MATERIAL SAFETY DATA SHEET
GM FOAM ULTRA-STRETCH BALLOON RUBBER
SECTION I--Preparation/Product Information
MANUFACTURED FOR AND SUPPLIED BY: TELEPHONE NO: (818) 908-1087
GM Foam, Inc DATE PREPARED: July 11, 2001
14956 Delano St. PREPARED BY: GM Foam, Inc
Van Nuys, CA 91411 PRODUCT USE: Latex Compound
DATE PRINTED: July 11, 2001
EMERGENCY CONTACT: (818) 908-1087
SECTION II ?Ingredients/Identity Information
HMIS HAZARD CODES
NAME: Latex Compound Health: 1
CLASS: Modified Natural Rubber Latex Flammability: 0
Reactivity: 0
Personal Protective Equipment: X
COMPONENTS EXPOSURE LIMITS TOXICITY
CHEMICAL IDENTITY CAS#/UN# PEL / TLV / OTHER LD50 / LC50
Zinc Oxide 1314-13-2 N/A N/A
TLV 2.0mg/m3
Potassium Hydroxide, KOH 1310-58-3 LD50rat/oral
*365mg/kg
PEL 50mg/m3, TLV 15.mg/m3
Ammonium Hydroxide 1336-21-6 N/A
PPM 25.mg/m3
SECTION III ?Physical / Chemical Characteristics
BOILING POINT: >212篎 SPECIFIC GRAVITY (H2O = 1): 1.02
FREEZING POINT: 32篎 pH: Not Available
VAPOR PRESSURE (mm Hg): Ammonium Hydroxide 11.9mmHg@20C
ODOR THRESHOLD (ppm): Not Applicable
VAPOR DENSITY (AIR = 1): Lighter than air COEF. WATER/OIL DIST.: Not Applicable
SOLUBILITY IN WATER: 10-99.99% EVAPORATION RATE: Slower
APPEARANCE (PHYSICAL STATE) AND ODOR: Natural liquid, mild ammonia odor
% VOLATILE BY VOLUME: 27.94% (relative to n-butyl acetate)
SECTION IV ?Fire and Explosion Hazard Data
FLAMMABILITY CLASSIFICATION:
OSHA: Not Available
DOT: Not Regulated for flammability
EXTINGUISHING MEDIA: Carbon dioxide, dry chemical, foam
GM FOAM ULTRA-STRETCH BALLOON RUBBER ?PAGE 1
SPECIAL FIRE FIGHTING PROCEDURES: Fire fighters should wear full protective clothing to guard against exposure to toxic and
irritating fumes. Fire fighters should wear self-contained breathing apparatus with a full facepiece operated in a positive pressure mode.
UNUSUAL FIRE ANS EXPLOSION HAZADS: Do not weld or use cutting torch on or near drums, even if empty. Empty drums contain
residual material which may decompose to emit toxic or irritating fumes if burned.
FLAMABLE LIMITS LEL: Not Determined
UEL: Not Determined
AUTOIGNITION TEMPURATURE: Not Determined
SENS. TO MECHANICAL IMPACT: Not Determined
SENS. TO STATIC DISCHARGE: Not Determined
HAZARDOUS COMBUSTION PRODUCTS: Not Available
SECTION V ?Reactivity Data
SABILITY:
Stable X
Unstable
CONDITIONS TO AVOID (Condition of Reactivity): None.
INCOMPATIBILITY (Materials to Avoid): Strong oxidizing agents. Liquid potassium hydroxide is a strong base ?Avoid contact with
acids.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: CO, CO2. If dry rubber is heated or ignited, poisonous fumes and smoke will be
emitted.
