MATERIAL SAFETY DATA SHEET
Date Prepared: 04/19/04 Page: 1
Skid-No-More MSDS Number: 130014
SECTION 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Material Identity
Product Name: Skid-No-More
Product Numbers: 100851, 100853 and 100854
Product Use: Rubberized Non-Skid Water-Based Coating
Company Emergency Telephone Numbers:
Fibre Glass-Evercoat CHEMTREC: 1-800-424-9300
a Division of Illinois Tool Works Inc. CANUTEC: 1-613-996-6666
6600 Cornell Road
Cincinnati, Ohio USA
Phone: 513-489-7600 Prepared By: Safety Department
SECTION 2. COMPOSITION / INFORMATION ON INGREDIENTS
Ingredient(s) CAS Number EINECS Number % (by weight)
Water 7732-18-5 231-791-2 35 ?40
Resin Proprietary Proprietary 15 ?20
Natural Rubber None None 15 ?20
2-Propenenitrile 9003-18-3 N/L 5 ?10
Talc 14807-96-6 238-877-9 5 ?10
Diethylene Glycol 112-34-5 203-961-6 1?
Monobutyl Ether
Ethylene Glycol 107-21-1 203-473-3 1?
Magnesite 546-93-0 208-915-9 1?
OSHA Regulatory Status: While this material is not classified as hazardous under
OSHA regulations, this MSDS contains valuable information critical to the safe
handling and proper use of the product.
SECTION 3. HAZARDS IDENTIFICATION
***EMERGENCY OVERVIEW***
WARNING! HARMFUL IF SWALLOWED.
CAUSES EYE, NOSE AND THROAT IRRITATION.
Potential Health Effects
Acute Effects (Short Term):
Eye: Contact with liquid or vapor may result in mild irritation, redness,
tearing, and blurred vision.
Skin: May cause mild skin irritation. Symptoms may include redness and
burning of the skin.
MATERIAL SAFETY DATA SHEET
Date Prepared: 04/19/04 Page: 2
Skid-No-More MSDS Number: 130014
Swallowing: Ingestion of this material may cause gastrointestinal irritation,
nausea, diarrhea, and vomiting.
Inhalation: Breathing small amounts of this material during normal handling is
not likely to cause harmful effects.
Chronic Effects of Overexposure (Long Term):
Ethylene Glycol: Overexposure to this material has been suggested as a
cause of the following effects in humans: kidney damage, liver
damage.
Diethylene Glycol Monobutyl Ether: This substance may have effects on the
blood.
Cancer Information: This product does not contain any substance, which is listed as a
carcinogen by NTP, IARC or OSHA in quantities greater than 0.1%. This material
may contain trace amounts of a chemical considered to be carcinogenic by
OSHA (Ethylene Oxide IARC-Group 1, Formaldehyde IARC-Group 2A,
Acrylonitrile IARC-Group 2B and 1,3 Butadiene IARC-Group 2A)
Other Health Effects: None Known
Primary Route(s) of Entry: Inhalation, Skin contact, Eye contact, Ingestion, Skin
absorption.
SECTION 4. FIRST AID MEASURES
Eyes: Flush eyes gently with water for at least 15 minutes. Obtain medical
advise.
Skin: Remove contaminated clothing. Wash exposed area with soap and
water. If symptoms persist, seek medical attention. Launder
clothing before reuse.
Swallowing: If irritation or discomfort occurs, obtain medical advice immediately.
Inhalation: Move individual away from exposure and into fresh air. Obtain
medical advice.
SECTION 5. FIRE FIGHTING MEASURES
Flash Point: Not Determined (Water-Based)
Explosive Limit: Lower: N/A Upper: N/A
Autoignition Temperature: N/A
OSHA Flammability Class: Non-Flammable
Hazardous Products of Combustion: May form: carbon dioxide, carbon
monoxide and various hydrocarbons.
Fire and Explosion Hazards: After water evaporates, remaining material will
burn.
MATERIAL SAFETY DATA SHEET
Date Prepared: 04/19/04 Page: 3
Skid-No-More MSDS Number: 130014
Extinguishing Media: Regular foam, carbon dioxide, dry chemical.
Fire Fighting Instructions: Water may be used to keep fire-exposed containers
cool until fire is out. Wear a self-contained breathing apparatus NIOSH
approved with a full facepiece operated in the positive pressure demand
mode with appropriate turn-out gear and chemical resistant personal
protective equipment.
NFPA Rating: Health - 1, Flammability - 1, Reactivity - 0
SECTION 6. ACCIDENTAL RELEASE MEASURES
In Case of Spill: Wear proper protective equipment (Section 8). Collect with an inert
absorbant and dispose of properly.
SECTION 7. HANDLING AND STORAGE
Handling: All hazard precautions given in the data sheet must be observed. Avoid
contact with eyes, skin and clothing. Wash thoroughly after handling. Do not take
internally. Close container after each use. Keep out of reach of children.
Storage: Store material in a cool, well-ventilated area. For maximum product
quality, avoid prolonged storage at temperatures above 75癋 (25癈). Do not use or
store near heat, sparks, or open flame. Keep container tightly closed. Avoid contact with
incompatible materials.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Eye Protection: Chemical splash goggles in compliance with OSHA regulations are
recommended.
