Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: PNEUMATIC-HYDRAULIC SEALANT 50 ML
Item No: 54550
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH TLV: TWA OSHA PEL:
TETRAETHYLENE GLYCOL 30-50 Not listed Not Listed
HEXOATE
18268-70-7
DIMETHACRYLATE ESTER 20-40 Not listed Not Listed
25852-47-5
2-HYDROXYETHYL 20-40 Not listed Not Listed
METHACRYLATE
868-77-9
10 mg/m3 total dust TLV 10 mg/m3 total dust
TREATED SILICON DIOXIDE, <4
SYNTHETIC, CRYSTALLINE-FREE
67762-90-7
DIMETHYLBENZYL <4 Not listed Not Listed
HYDROPEROXIDE
80-15-9
PROPYLENE GLYCOL <4 Not listed Not Listed
57-55-6
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. May cause nose, throat and respiratory irritation. Ingestion may irritate
Toxicity:
digestive tract and cause nausea, vomiting and diarrhea. Note: This product does not contain
microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
May cause redness to eyes and irritation to nasal passages. Repeated skin contact may cause allergic
Signs and Symptoms of Exposure:
skin reactions.
Preexisting skin disorders.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Oxygen or artificial respiration if needed.
Inhalation:
Obtain medical attention.
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
>200癋 TCC
Flash Point (癋/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Oxides of carbon
Hazardous Products of Combustion:
None.
Unusual Fire/Explosion Hazards:
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
1 of 3
Product Name: PNEUMATIC-HYDRAULIC SEALANT 50 Item No: 54550
ML
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store below 100 degrees F.
Storage:
Avoid prolonged skin contact. Keep away from eyes. Do not inhale vapors.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Rubber or plastic gloves.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Purple liquid
Appearance:
MILD
Odor:
>300癋
Boiling Point:
Does not apply
pH:
Slight
Solubility in Water:
1.00-1.15
Specific Gravity:
<4%
VOC Content(Wt.%):
<5 mm Hg @ 25癈
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
MAY OCCUR.
Hazardous Polymerization:
Metal salts, heat and amines.
Incompatabilities:
Heat.
Conditions to Avoid:
Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
Unrestricted
Proper Shipping:
2 of 3
Product Name: PNEUMATIC-HYDRAULIC SEALANT 50 Item No: 54550
ML
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 0.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: February/26/2008
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 1
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.: