PIRS Page 1 of 4
MATERIAL SAFETY DATA SHEET:POXY-PAC
DATE OF ISSUE: 12/06/2004 SUPERCEDES: 12/15/1995
SECTION I - GENERAL INFORMATION
Chemical Name & Synonyms: Trade Name & Synonyms:
N/A POXY-PAC
Chemical Family: Formula Mixture: X
EPOXY
Manufacturer's Name:
DYNA SYSTEMS A PARTSMASTER CO DIV OF NCH
Address:
P.O. BOX 655326
DALLAS, TEXAS 75265-5326
Prepared By: Product Code Number Emergency Phone Number
a santiago/Chemist 22114300 800-424-9300
SECTION II - HAZARDOUS INGREDIENTS
THE HAZARDS PRESENTED BELOW ARE THOSE OF THE INDIVIDUAL COMPONENTS
Chemical Name (Ingredients) Hazard TLV PEL STEL CAS #
HARDENER CLEAR PORTION)
POLYMERCAPTAN IRRITANT NOT EST. 1 NOT EST. 2 NOT EST. 101359-8-79
TRIS (DIMETHYLAMINOMETHYL) PHENOL IRRITANT NOT EST. 1 NOT EST. 2 NOT EST. 90-72 -2
STYRENE MONOMER IRR/CNS 20 PPM 1 100PPM 2 40 PPM 100-42-5
ETHYLENE GLYCOL IRRITANT 100MG/M3*1 NOT EST. 2 NOT EST. 107-21-1
AROMATIC RESIN IRRITANT NOT EST. 1 NOT EST. 2 NOT EST. 64741-81 -7
ALUMINA TRIHYDRATE IRRITANT NOT EST. 1 NOT EST. 2 NOT EST. 21645-51 -2
SILICA, AMORPHOUS, FUMED CRYSTALLINE-FREE NUIS. DUST 10MG/M3 1 6 MG/M3 2 NOT EST. 112945-52-5
BENZ(A)ANTHRACENE IRR/CARC NOT EST. 1 NOT EST. 2 NOT EST. 56-55 -3
RESIN (DARK PORTION)
ALUMINA TRIHYDRATE IRRITANT NOT EST. 1 NOT EST. 2 NOT EST. 21645-51 -2
REACTION PRODUCT OF EPICHLORAHYDRIN AND BISPHENOL A IRR/ALLR NOT EST. 1 NOT EST. 2 NOT EST. 25085-99 -8
EPICHLOROHYDRIN-4,4'-ISOPROPYLIDENE DIPHENOL RESIN IRR/ALLR NOT EST. 1 NOT EST. 2 NOT EST. 25068-38 -6
TITANIUM DIOXIDE IRRITANT 10 MG/M3 1 15MG/M3 2 NOT EST. 13463-67 -7
* CEILING
SECTION III - PHYSICAL DATA
Boiling Point (f): > 300篎 Specific Gravity (H20=1): R:1.68 H:1.40
Vapor Pressure (MM HG): <1 Color: R:BLACK H:CLEAR
Vapor Density (Air=1): N/A Odor: SHARP/BITTER
PH @ 100% : N/A Clarity OPAQUE
% Volatile by Volume: NIL Evaporation Rate (BU A/C=1): N/A
H20 Solubility: NEG. Viscosity: VISCOUS
SECTION IV - FIRE AND EXPLOSION HAZARD
Flash Point: Flammable Limits: LEL: UEL:
200篎 / T.C.C. N/A N/A N/A
Extinguishing Media:
Foam:X Alcohol Foam:X CO2:X Dry Chemical:X Water Spray: Other:
Special Fire Fighting Procedures:
FIREFIGHTERS SHOULD WEAR A SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE GEAR.
Unusual Fire and Explosion Hazards:
FIRE FIGHTERS SHOULD WEAR A SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE GEAR.
NFPA Hazard Rating: (0=Insignificant 1=Slight 2=Moderate 3=High 4=Extreme)
http://pirs.nch.com/MSDSPrintPage.asp 12/6/2004
PIRS Page 2 of 4
Health:2 Flammability:1 Instability:1 Special:0
SECTION V - HEALTH HAZARD DATA
Threshold Limit Value:
NOT ESTABLISHED FOR MIXTURE. SEE SECTION II.
Effects of Overexposure:
-Acute(Short Term Exposure)
CONTACT WITH UNCURED PRODUCT CAUSES IRRITATION SEEN AS ITCHING AND REDNESS. MAY CAUSE SKIN SENSITIZATION.
UNCURED MATERIAL CAUSES EYE IRRITATION SEEN AS ITCHING AND REDNESS. MAY CAUSE SKIN SENSITIZATION. UNCURED
MATERIAL CAUSES EYE IRRITATION SEEN AS PAIN, REDNESS AND/OR TEARS DUST CREATED BY SANDING IS MECHANICALLY
IRRITATING TO THE EYES. FUMES RELEASED DURING CURING MAY CAUSE RESPIRATORY TRACT IRRITATION SEEN AS
COUGHING AND SNEEZING. INHALATION OF DUST CREATED BY SANDING CAUSES IRRITATION, OF THROAT AND LUNGS,
COUGHING AND/OR BURNING. INGESTION OF LARGE AMOUNTS OF UNCURED MATERIAL CAN CAUSE PAIN, NAUSEA, VOMITING,
BLURRED VISION, CARDIAC FAILURE, KIDNEY DAMAGE, BRAIN DAMAGE. FULLY CURED MATERIAL IS NOT TOXIC BY INGESTION.
