MATERIAL SAFETY DATA SHEET
LABORATORIES 320 37th Avenue ?St. Charles, Illinois 60174 ?To Reorder, Call 800-323-2594
PRODUCT IDENTIFICATION USE / DESCRIPTION REVISION DATE FOR MEDICAL AND
UNITED 132 Aerosol PVC Purple Primer November 4, 2004 TRANSPORTATION EMERGENCIES:
AERO-WELD INFOTRAC: 800-535-5053
HEALTH (0 = Maximum Safety) REACTIVITY (0 = Maximum Safety)
Always follow Label Directions and Cautions. Susceptible to Release of Energy.
Extreme. High. Moderate. Slight. Minimal.
4 3 2 1 0 May detonate-vacate area if Violent chemical change
Materials are exposed to fire. possible-use hose stream
See Health Hazard Data Section of this M.S.D.S.
Strong shock of heat may from distance
for more detailed information. detonate-use monitors from Unstable if heated-use
behind explosion resistant precaution.
FLAMMABILITY (0 = Maximum Safety) barriers. Normally stable.
Susceptibility of Material to Burning.
Extremely flammable. Must be preheated to burn.
Ignites at normal temperature. Will not burn.
Ignites when moderately heated.
IDENTITY, EXPOSURE LIMITS AND S.A.R.A. TITLE III INFORMATION
HAZARDOUS CAS ACGIH ACGIH OSHA OTHER S.A.R.A. TITLE III
COMPONENTS NUMBER TWA STEL PEL RECOMMENDED LIMITS QUANTITIES
Acetone 67-64-1 500 ppm 750 ppm 1000 ppm NIOSH TWA None
1188 mg/m 3 1782 mg/m 3 2400 mg/m 3 250 ppm 590mg/m 3
Methyl ethyl ketone 78-93-3 100 ppm NE 100 ppm NE None
Tetrahydrofuran 109-99-9 200 ppm NE 200 ppm NE None
Cyclohexanone 108-94-1 25 ppm NE 25 ppm NE None
Hydrocarbon propane 68-476-86-8 800 ppm NE 800 ppm NE None
PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING POINT SPECIFIC GRAVITY (H20 = 1)
Not determined 0.80
VAPOR PRESSURE (Psig) MELTING POINT
(At 70?F) >60 psi Not determined
VAPOR DENSITY (Air = 1) EVAPORATION RATE
Not determined (Butyl Acetate = 1) Not determined
SOLUBILITY IN WATER VOLATILE ORGANIC COMPOUNDS (V.O.C.)
None (Pounds Per Can Of Product) ND
APPEARANCE AND ODOR pH:
Aerosol spray with characteristic odor Not applicable
FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (Method Used) FLAMMABLE LIMITS LEL UEL
Flammable (TCC) Level 3 Aerosol Propellant ND ND
Foam, dry chemical, carbon dioxide, water
SPECIAL FIRE FIGHTING PROCEDURES
Use water fog to cool containers to prevent rupturing and exploding containers. Provide shielding for personnel.
Firefighters should wear full protective equipment and NIOSH approved self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARDS
Do not expose aerosols to temperatures above 120?F or the container may burst.
PAGE (1) (CONTINUED ON REVERSE SIDE)
STABILITY: STABLE X CONDITIONS TO AVOID
Open flame, welding arcs, heat, sparks
INCOMPATIBILITY (Materials To Avoid)
Strong oxidizing agents
HAZARDOUS DECOMPOSITION OR BY PRODUCTS
Carbon monoxide, carbon dioxide
HAZARDOUS POLYMERIZATION:WILL NOT OCCUR X CONDITIONS TO AVOID
MAY OCCUR X
HEALTH HAZARD DATA
EYES: May cause mild irritation. SKIN: May cause mild irritation or dematitis INHALATION: Excessive inhalation of vapors can cause nasal and
respiratory irritation, dizziness, weakness, nausea, headache, possible unconsciousness, asphyxiation or death.
IF SWALLOWED: Aspiration of material into the lungs during vomiting may cause pulmonary injury
No No No
CARCINOGENICITY: NTP? IARC MONOGRAPHS? OSHA REGULATED?
This product contains a chemical known to the state of California to cause cancer or reproductive toxicity?
SIGNS AND SYMPTOMS OF OVEREXPOSURE
EYES: Irritation SKIN: Irritation due to defatting of skin
INHALATION: Nasal and respiratory irritation, dizziness, weakness, nausea, headache IF SWALLOWED: May cause nausea, vomiting, pneumonitis
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY OVEREXPOSURE
May aggravate existing eye, skin or upper respiratory conditions.
EMERGENCY AND FIRST AID PROCEDURES
EYES: Flush with cool water for at least 15 minutes while holding eyelids open. If irritation persists, call a physician or poison control center.
SKIN: Wash with soap and water. If irritation persists, call a physician or poison control center.
INHALATION: Remove to fresh air. Apply CPR if needed. Call a physician or poison control center.
IF SWALLOWED: DO NOT INDUCE VOMITING. Call a physician or poison control center immediately.
PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
Ventilate area and eliminate all sources of ignition. Contain spill and soak up spilled material with inert absorbent material and place in a properly
labeled closed container for proper disposal.
WASTE DISPOSAL METHOD
Consult local, state and federal authorities for proper disposal guidelines.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Store in a cool (<120癋), dry, well-ventilated area away from sources of ignition.
FOR USE WHERE SIGNIFICANT EYE, SKIN OR INHALATION EXPOSURE IS LIKELY
RESPIRATORY PROTECTION (Specify Type)
If TLV is exceeded, use NIOSH approved respirator to prevent overexposure.
VENTILATION: MECHANICAL (General) LOCAL EXHAUST
Provide adequate ventilation Generally adequate
PROTECTIVE GLOVES EYE PROTECTION
Neoprene or Nitrile rubber gloves Safety glasses or goggles and face shield
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
WORK HYGENIC PRACTICES
Wash hands and face with soap and water after using this product. Remove contaminated clothing and launder before reusing.
UNITED 132 AERO-WELD Aerosol PVC Purple Primer