Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: SURFACE INSENSITIVE THREADLOCKER BLUE 6ML
Item No: 24027
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH TLV: TWA OSHA PEL:
POLYGLYCOL DIMETHACRYLATE 50-70 Not listed Not Listed
25852-47-5
TETRAETHYLENE GLYCOL 10-20 Not listed Not Listed
HEXOATE
18268-70-7
POLYVINYL ACETATE <5 Not listed Not Listed
9003-20-7
POLYETHYLENE HOMOPOLYMER <5 Not listed Not Listed
9002-88-4
PROPYLENE GLYCOL <5 Not listed Not Listed
57-55-6
DIMETHYLBENZYL <2 Not listed Not Listed
HYDROPEROXIDE
80-15-9
10mg/m3 nuisance dust
SACCHARIN <2 Not Listed
81-07-2
10 ppm TWA; 30 mg/m3 TWA
ACRYLIC ACID 0.1-1.0 2 ppm TWA
79-10-7
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. At elevated temperatures may cause irritation of the respiratory tract.
Toxicity:
Irritates mucous membranes. Ingestion may irritate digestive tract and cause nausea, vomiting and
diarrhea. High concentrations may cause central nervous system (CNS) depression. May cause skin
sensitization.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. Ingestion may cause nausea and vomiting.
Signs and Symptoms of Exposure:
Inhalation overexposure may cause irritation, coughing and flu-like symptoms. May cause pain, redness
or swelling of the eyes and excessive blinking and tear production.
Component Weight% NTP ACGIH Carcinogens IARC
POLYVINYL ACETATE <5 Group 3: Vol.19, Supp 7;
9003-20-7 1987
SACCHARIN <2 Delisted April 2000 Group 3: Vol 73, 1999
81-07-2
ACRYLIC ACID 0.1-1.0 A4 - Not Classifiable Group 3 Monograph 71,
79-10-7 as a Human 1999; Supplement 7, 1987;
Carcinogen Monograph 19, 1979
May aggrevate preexisting dermatitis.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
1 of 3
Product Name: SURFACE INSENSITIVE Item No: 24027
THREADLOCKER BLUE 6ML
5. FIRE FIGHTING MEASURES
>200癋 PMCC
Flash Point (癋/C):
Water fog, carbon dioxide, foam, dry chemical.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Oxides of carbon
Hazardous Products of Combustion:
Closed containers may rupture or explode when exposed to extreme heat
Unusual Fire/Explosion Hazards:
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store below 100 degrees F.
Storage:
Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Neoprene or nitrile gloves recommended.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved organic vapor respirator should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Blue liquid
Appearance:
MILD
Odor:
>300癋
Boiling Point:
Does not apply
pH:
Insoluble
Solubility in Water:
1.00-1.15
Specific Gravity:
<3%
VOC Content(Wt.%):
Not determined
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
Will not occur.
Hazardous Polymerization:
Strong oxidizers, free radical initiators, inert gases, Peroxides
Incompatabilities:
Heat
Conditions to Avoid:
Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
2 of 3
Product Name: SURFACE INSENSITIVE Item No: 24027
THREADLOCKER BLUE 6ML
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 1.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: April/22/2008
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 1
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.: