24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
MATERIAL SAFETY DATA SHEET
SECTION I - MATERIAL AND MANUFACTURER IDENTIFICATION
Manufacturer's Name: ChemtrecEmergency Telephone No.: 800-424-9300
JEEN INTERNATIONAL CORPORATION Chemtrec International Telephone No.: 703-527-3887 (Collect Calls
Accepted)
24 MADISON ROAD
FAIRFIELD, NJ 07004 (973) 439-1401
Material: Date Issued:
JEEMATE 400 DL 11/20/92 - Rev.
CAS Number: Formula:
Mixture Mixture
Supercedes: DOT Shipping Name:
09/03/86 Not Regulated
DOT Hazard Classification: DOT Label:
Non-Hazardous None
Chemical Name: Polyethylene glycol dicocoate; PEG-8 dilaurate (CTFA name);
Polyethylene glycol 400 dilaurate
SECTION II - INGREDIENTS
APPROXIMATE
WEIGHT% TWA/TLV
Polyethylene glycol dicoate
(CAS #68139-91-3): 85 NONE ESTABLISHED
Polyethylene glycol monococoate
(CAS #61791-29-5): 15 NONE ESTABLISHED
Polyethylene glycol (CAS #25322-68-3): 2 NONE ESTABLISHED
Coco fatty acid (CAS #61788-47-4): 2 NONE ESTABLISHED
SECTION III - PHYSICAL DATA
APPEARANCE: YELLOW LIQUID
VISCOSITY: NOT KNOWN
BOILING POINT: NOT KNOWN
VAPOR DENSITY (AIR=1): NOT APPLICABLE
PERCENT VOLATILE
BY WEIGHT: <0.5 (WATER)
EVAPORATION RATE
(BUTYL ACETATE=1): NOT APPLICABLE
pH 4 (5% SOLUTION)
ODOR: MILD FATTY
MELTING OR FREEZING POINT: NOT KNOWN
VAPOR PRESSURE (mm Hg): NOT APPLICABLE
SOLUBILITY IN WATER: DISPERSIBLE
SPECIFIC GRAVITY (H20=1)
@25oC: 0.99
SECTION IV - FIRE AND EXPLOSION INFORMATION
249oC (COC)
FLASH POINT:
EXTINGUISHING MEDIA: FOAM, WATER, DRY CHEMICAL, CO2
SPECIAL FIRE FIGHTING
PROCEDURES: MUST WEAR MSHA/NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS AND PROTECTIVE CLOTHING. COOL FIRE-EXPOSED
CONTAINERS WITH WATER SPRAY.
UNUSUAL FIRE AND EXPLOSION
HAZARDS: PRODUCTS OF COMBUSTION ARE TOXIC. TREAT AS HOT OIL OR FAT. IF WATER
MUST BE USED, USE A FOG NOZZLE TO AVOID SPATTERING OF HOT MATERIAL
AND SPREAD OF BURNING LIQUID.
AUTO IGNITION TEMPERATURE: NOT KNOWN
UPPER EXPLOSION LIMIT (%): NOT APPLICABLE
JEEMATE 400 DL PAGE 1 OF 4
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
SECTION V - HEALTH EFFECTS INFORMATION
PRIMARY ROUTES OF ENTRY: SKIN CONTACT AND EYE CONTACT
EFFECTS OF OVEREXPOSURE: BASED UPON THE RESULTS OF ANIMAL TOXICITY STUDIES, IT IS ANTICIPATED THAT
DIRECT SKIN AND EYE CONTACT MAY PRODUCE MILD IRRITATION. NO
INFORMATION IS AVAILABLE ON HUMAN OVEREXPOSURE.
EMERGENCY AND
FIRST AID PROCEDURES: EYES: FLUSH EYES WITH PLENTY OF WATER FOR SEVERAL MINUTES.
SEEK MEDICAL ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.
SKIN: WASH AFFECTED AREAS WITH PLENTY OF WATER, AND SOAP IF
AVAILABLE, FOR SEVERAL MINUTES. SEEK MEDICAL ATTENTION IF IRRITATION
DEVELOPS.
INGESTION: IF SWALLOWED, RINSE OUT MOUTH AND DRINK 2-3 GLASSES OF
WATER. SEEK MEDICAL ATTENTION IF DISCOMFORT OR OTHER SYMPTOMS
DEVELOP.
INHALATION: IF SIGNIFICANT QUANTITIES ARE INHALED, REMOVE FROM AREA
TO FRESH AIR. SEEK MEDICAL ATTENTION IF DISCOMFORT OR OTHER
SYMPTOMS DEVELOP.
CHEMICALS LISTED AS CARCINOGEN BY:
NATIONAL TOXICOLOGY PROGRAM: NO
I.A.R.C. MONOGRAPHS: NO
OSHA: NO
SECTION VI - REACTIVITY INFORMATION
STABILITY: STABLE
CONDITIONS TO AVOID: NONE KNOWN
HAZARDOUS DECOMPOSITION
PRODUCTS: THERMAL DECOMPOSITION MAY PRODUCE TOXIC ORGANIC VAPORS/FUMES
AND OXIDES OF CARBON, NITROGEN AND SULFUR.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
CONDITIONS TO AVOID: NONE KNOWN
INCOMPATIBILITY
(MATERIALS TO AVOID): STRONG OXIDIZING AGENTS, ACIDS OR BASES.
SECTION VII - SPILL AND DISPOSAL INFORMATION
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
CAUTION! FLOORS MAY BECOME SLIPPERY. WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND NIOSH/MSHA
APPROVED RESPIRATOR WHERE MIST OR VAPORS OF UNKNOWN CONCENTRATIONS MAY BE GENERATED
(SELF-CONTAINED BREATHING APPARATUS PREFERRED).
DIKE AND CONTAIN SPILL WITH INERT MATERIAL (SAND, EARTH, ETC.) AND TRANSFER THE LIQUID
AND SOLID SEPARATELY TO CONTAINERS FOR RECOVERY OR DISPOSAL. KEEP SPILL OUT OF
SEWERS AND OPEN BODIES OF WATER.
WASTE DISPOSAL METHOD:
DISPOSE OF IN COMPLIANCE WITH ALL FEDERAL, STATE, AND LOCAL LAWS AND REGULATIONS. INCINERATION
IS THE PREFERRED METHOD.
JEEMATE 400 DL PAGE 2 OF 4
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
SECTION VIII- PERSONAL PROTECTION INFORMATION
VENTILATION TYPE:
IN PROCESSES WHERE MISTS OR VAPORS MAY BE GENERATED, PROPER VENTILATION MUST BE PROVIDED IN
ACCORDANCE WITH GOOD VENTILATION PRACTICES.
RESPIRATORY PROTECTION:
WHERE MIST OR VAPORS ARE GENERATED BY THE PROCESS, A NIOSH/MSHA JOINTLY APPROVED RESPIRATOR
IS ADVISED IN THE ABSENCE OF PROPER ENVIRONMENTAL CONTROLS.
PROTECTIVE GLOVES:
RUBBER OR NEOPRENE, WHEN NEEDED, TO PREVENT SKIN CONTACT.
EYE PROTECTION:
WEAR CHEMICAL SPLASH GOGGLES WHERE THERE IS A POTENTIAL FOR EYE CONTACT. USE SAFETY GLASSES
WITH SIDE SHIELDS UNDER NORMAL USE CONDITIONS.
OTHER PROTECTIVE EQUIPMENT:
EYE WASH; SAFETY SHOWER; PROTECTIVE CLOTHING (LONG SLEEVES, COVERALLS OR OTHER, AS
APPROPRIATE), WHEN NEEDED, TO PREVENT SKIN CONTACT.
SECTION IX - STORAGE AND HANDLING
PRECAUTIONS TO BE TAKEN IN STORAGE AND HANDLING:
KEEP CONTAINERS CLOSED UNTIL USED. TO MAINTAIN PRODUCT QUALITY, DO NOT STORE IN HEAT OR DIRECT
SUNLIGHT.
SECTION X - TOXICOLOGY INFORMATION
* ORAL LD50 (RAT): GREATER THAN 5000mg/kg
* EYE IRRITATION (RABBIT): MILD IRRITANT. (PRIMARY IRRITATION INDEX = 2; IRRITATION CLEARED BY DAY
2, POST DOSE.)
* SKIN IRRITATION (RABBIT): MILD IRRITANT
SECTION XI - MISCELLANEOUS AND REGULATORY INFORMATION
FEDERAL LEVEL REGULATIONS:
TOXIC SUBSTANCES CONTROL ACT (TSCA INVENTORY) STATUS:
FOUND ON U.S. EPA TSCA INVENTORY.
