SIGMA-ALDRICH
MATERIAL SAFETY DATA SHEET
Date Printed: 01/10/2008
Date Updated: 01/30/2006
Version 1.3
Section 1 - Product and Company Information
Product Name DIMETHYL SUBERIMIDATE DIHYDROCHLORIDE
Product Number D7636
Brand SIGMA
Company Sigma-Aldrich
Address 3050 Spruce Street
SAINT LOUIS MO 63103 US
Technical Phone: 800-325-5832
Fax: 800-325-5052
Emergency Phone: 314-776-6555
Section 2 - Composition/Information on Ingredient
Substance Name CAS # SARA 313
DIMETHYL SUBERIMIDATE 34490-86-3 No
DIHYDROCHLORIDE
Formula C10H20N2O2.2ClH
Section 3 - Hazards Identification
EMERGENCY OVERVIEW
Irritant.
Irritating to eyes, respiratory system and skin.
For additional information on toxicity, please refer to Section 11.
Section 4 - First Aid Measures
ORAL EXPOSURE
If swallowed, wash out mouth with water provided person is
conscious. Call a physician.
INHALATION EXPOSURE
If inhaled, remove to fresh air.
DERMAL EXPOSURE
Flush skin with water.
EYE EXPOSURE
In case of contact, immediately flush eyes with copious amounts
of water for at least 15 minutes.
Section 5 - Fire Fighting Measures
FLASH POINT
N/A
AUTOIGNITION TEMP
N/A
FLAMMABILITY
N/A
EXTINGUISHING MEDIA
Suitable: Water spray. Carbon dioxide, dry chemical powder, or
appropriate foam.
FIREFIGHTING
Protective Equipment: Wear self-contained breathing apparatus
and protective clothing to prevent contact with skin and eyes.
Specific Hazard(s): Emits toxic fumes under fire conditions.
EXPOSURE HAZARD(S)
Material: Irritant.
Section 6 - Accidental Release Measures
PROCEDURE(S) OF PERSONAL PRECAUTION(S)
Wear respirator, chemical safety goggles, rubber boots, and
heavy rubber gloves.
METHODS FOR CLEANING UP
Sweep up, place in a bag and hold for waste disposal. Avoid
raising dust. Ventilate area and wash spill site after material
pickup is complete.
Section 7 - Handling and Storage
HANDLING
User Exposure: Avoid breathing dust. Avoid contact with eyes,
skin, and clothing.
STORAGE
Suitable: Keep tightly closed. Store in a cool dry place.
SPECIAL REQUIREMENTS
Moisture sensitive.
Section 8 - Exposure Controls / PPE
ENGINEERING CONTROLS
Mechanical exhaust required. Safety shower and eye bath.
PERSONAL PROTECTIVE EQUIPMENT
Respiratory: Use respirators and components tested and approved
under appropriate government standards such as NIOSH (US) or CEN
(EU). Where risk assessment shows air-purifying respirators are
appropriate use a dust mask type N95 (US) or type P1 (EN 143)
respirator.
Hand: Compatible chemical-resistant gloves.
Eye: Chemical safety goggles.
GENERAL HYGIENE MEASURES
Wash thoroughly after handling.
Section 9 - Physical/Chemical Properties
Appearance Color: White
Form: Powder
Property Value At Temperature or Pressure
SIGMA - D7636 www.sigma-aldrich.com Page 2
Molecular Weight 273.2 AMU
pH N/A
BP/BP Range N/A
MP/MP Range 215 癈
Freezing Point N/A
Vapor Pressure N/A
Vapor Density N/A
Saturated Vapor Conc. N/A
SG/Density N/A
Bulk Density N/A
Odor Threshold N/A
Volatile% N/A
VOC Content N/A
Water Content N/A
Solvent Content N/A
Evaporation Rate N/A
Viscosity N/A
Surface Tension N/A
Partition Coefficient N/A
Decomposition Temp. N/A
Flash Point N/A
Explosion Limits N/A
Flammability N/A
Autoignition Temp N/A
Refractive Index N/A
Optical Rotation N/A
Miscellaneous Data N/A
Solubility N/A
N/A = not available
Section 10 - Stability and Reactivity
STABILITY
Conditions of Instability: May decompose on exposure to moist air
or water.
Materials to Avoid: Strong oxidizing agents, Strong bases.
HAZARDOUS DECOMPOSITION PRODUCTS
Hazardous Decomposition Products: Carbon monoxide, Carbon dioxide,
Nitrogen oxides, Hydrogen chloride gas.
Section 11 - Toxicological Information
ROUTE OF EXPOSURE
Inhalation: Material is irritating to mucous membranes and upper
respiratory tract.
Multiple Routes: Causes eye and skin irritation. May be harmful
by inhalation, ingestion, or skin absorption.
SIGNS AND SYMPTOMS OF EXPOSURE
To the best of our knowledge, the chemical, physical, and
toxicological properties have not been thoroughly investigated.
Section 12 - Ecological Information
No data available.
Section 13 - Disposal Considerations
APPROPRIATE METHOD OF DISPOSAL OF SUBSTANCE OR PREPARATION
SIGMA - D7636 www.sigma-aldrich.com Page 3
Dissolve or mix the material with a combustible solvent and burn
in a chemical incinerator equipped with an afterburner and
scrubber. Observe all federal, state, and local environmental
regulations.
Section 14 - Transport Information
DOT
Proper Shipping Name: None
Non-Hazardous for Transport: This substance is
considered to be non-hazardous for transport.
IATA
Non-Hazardous for Air Transport: Non-hazardous for air
transport.
Section 15 - Regulatory Information
EU ADDITIONAL CLASSIFICATION
Symbol of Danger: Xi
Indication of Danger: Irritant.
R: 36/37/38
Risk Statements: Irritating to eyes, respiratory system and skin.
S: 26-36
Safety Statements: In case of contact with eyes, rinse
immediately with plenty of water and seek medical advice. Wear
suitable protective clothing.
US CLASSIFICATION AND LABEL TEXT
Indication of Danger: Irritant.
Risk Statements: Irritating to eyes, respiratory system and skin.
Safety Statements: In case of contact with eyes, rinse
immediately with plenty of water and seek medical advice. Wear
suitable protective clothing.
UNITED STATES REGULATORY INFORMATION
SARA LISTED: No
CANADA REGULATORY INFORMATION
WHMIS Classification: This product has been classified in
accordance with the hazard criteria of the CPR, and the MSDS
contains all the information required by the CPR.
DSL: No
NDSL: Yes
Section 16 - Other Information
DISCLAIMER
For R&D use only. Not for drug, household or other uses.
WARRANTY
The above information is believed to be correct but does not
purport to be all inclusive and shall be used only as a guide. The
information in this document is based on the present state of our
knowledge and is applicable to the product with regard to
appropriate safety precautions. It does not represent any
guarantee of the properties of the product. Sigma-Aldrich Inc.,
shall not be held liable for any damage resulting from handling or
from contact with the above product. See reverse side of invoice
or packing slip for additional terms and conditions of sale.
Copyright 2007 Sigma-Aldrich Co. License granted to make unlimited
paper copies for internal use only.
SIGMA - D7636 www.sigma-aldrich.com Page 4
|