SEEN AS PAIN, REDNESS AND/OR TEARS DUST CREATED BY SANDING IS MECHANICALLY IRRITATING TO THE EYES. FUMES
RELEASED DURING CURING MAY CAUSE RESPIRATORY TRACT IRRITATION SEEN AS COUGHING AND SNEEZING. INHALATION OF
DUST CREATED BY SANDING CAUSES IRRITATION, OF THROAT AND LUNGS, COUGHING AND/OR BURNING. INGESTION OF
LARGE AMOUNTS OF UNCURED MATERIAL CAN CAUSE PAIN, NAUSEA, VOMITING, BLURRED VISION, CARDIAC FAILURE, KIDNEY
DAMAGE, BRAIN DAMAGE. FULLY CURED MATERIAL IS NOT TOXIC BY INGESTION.
-Chronic (Long Term Exposure)
PERSONS THAT BECOME SENSITIZED BY INITIAL SKIN CONTACT WITH UNCURED MATERIAL MAY HAVE ALLERGIC SKIN
REACTIONS SUCH AS RASH, STINGING, REDNESS AND SWELLING UPON SUBSEQUENT SKIN CONTACT. REPEATED LONG TERM
SKIN CONTACT WITH UNCURED MATERIAL POSES A CANCER RISK. REPEATED LONG TERM INHALATION OF VAPORS RELEASED
BY CURING CAN CAUSE DAMAGE TO THE CENTRAL NERVOUS SYSTEM. REPEATED INGESTION OF UNCURED MATERIAL CAN
CAUSE KIDNEY DAMAGE. MEDICAL CONDITIONS AGGRAVATED: PRE-EXISTING KIDNEY DISEASES. TARGET ORGANS: CENTRAL
NERVOUS SYSTEM, KIDNEYS, AND LIVER.
Primary Routes of Entry: Inhalation:X Ingestion: Absorption:X
Emergency and First Aid Procedures:
-Inhalation:
REMOVE FROM THE AREA TO FRESH AIR. SEEK MEDICAL ATTENTION IF RESPIRATORY IRRITATION DEVELOPS OR IF BREATHING
BECOMES DIFFICULT.
-Eye Contact:
IMMEDIATELY RINSE THE EYES WITH WATER. REMOVE ANY CONTACT LENSES AND CONTINUE FLUSHING FOR AT LEAST 15
MINUTES. HOLD THE EYELIDS APART TO ENSURE RINSING OF THE ENTIRE SURFACE OF THE EYES AND LIDS WITH WATER. GET
MEDICAL ATTENTION.
-Skin Contact:
IMMEDIATELY WASH AFFECTED AREAS WITH LARGE AMOUNTS OF SOAP AND WATER FOR 15 MINUTES. REMOVE
CONTAMINATED CLOTHING AND SHOES. SEEK MEDICAL ATTENTION IF IRRITATION PERSISTS. WASH CLOTHING AND CLEAN
SHOES BEFORE REUSE.
-Ingestion:
GIVE 3 TO 4 GLASSES OF WATER, BUT DO NOT INDUCE VOMITING. IF VOMITING OCCURS, GIVE FLUIDS AGAIN. GET MEDICAL
ATTENTION IF SYMPTOMS DEVELOP AND PERSIST.
-Notes to Physician:
SECTION VI - TOXICITY INFORMATION
Product Contains Chemicals Listed as Carcinogen or Potential Carcinogen By:
IARC: Yes NTP: Yes OSHA: Yes ACGIH: Yes OTHER: No
VOC CONTENT HARDENER: 14.3%;200 GRAMS/LITER 0.038% (VALUE FOR RESIN AND HARDENER TOGETHER)
VOC CONTENT HARDENER: 0.47%;7.9 GRAMS/LITER 0.038% (VALUE FOR RESIN AND HARDENER TOGETHER)
EPICHLOROHYDRIN-4,4'-ISOPROPYLIDENE DIPHENOL RESIN
SKN-RBT 2MG/24 SEVERE 3.
EYE-RBT 50 UG/24 SEVERE 3.
ORL-RAT LD50: 120 MG/KG 3.
SKN-RAT LD50: 1280 MG/KG 3.
STYRENE MONOMER
SKN-RBT 500 MG MILD 3.
EYE-RBT 100 MG SEVERE 3.
http://pirs.nch.com/MSDSPrintPage.asp 12/6/2004
PIRS Page 3 of 4
ORL-MUS LD50: 316 MG/KG 3.
IHL-MUS LC50: 9500 MG/M3/4H 3.
SILICA, AMORPHOUS, FUMED CRYSTALLINE-FREE
ORL-RAT LD50: 3160 MG/KG 3.
ETHYLENE GLYCOL
SKN-RBT 555 MG MILD 3.
