Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924 (ChemTel)
International Emergency: +01-813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: HIGH STRENGTH THREADLOCKER RED GEL 10 GR
Item No: 27010
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH; TLV-TWA OSHA PEL
POLYGLYCOL DIMETHACRYLATE 50-70 Not listed Not listed
25852-47-5
POLYESTER RESIN 20-40 Not listed Not listed
MIXTURE
-
10 mg/m3
TREATED SILICON DIOXIDE, <10 Not listed
SYNTHETIC, CRYSTALLINE-FREE
67762-90-7
DIMETHYLBENZYL <3 Not listed Not listed
HYDROPEROXIDE
80-15-9
PROPYLENE GLYCOL <3 Not listed Not listed
57-55-6
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. At elevated temperatures may cause irritation of the respiratory tract.
Toxicity:
Irritates mucous membranes. Ingestion may irritate digestive tract and cause nausea, vomiting and
diarrhea. High concentrations may cause central nervous system (CNS) depression. May cause skin
sensitization. Note: This product does not contain microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. Skin redness. Ingestion may cause nausea and
Signs and Symptoms of Exposure:
vomiting. Inhalation overexposure may cause irritation, coughing and flu-like symptoms. May cause pain,
redness or swelling of the eyes and excessive blinking and tear production.
Preexisting skin disorders.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
>200癋
Flash Point 癋(C?:
Carbon dioxide, Dry chemical, Foam
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Oxides of carbon, Irritating vapors
Hazardous Products of Combustion:
None reasonably foreseeable
Unusual Fire/Explosion Hazards:
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until disposal.
Spill Procedures:
1 of 3
Product Name: HIGH STRENGTH THREADLOCKER Item No: 27010
RED GEL 10 GR
7. HANDLING AND STORAGE
Store below 100癋.
Storage:
Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Neoprene or nitrile gloves recommended.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this product.
An approved organic vapor respirator should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Red gel
Appearance:
Mild
Odor:
>150癈
Boiling Point:
Does not apply
pH:
Insoluble
Solubility in Water:
1.11-1.15
Specific Gravity:
<2%
VOC(Wt.%):
Not determined
Vapor Pressure:
>1
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
Will not occur
Hazardous Polymerization:
Strong oxidizers, free radical initiators, inert gases
Incompatabilities:
Heat
Conditions to Avoid:
Oxides of carbon, Irritating vapors
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations..
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Ground Transport (DOT)
Not regulated
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
Not regulated
Proper Shipping:
None
Hazard Class:
None
UN Number:
None
Marine Pollutant:
2 of 3
Product Name: HIGH STRENGTH THREADLOCKER Item No: 27010
RED GEL 10 GR
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
California Proposition 65: No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level
TSCA Inventory Status: All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 1, FLAMMABILITY 1 , REACTIVITY 0.
Estimated NFPA Rating:
HEALTH 1, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: June 21, 2010
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 3
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|