE REQUIRED. OTHER SPECIAL
PRECAUTIONS SUCH AS RESPIRATORY MASKS OR ENVIRONMENTAL TITLE: PRESIDENT
CONTAINMENT DEVICES MAY BE REQUIRED IN EXTREME CASES. COMPANY: VEXCON CHEMICALS,
RESPIRATORY (SPECIFY IN DETAIL): THE USE OF RESPIRATORY ADDRESS: 7240 STATE ROAD, PHILA.PA 19135
PROTECTION DEPENDS ON VAPOR CONCENTRATION ABOVE THE TIME
WEIGHTED TLV: USE OF A OSHA APPROVED CARTRIDGE RESPIRATOR OR
THE INFORMATION PROVIDED IN THIS MATERIAL
GAS MASK OR AIRPACK.
SAFETY DATA SHEET HAS BEEN OBTAINED FROM SOURCES
EYE: CHEMICAL GOGGLES AND/OR FACE SHIELDS ARE RECOMMENDED
BELIEVED TO BE RELIABLE. VEXCON PROVIDES NO
TO SAFEGUARD AGAINST POTENTIAL EYE CONTACT, IRRITATION OR
WARRANTIES, EXPRESS OR IMPLIED, AND ASSUMES NO
INJURY.
RESPONSIBILITY FOR THE ACCURACY OR COMPLETEMENT OF
GLOVES: THE USE OF IMPERMEABLE GLOVES IS ADVISED TO
THE INFORMATION CONTAINED HEREIN
PREVENT SKIN IRRITATION IN SENSITIVE INDIVIDUALS.
OTHER CLOTHING AND EQUIPMENT: IMPERMEABLE APRONS AND
HELMETS (HEAD COVER) ARE ADVISED WHEN WORKING WITH THIS
PRODUCT. THE AVAILABILITY OF EYE WASHES AND SAFFETY
SHOWERS IN WORK AREAS IS RECOMMENDED
|