EYE-RBT 100 MG/IH MILD 3.
ORL-RAT LD50: 4700 MG/KG 3.
IHL-HMN TCLO: 1000MG/M3: IRR 3.
BENZ(A)ANTHRACENE
SKN-MUS TDLO: 18 MG/KG 3.
SECTION VII - REACTIVITY DATA
Stability: Stable:X Unstable:
Conditions to Avoid: OPEN FLAMES, LONG-
TERM EXPOSURE TO HIGH
TEMPERATURES.
Incompatibility (Materials to Avoid):
STRONG OXIDIZING AGENTS, STRONG BASES OR STRONG ACIDS
Hazardous Decomposition Products:
OXIDES OF CARBON, NITROGEN, SULFUR AND ACRID SMOKE AND FUMES.
Hazardous Polymerization: May Occur: Will Not Occur:X
Conditions to Avoid: NONE KNOW
SECTION VIII - SPILL OR LEAK PROCEDURES
Steps to be Taken if Material is Released or Spilled:
DUE TO THE NATURE OF THE PACKAGING OF THIS PRODUCT, A LARGE SPILL IS UNLIKELY. WEAR NEOPRENE GLOVES AND
SCRAPE UP INTO LABELED CONTAINERS FOR PROPER DISPOSAL. CLEAN RESIDUE WITH SOAP AND WATER.
Waste Disposal Method(s):
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE, AND LOCAL REGULATIONS.
Neutralizing Agent:
N/A
SECTION IX - SPECIAL PROTECTION INFORMATION
Required Ventilation:
LOCAL EXHAUST IS RECOMMENDED TO CONTROL VAPOR LEVELS IF BURNED OR WELDED. GENERAL EXHAUST IS ADEQUATE
FOR NORMAL USE. LOCAL VENTILATION IS PREFERRED, BECAUSE IT PREVENTS DISPERSION INTO WORK AREAS BY
CONTROLLING IT AT ITS SOURCE.
Respiratory Protection:
WEAR NIOSH APPROVED AIR-PURIFYING RESPIRATOR IF THE POTENTIAL TO EXCEED ESTABLISHED EXPOSURE LIMITS EXISTS.
Glove Protection:
NEOPRENE OR NITRILE RUBBER GLOVES IF REPEATED OR PROLONGED SKIN CONTACT IS LIKELY.
Eye Protection:
CHEMICAL SPLASH GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS SHOULD BE WORN.
Other Protection:
SECTION X - STORAGE AND HANDLING INFORMATION
Storage Temperature: Indoors:X Outdoors: Heated: Refrigerated:X
Minimum Temperature:30 F Maximum Temperature:100 F
Precautions to be taken in Handling and Storing:
STORE IN ORIGINAL CONTAINER UNTIL READY TO USE. KEEP IN A COOL, WELL-VENTILATED AREA AWAY FROM HEAT, SPARKS
AND OPEN FLAME.
Other Precautions:
KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL BEFORE USING THE PRODUCT. FOLLOW THE LABEL DIRECTIONS.
http://pirs.nch.com/MSDSPrintPage.asp 12/6/2004
PIRS Page 4 of 4
SECTION XI - REGULATORY INFORMATION
Chemical Name CAS Number Upper % Limit
STYRENE MONOMER 100-42 -5 5
ETHYLENE GLYCOL 107-21 -1 5
Those Ingredients listed above are subject to the reporting requirements of 313 of Title III& of the Superfund Amendments and Reauthorization
Act of 1986 and 40 CFR part 372.
CALIFORNIA PROPOSITION 65
WARNING: This product contains the following chemical(s) know to the State of Californiato cause (1)Cancer or (2)Birth Defects or other
reproductive harm. THIS PRODUCT CONTAINS 1,4-DIOXANE (1);ACETALDEHYDE (1); ETHYLENE OXIDE (1); BENZ(A)ANTHRACENE (1);
FORMALDEHYDE (1); BENZENE (1)
SECTION XII - REFERENCES
1. THRESHOLD LIMIT VALUES FOR CHEMICAL SUBSTANCES AND PHYSICAL
AGENTS AND BIOLOGICAL EXPOSURE INDICES, ACGIH, 2004.
2. OSHA PEL.
3. REGISTRY OF TOXIC EFFECTS OF CHEMICAL SUBSTANCES, CCINFOWeb, 2004.
ALL THE COMPONENTS OF THIS PRODUCT ARE IN COMPLIANCE WITH THE TOXIC SUBSTANCES CONTROL ACT (TSCA) AND ARE EITH
--------------------------------------------------------------------------------------------------------------
IRR:IRRITANT, FLAM/FLAMM:FLAMMABLE, COMB:COMBUSTIBLE, CORR:CORROSIVE CARC:CARCINOGENIC, TOX:TOXIC, N/A:NOT AP
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE IN LIGHT OF CURRENT FORMULATION.HOWEVER
DYNA SYSTEMS A PARTSMASTER CO DIV OF NCHassumes no responsibility for personal injury or property damage caused by the use, storage,
http://pirs.nch.com/MSDSPrintPage.asp 12/6/2004
|