CERCLA (COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY ACT OF 1980
REQUIRES NOTIFICATION OF THE NATIONAL RESPONSE CENTER (TELEPHONE 1-800-424-8802) IN THE EVENT OF
A RELEASE OF QUANTITIES OF THE FOLLOWING HAZARDOUS MATERIALS CONTAINED IN THIS PRODUCT, IF THE
RELEASE IS EQUAL TO OR GREATER THAT THE REPORTABLE QUANTITIES (RQs) LISTED IN 40 CFR 302.4:
TYPICAL MAXIMUM
CHEMICAL NAME CAS NUMBER CONCENTRATION
NONE KNOWN - -
SARA TITLE III, SECTIONS 302/304 (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986):
THIS ACT REQUIRES EMERGENCY PLANNING, INCLUDING AGENCY NOTIFICATION, FOR POSSIBLE RELEASE OF
THE FOLLOWING COMPONENTS OF THIS MATERIAL, BASED UPON THE THRESHOLD PLANNING QUANTITIES
(TPQs) AND RELEASE REPORTABLE QUANTITIES (RQs) LISTED FOR THE COMPONENTS IN 40 CFR 355:
TYPICAL MAXIMUM
CHEMICAL NAME CAS NUMBER CONCENTRATION
NONE KNOWN - -
SARA TITLE III, SECTIONS 311/312 -
THIS ACT REQUIRES REPORTING UNDER THE COMMUNITY RIGHT-TO-KNOW PROVISIONS DUE TO THE
INCLUSION OF THE FOLLOWING COMPONENTS OF THIS MATERIAL IN ONE OR MORE OF THE FIVE HAZARD
CATEGORIES LISTED IN 40 CFR 370:
JEEMATE 400 DL PAGE 3 OF 4
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
HAZARD *)
CHEMICAL NAME CAS NUMBER CONCENTRATION
NONE KNOWN - -
*) THE FIVE HAZARD CATEGORIES ARE AS FOLLOWS: F=FIRE HAZARD; S=SUDDEN RELEASE OF PRESSURE;
R=REACTIVE; A=IMMEDIATE (ACUTE) HEALTH HAZARD; C=DELAYED (CHRONIC) HEALTH HAZARD.
SARA TITLE 313-
THIS ACT REQUIRES SUBMISSION OF ANNUAL REPORTS OF RELEASES OF THE FOLLOWING COMPONENTS OF
THIS MATERIAL IF THE THRESHOLD REPORTING QUANTITIES, AS LISTED IN 40 CFR 372, ARE MET OR EXCEEDED:
TYPICAL MAXIMUM
CHEMICAL NAME CAS NUMBER CONCENTRATION
NONE KNOWN - -
STATE RIGHT-TO-KNOW REGULATIONS:
CALIFORNIA PROPOSITION 65-
COMPONENTS PRESENT IN THIS MATERIAL WHICH THE STATE OF CALIFORNIA HAS FOUND TO CAUSE CANCER,
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM AS FOLLOWS:
TYPICAL MAXIMUM
CHEMICAL NAME CAS NUMBER CONCENTRATION
Acetaldehyde 75-07-0 1 PPM
1, 4-Dioxane 123-91-1 10 PPM
Ethylene oxide 75-21-8 1 PPM
MASSACHUSETTS RIGHT-TO-KNOW-
THE FOLLOWING COMPONENTS OF THIS MATERIAL ARE INCLUDED IN THE MASSACHUSETTS SUBSTANCE LIST
AND ARE PRESENT AT OR ABOVE REPORTABLE LEVELS:
TYPICAL MAXIMUM
CHEMICAL NAME CAS NUMBER CONCENTRATION
Acetaldehyde 75-07-0 1 PPM
1, 4-Dioxane 123-91-1 10 PPM
Ethylene oxide 75-21-8 1 PPM
MICHIGAN CRITICAL MATERIALS-
THE FOLLOWING COMPONENTS OF THIS MATERIAL ARE INCLUDED IN THE MICHIGAN CRITICAL MATERIALS LIST:
TYPICAL MAXIMUM
CHEMICAL NAME CAS NUMBER CONCENTRATION
NONE KNOWN - -
NEW JERSEY RIGHT-TO-KNOW-
THE FOLLOWING COMPONENTS OF THIS MATERIAL ARE INCLUDED IN THE NEW JERSEY HAZARDOUS
SUBSTANCE LIST AND ARE PRESENT AT OR ABOVE REPORTABLE LEVELS:
TYPICAL MAXIMUM
CHEMICAL NAME CAS NUMBER CONCENTRATION
NONE KNOWN - -
PENNSYLVANIA RIGHT-TO-KNOW-
THE FOLLOWING COMPONENTS OF THIS MATERIAL ARE INCLUDED IN THE PENNSYLVANIA HAZARDOUS
SUBSTANCE LIST AND ARE PRESENT AT OR ABOVE REPORTABLE LEVELS:
TYPICAL MAXIMUM
CHEMICAL NAME CAS NUMBER CONCENTRATION
NONE KNOWN - -
THE INFORMATION PROVIDED HEREIN IS COMPLIED FROM INTERNAL REPORTS AND DATA FROM PROFESSIONAL PUBLICATIONS. IT IS
FURNISHED WITHOUT WARRANTY OF ANY KIND, EXPRESSED OR IMPLIED. IT IS INTENDED TO ASSIST IN EVALUATING THE SUITABILITY
AND PROPER USE OF THE MATERIAL IN MANUFACTURING AND IN THE DEVELOPMENT AND IMPLEMENTATION OF SAFETY PRECAUTIONS
AND PROCEDURES.
JEEMATE 400 DL PAGE 4 OF 4
|