Skin Protection: Protective gloves and proper clothing should be worn to prevent
skin contact. Gloves should be made of polyvinyl chloride. A barrier
cream may be used for additional skin protection. To prevent
repeated or prolonged skin contact, wear impervious clothing and
boots.
Respiratory Protection: Not required if airborne concentrations are maintained below
listed exposure limits.
Engineering Controls: Provide sufficient mechanical (general and/or local exhaust)
ventilation to maintain exposure below acceptable limits.
Exposure Guidelines:
Hazardous Ingredients CAS Number OSHA PEL/TWA ACGIH TLV
2 mg/m3
Talc 14807-96-6 20 mppcf
Ethylene Glycol 107-21-1 N/E 39.4 ppm C
15 mg/m3 10 mg/m3
Magnesite 546-93-0
Mppcf- Millions of particles per cubic foot of air C- Ceiling Limit
MATERIAL SAFETY DATA SHEET
Date Prepared: 04/19/04 Page: 4
Skid-No-More MSDS Number: 130014
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
212 癋/ 100 癈 Heavier than air.
Boiling Point: Vapor Density:
(Water)
1.10/ 9.15 lbs/gal 40 - 45 %
Specific Gravity / Percent Volatiles
Density: by weight:
Slower than ethyl Liquid w/ Rubber
Evaporation Rate: Physical State:
ether. Particles
32 癋 / 0 癈 N/D
Freezing Point: pH:
(Water)
Very slight odor Soluble in water.
Odor: Solubility:
17.5 mmHg @ 68 Gray w/ Black and
Vapor Pressure: Appearance:
癋 / 20 癈 (Water) White Rubber Particles
Unknown 0.12 lbs/gal
Octanol/Water VOC (material):
Partition
SECTION 10. STABILITY AND REACTIVITY
Hazardous Polymerization: Product will not undergo hazardous polymerization.
Hazardous Decomposition: May form: carbon dioxide, carbon monoxide and
various hydrocarbons.
Chemical Stability: Stable under normal handling conditions.
Incompatibility: Avoid contact in uncontrolled conditions with:
strong oxidizing agents, halocarbon vapors and water reactive materials.
SECTION 11. TOXICOLOGICAL INFORMATION
Acute Toxicity Data:
Ingredient CAS # LD50 Oral-Rat LC50 Inhalation-Rat
Ethylene Glycol 107-21-1 4,700 mg/kg N/E
Diethylene Glycol 112-34-5 6,650 mg/kg N/E
Monobutyl Ether
Carcinogenicity: See Cancer Information, Section 3.
Mutagenicity: No significant evidence found.
Teratogenicity: No significant risk of birth defects or reproductive toxicity.
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity: No known hazards. This material should not be released to sewage,
draining systems or any body of water exceeding concentrations of approved
limits under applicable regulations and permits.
MATERIAL SAFETY DATA SHEET
Date Prepared: 04/19/04 Page: 5
Skid-No-More MSDS Number: 130014
SECTION 13. DISPOSAL CONSIDERATION
RCRA Hazardous Waste: This material as supplied, if discarded,
would not be regulated as a hazardous waste under RCRA (40 CFR 261).
Dispose of in accordance with applicable federal, state, and local
regulations.
RCRA Hazard Class: This material would be classified as EPA NON-RCRA.
SECTION 14. TRANSPORT INFORMATION
DOT Description: The DOT Classification for shipping is dependant on
quantity, type of packaging (a kit may include other components), or
method of shipment.
SECTION 15. REGULATORY INFORMATION
US Federal Regulations
TSCA (Toxic Substances Control Act) Status
TSCA (USA) The intentional ingredients of this product are listed.
CERCLA RQ - 40 CFR 302.4(a)
Component RQ (lbs.)
None
SARA Title III: Section 302- Extremely Hazardous Substances
None
SARA Title III: Section 313- Toxic Chemical List
Component CAS Number Percentage
Ethylene Glycol 107-21-1 1?%
International Regulations
EINECS (Europe) The intentional ingredients of this product are listed.
DSL (Canada) The intentional ingredients of this product are listed.
WHMIS Classification
Health Hazard: D2B (Other Toxic Effects)
Physical Hazard:
State and Local Regulations
California Proposition 65:
This product contains the following chemical(s) known to the state of
California to cause cancer. 4-VINYL CYCLOHEXANE, ETHYLENE OXIDE,
FORMALDEHYDE, 1,4-DIOXANE, ACRYLONITRILE, 1,3-BUTADIENE,
ACETALDEHYDE
This product contains the following chemical(s) known to the state of
California to cause birth defects or reproductive harm. ETHYLENE OXIDE,
1,3-BUTADIENE
MATERIAL SAFETY DATA SHEET
Date Prepared: 04/19/04 Page: 6
Skid-No-More MSDS Number: 130014
SECTION 16. OTHER INFORMATION
HMIS Rating: Health ?1, Flammability - 0, Reactivity - 0
Key- 0=Least, 1=Slight, 2=Moderate, 3=Serious, 4=Extreme, *=Chronic Effects
Other Precautions for Use: Keep material from freezing.
Additional Information may be obtained by calling the Evercoat MSDS Hotline at
1-800-729-7600.
NOTICE: The information accumulated herein is believed to be correct as of the date issued from
sources, which are believed to be accurate and reliable. Since it is not possible to anticipate all
circumstances of use, recipients are advised to confirm, in advance of need, that the information
is current, applicable and suitable to their circumstances.
|