PRODUCT NAME: SOLUTION 625 BELT DRESSING HMIS CODES: H F R P
PRODUCT NAME: SOLUTION 625 BELT DRESSING HMIS CODES: H F R P
PRODUCT CODE: VIA-0037-003 1 2 0
================== SECTION I - DISTRIBUTOR IDENTIFICATION ==================
DISTRIBUTOR'S NAME : MRO SOLUTIONS
ADDRESS : 5645 W. HOWARD
NILES, IL 60714
EMERGENCY PHONE : 1-800-424-9300 DATE PREPARED : 09/24/2004
INFORMATION PHONE : 1-847-588-2480 NAME OF PREPARER : ESP
========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION =========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mm Hg @ TEMP PERCENT
--------------------------------------------------------------------------------
HEPTANE 142-82-5 40 72 45
OSHA PEL: 400 PPM, ACGIH TLV: 400 PPM
PROPANE 74-98-6 6350 68 20
OSHA PEL: 1000 PPM, ACGIH TLV: ASPHYXIANT
BUTANE 106-97-8 1640 68 20
OSHA PEL: 800 PPM, ACGIH TLV: 800 PPM
*** No toxic chemical(s) subject to the reporting requirements of section
313 of
Title III and of 40 CFR 372 are present. ***
=============== SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS ============
http://mrosolutions.com/msdsfils/sol0625.htm (1 of 4)7/17/2008 4:22:43 AM
PRODUCT NAME: SOLUTION 625 BELT DRESSING HMIS CODES: H F R P
BOILING RANGE: -44 deg F - 208 deg F SPECIFIC GRAVITY (H2O=1): 0.65
VAPOR DENSITY: HEAVIER THAN AIR EVAPORATION RATE: SLOWER THAN ETHER
SOLUBILITY IN WATER: NIL APPEARANCE AND ODOR: AEROSOL PRODUCT
================= SECTION IV - FIRE AND EXPLOSION HAZARD DATA ==============
FLASH POINT: -156 deg F METHOD USED: ESTIMATED
FLAMMABLE LIMITS IN AIR BY VOLUME: LOWER: 1.2 UPPER: 9.5
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES: WATER SPRAY MAY BE INEFFECTIVE. WATER MAY
BE USED TO COOL CONTAINERS TO PREVENT PRESSURE BUILD-UP AND EXPLOSION WHEN
EXPOSED TO EXTREME HEAT. IF WATER IS USED, FOG NOZZLES PREFERRED. WEAR
GOGGLES AND SELF-CONTAINED BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS: CLOSED CONTAINERS MAY EXPLODE FROM
INTERNAL PRESSURE BUILD-UP WHEN EXPOSED TO EXTREME HEAT AND DISCHARGE
CONTENTS. VAPOR ACCUMULATION CAN FLASH OR EXPLODE IF IGNITED. OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY NOT BE
READILY APPARENT. OBTAIN MEDICAL ATTENTION.
======================== SECTION V - REACTIVITY DATA =======================
STABILITY: STABLE
CONDITIONS TO AVOID: APPLICATION TO HOT SURFACES. STORAGE ABOVE 120 DEG F.
EXPOSURE TO OPEN FLAME.
INCOMPATIBILITY (MATERIALS TO AVOID): STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE AND OTHER TOXIC FUMES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
==================== SECTION VI - HEALTH HAZARD DATA =======================
http://mrosolutions.com/msdsfils/sol0625.htm (2 of 4)7/17/2008 4:22:43 AM
PRODUCT NAME: SOLUTION 625 BELT DRESSING HMIS CODES: H F R P
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: RESPIRATORY IRRITATION,
HEADACHE, NAUSEA, FATIGUE, DROWSINESS, IMPAIRED CO-ORDINATION.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE: SKIN: CONTACT
MAY DRY THE SKIN; PROLONGED CONTACT MAY CAUSE MODERATE IRRITATION. EYES:
LIQUID OR VAPOR CAN CAUSE MODERATE TO SEVERE IRRITATION.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: NOT EASILY ABSORBED.
SOLVENT ACTION CAN DRY AND DEFAT THE SKIN CAUSING THE SKIN TO CRACK,
LEADING TO DERMATITIS.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: NOT A LIKELY ROUTE OF
EXPOSURE. IF SWALLOWED, SEEK IMMEDIATE MEDICAL ADVICE AND/OR ATTENTION.
HEALTH HAZARDS (ACUTE AND CHRONIC): ACUTE: EYE IRRITANT. POSSIBLE SKIN
IRRITANT.
CHRONIC: NONE KNOWN.
CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: No OSHA REGULATED: No
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: NONE KNOWN.
EMERGENCY AND FIRST AID PROCEDURES: INHALATION: REMOVE TO FRESH AIR.
ADMINISTER OXYGEN IF NEEDED. APPLY ARTIFICIAL RESPIRATION IF BREATHING HAS
STOPPED. GET MEDICAL ATTENTION. SKIN: WIPE OFF WITH TOWEL. WASH WITH SOAP
AND WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS. EYES: WASH
IMMEDIATELY WITH LARGE VOLUMES OF FRESH WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION.
=========== SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE ============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: AVOID BREATHING
VAPORS. VENTILATE AREA. REMOVE ALL SOURCES OF IGNITION. CLEAN UP AREA WITH
ABSORBENT MATERIAL AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
WASTE DISPOSAL METHOD: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. BEFORE ATTEMPTING CLEAN UP, REFER TO OTHER SECTIONS OF
THIS MSDS FOR HAZARD CAUTION INFORMATION.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: STORE AND USE IN COOL,
DRY, WELL-VENTILATED AREAS. DO NOT STORE ABOVE 120 DEG F. DO NOT PUNCTURE
OR INCINERATE (BURN) CANS. DO NOT STICK PIN, NAIL OR ANY OTHER SHARP OBJECT
INTO OPENING ON TOP OF CAN. DO NOT SPRAY IN EYES. DO NOT TAKE INTERNALLY.
http://mrosolutions.com/msdsfils/sol0625.htm (3 of 4)7/17/2008 4:22:43 AM
PRODUCT NAME: SOLUTION 625 BELT DRESSING HMIS CODES: H F R P
SEE PRODUCT LABEL FOR ADDITIONAL INFORMATION.
OTHER PRECAUTIONS: THE STORAGE OF NON-FLAMMABLE PRODUCTS WITH NON-FLAMMABLE
OF FLAMMABLE
PRESSURIZING AGENT, IN CARTONS, IS THE SAME AS FOR ORDINARY CANNED GOODS IN
CARTONS.
RESPIRATORY PROTECTION: NONE UNDER NORMAL USE. AVOID BREATHING VAPORS. IN
RESTRICTED AREAS, USE APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO
REMOVE A COMBINATION OF PARTICLES AND VAPOR. IN CONFINED AREAS, USE
APPROVED AIR LINE TYPE RESPIRATOR OR HOOD. SELF-CONTAINED BREATHING
APPARATUS IS REQUIRED FOR VAPOR CONCENTRATIONS ABOVE PEL/TLV LIMITS.
VENTILATION: SUFFICIENT TO PREVENT INHALATION OF SOLVENT VAPORS. GENERAL
DILUTION AND/OR
LOCAL EXHAUST VENTILATION IN VOLUME OR PATTERN TO KEEP PEL/TLV OF MOST
HAZARDOUS INGREDIENT BELOW ACCEPTABLE LIMIT AND LEL BELOW STATED LIMIT.
PROTECTIVE GLOVES: NONE UNDER NORMAL USE. SOLVENT RESISTANT REQUIRED FOR
PROLONGED OR REPEATED CONTACT.
EYE PROTECTION: NONE UNDER NORMAL USE; HOWEVER, USE OF SAFETY GLASSES WITH
SPLASH GUARDS OR FULL FACE SHIELD IS RECOMMENDED.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: NONE UNDER NORMAL USE; HOWEVER, USE
OF SOLVENT RESISTANT APRONS OR OTHER CLOTHING IS RECOMMENDED.
WORK/HYGIENIC PRACTICES: EYE WASHES AND SAFETY SHOWERS IN THE WORKPLACE ARE
RECOMMENDED.
========================= SECTION IX - DISCLAIMER ==========================
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE.
HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE
DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF. BECAUSE THE
INFORMATION CONTAINED HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR
CONTROL, WE ASSUME NO RESPONSIBILITY FOR ITS USE.
http://mrosolutions.com/msdsfils/sol0625.htm (4 of 4)7/17/2008 4:22:43 AM
|