HAZARDOUS POLYMERIZATION: Will not occur
POLYMERIZATION CONDITIONS TO AVOID: None
SECTION VI ?Health Hazard Data
PRI MARY ROUTE OF EXPOSURE:
Inhalation: X Skin Contact: X
Skin Absorption: Ingestion:
Eye Contact:
HEALTH HAZARDS:
Acute: None Known
Chronic: None Known
CARCINOGENICITY:
NTP: No IARC: No OSHA: No
SIGNS AND SYMPTOMS OF EXPOSURE: None Known
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: None Known
OECD TEST VALUE FOR:
Irritancy: Not Determined Reproductive Toxicity: Not Determined
GM FOAM ULTRA-STRETCH BALLOON RUBBER ?PAGE 2
Sensitization: Not Determined Teratogenicity: Not Determined
Mutagenicity: Not Determined
SYNERGISTIC PRODUCTS: Not Determined
HMIS RATING: 0
SECTION VII ?First Aid Measures
EMERGENCY AND FIRST AID PROCEDURES
Inhalation: Move to fresh air
Ingestion: Consult a physician
Skin Contact: Wash with soap and water.
Eye Contact: Flush with water for 15 minutes. If irritation persists, consult a physician.
SECTION VIII ?Precautions for Safe Handling and Use
Steps to be taken in case material is released or spilled:
Properly protected personnel should contain the spill. Soak it up with absorbent material. Shovel the absorbed material into
containers for disposal.
Waste Disposal Method:
In accordance with all Federal, State and Local regulations. Empty containers retain product residue and are subject to all of
the handling instructions on this sheet
Precautions to be taken in handling and storing:
Avoid contact with eyes, skin and clothing. Do not store near moisture and air.
Other Precautions:
None Known
SECTION IX ?Control Measures
Respiratory Protection Specify Type): If ventilation is inadequate, wear an appropriate respirator to prevent overexposure.
VENTILATION: Good room ventilation. Provide mechanical or local exhaust during baking to prevent fumes from accumulating.
EYE PROTECTION: Chemical Safety Glasses or splash goggles to prevent eye contact.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: If needed to prevent unnecessary skin contact.
ROUTES OF ENTRY: Skin contact, inhalation
SECTION X ?Special Precautions
HANDLING AND STORAGE PRECAUTIONS:
Avoid unnecessary skin contact with this product. Avoid breathing vapors. Provide adequate ventilation during use.
GM FOAM ULTRA-STRETCH BALLOON RUBBER ?PAGE 3
OTHER PRECAUTIONS:
Store in a cool, dry location. Keep containers tightly sealed and upright when not in use. Keep from freezing.
SECTION XI ?Additional Information
SPECIAL SHIPPING INFORMATION:
DOT SHIPPING NAME: Natural rubber latex
HAZARD CLASS: UN/NA
SARA TITLE III REGULATORY INFORMATION:
Section 302 ?Extremely Hazardous Substances: does not contain
Section 311/312 ?Categories for Tier I & Tier II reporting:
______Fire __X__Immediate (acute) Health ______Reactivity
______Delayed (chronic) Health ______Sudden Release of Pressure
Section 313 ?Emissions reporting: All product ingredients with "yes" in the "Listed?" column are subject to the reporting
requirements of Section 313. EPA lists chemical name & CAS# or by chemical category. This information must accompany all
copies of this MSDS.
CHEMICAL CAS# LISTED %
Zinc Oxide 1314-13-2 No 1-5
contains: zinc compounds -------------- Yes -----
Potassium Hydroxide, KOH 1310-38-3 No 1-5
Ammonium Hydroxide 1336-21-6 No <1
CALIFORNIA PROPOSITION 65:
This product is not known to contain any listed chemicals.
THE INFORMATION AND RECOMMENDATIONS CONTAINED HEREIN ARE BASED UPON DATA THAT IS ACCURATE AND
RELIABLE TO THE BEST OF GM FOAM'S KNOWLEDGE AND BELIEF. WITH RESPECT TO THE INFORMATION AND
RECOMMENDATIONS, GM FOAM MAKES NO REPRESENTATIONS OR WARRANTIES OF ANY KIND OR NATURE, EXPRESS
OR IMPLIED.
This Adobe Portable Document Format file was created from GM Foam, Inc's original Material Safety
Data Sheet word document files by Cybergraphic Designs, Inc. for use on the Cybergraphic Designs, Inc.
Makeup Effects & Supply website. Please visit us on the web to download other useful MSDS PDF files.
http://www.getspfx.com
GM FOAM ULTRA-STRETCH BALLOON RUBBER ?PAGE 4
|